2019 Ford F-150 steering problems

Filed Oct 2, 2026 · Brakes, Electrical · 92,004 miles · MN

The contact owns a 2019 Ford F-150. The contact stated that after hauling a travel trailer and unhooking the vehicle, the parking brake and other lights started flashing and the instrument panel illuminated. The 911 assist was disabled. A part of the power steering was inoperable. The floorboard was saturated with water, which damaged the wiring harness. The driver was unaware because of the rubber floor mats. A mechanic suggested that the contact disconnect the battery. The parking brake failed to release. The contact associated the failure with TSB: 20-2170. The vehicle was taken to the local dealer. The manufacturer was contacted and opened a case. The failure mileage was 92,004.

Filed Aug 2, 2026 · Steering · FL

Its a sensor that marks the wrong temperature n the truck

Filed Jun 26, 2026 · Electrical, Engine · NJ

While driving my vehicle (2019 Ford F150), it suddenly came to a complete stop. The engine shut off and the steering wheel locked up. While in the middle of a roadway, I had to quickly throw my vehicle into park, turn it off and back on. At that point, it was running again and I was able to safely get it to a dealership where it was inspected for an issues. There were no warnings, alerts or messages on my dashboard. The dealership confirmed what had happened. It was due to the electronic steering system failing. They fixed it and so far there has been no issues. This is not the first time I have heard of this happening and after researching, it appears it is more common than not. I believe, because of the risk of this vehicle unexpectedly and suddenly stopping on any roadway, a recall should occur. I could not imagine what would happen if one of my loved ones had been driving and a serious crash occurred.

Filed Jan 29, 2026 · Airbags, Steering · FL

Center piece of steering wheel is cracked

Filed Nov 14, 2025 · Steering · FL

Sudden total loss of power steering on 2019 Ford F-150 XL Regular Cab 2WD, 3.3L V6 (VIN [XXX] , 170,000 miles). Purchased used in 2024 with clean Carfax — no accidents, no damage, no odometer issues. Sarasota Ford diagnosed multiple internal lost communication codes and failed pinpoint test — requires EPAS rack replacement ($2,700). Ford denied goodwill case XXX (escalated to supervisor Shaniqua) — based solely on mileage, despite: • TSB 19-2306 • SSM 51226 • 1,200+ the federal safety agency complaints for 2015–2019 F-150 EPAS • Lincoln v. Ford lawsuit (Case 1:19-cv-02741) covering 2019 models Rep Haley stated “safety is not a deciding factor”. High crash risk — nearly lost control in traffic. Clean Carfax proves no abuse — mileage must not override a known safety defect. Sincerely [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 4, 2025 · Engine, Steering · 55,000 miles · OH

The contact owns a 2019 Ford F-150. The contact stated that the vehicle lost motive power while depressing the accelerator pedal, and hesitated while accelerating after a complete stop. The contact stated that occasionally the check engine warning light illuminated, and the dipstick was checked, and the engine oil was low. The vehicle was taken to a dealer, and an oil and oil filter change was performed as part of an oil consumption test. On the next visit for an oil change, the dealer discovered that the engine was consuming a quart of engine oil between oil changes. The contact inspected the vehicle and discovered that the engine was consuming three quarts of engine oil between oil changes. The vehicle was taken back to the dealer ,where a diagnostic was performed, and the contact was informed that the engine needed to be replaced. The manufacturer was notified of the engine failure and the manufacturer spoke with the dealer about the repair. The contact was later informed that the manufacturer would not assist with the cost of replacing the engine. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. Recently, while driving 15 MPH and towing a trailer, the electric power steering assist failed and the messages "Steering Assist Fault", Traction Control" and "ABS Fault" were displayed. The contact used excessive force to steer the vehicle back to the residence. The vehicle was taken back to the dealer and was diagnosed with a defective rack and pinion. The vehicle was not repaired. The failure mileage was approximately 55,000.

Filed Apr 16, 2025 · Electrical, Engine · GA · 1 injury

The truck would just shut off while driving or not start whenever you need it to. It acts like a dead battery but the battery is fine. It has been at the dealership for 45 days plus straight for this issue. When it cuts out, we lose all steering all breaking all power. I’m very lucky it hasn’t taken my life or one of my family members lives. There are some innocent person on the road because of The lack of quality and workmanship. In my opinion the truck needs to be recalled because it’s been nothing but a hassle for us.

Filed Mar 28, 2025 · Steering · TX

Loss of power steering resulting in steering gear needing to be replaced.

Filed Feb 17, 2025 · Steering · NY

The vehicle steering wheel turns by itself, without warning, causing me to fight the steering wheel to maintain proper control and direction. I reported the issue to my mechanic and had him inspect and paid $129 to have a full alignment. After a road test, the problem still exists. The mechanic deemed the problem as "dangerous to drive". After contacting ford the recall referenced 24S45. supposedly Ford has yet to come up with a fix.

Filed Dec 16, 2024 · Airbags, Steering · 58,814 miles · TX · crash

The contact owned a 2019 Ford F-150. The contact stated that while his son was driving approximately 25-35 MPH, the steering function failed, and the vehicle veered to the right. The driver attempted to turn to the left, but the steering was inoperable. The vehicle went over a curb and crashed into two mailboxes. There were no reported injuries or fires. The air bag warning was illuminated, but the air bag cover detached, and the air bag failed to deploy. A police report was filed. The contact stated that the failure was related to the federal safety agency Campaign Number: 14V316000 (Steering). The vehicle was towed to a body shop. The contact called the local dealer, who informed him there was no recall coverage. The vehicle was not diagnosed or repaired. The manufacturer was contacted, who opened a case and referred to the federal safety agency hotline. The vehicle was deemed a total loss by the insurance company. The failure mileage was approximately 58,814.