2019 Ford F-150 brakes problems

Filed Oct 2, 2026 · Brakes, Electrical · 92,004 miles · MN

The contact owns a 2019 Ford F-150. The contact stated that after hauling a travel trailer and unhooking the vehicle, the parking brake and other lights started flashing and the instrument panel illuminated. The 911 assist was disabled. A part of the power steering was inoperable. The floorboard was saturated with water, which damaged the wiring harness. The driver was unaware because of the rubber floor mats. A mechanic suggested that the contact disconnect the battery. The parking brake failed to release. The contact associated the failure with TSB: 20-2170. The vehicle was taken to the local dealer. The manufacturer was contacted and opened a case. The failure mileage was 92,004.

Filed Sep 16, 2026 · Brakes · WI

The brake master cylinder on my 2019 F150 had a seal leak which caused all brake fluid loss while towing with my family. Luckily we were able to stop safely, not only for us but others nearby. I know this is a recall that affects vehicles in other years but mine was not included and I feel like it should be because we had total brake failure. This is already documented by Ford recall number 25S37 (which aligns with the federal safety agency's number 25V‑236). I feel like Ford needs to expand the recall to other years as it seems the defective part is more widespread to the ones they recalled. I had a Ford dealer replace the master cylinder and brake booster which is Ford's recommendation based on the rear seal leak of the master cylinder. A low brake fluid warning was all that appeared and by the time I was going to safely stop to check fluid level, there was no braking pressure.

Filed Jul 6, 2026 · Brakes, Transmission · CA

The front passenger brake caliper came completely off when I was driving.the only warning I had was when my brake pedal went straight to the floor when depressed.i was forced to pull into a gas station and keep driving in circles till the vehicle slowed enough to drive into a curb to stop so I could put the vehicle in park.i then had my vehicle towed home and replaced the part myself as I dont feel comfortable taking my vehicle to the dealership to be worked on because of past experiences. The other issue is when I accelerate my pcm goes into what I would call it as limp mode.the vehicle has no power to accelerate and it happens randomly.it will stay like that until the vehicle is turned off and key removed for atleast 15 minutes.when started back up it is back to normal but if the accelerator pedal is push to quickly it will go back Into limp mode if I put the vehicle in sport mode it happens almost immediately. Also the transmission has random down and upshifts and shifts very harshly at times.i drive over a mountain pass atleast 5 times a month and have been stuck on the side of the road multiple times waiting for my vehicle to go back to normal to make it over the pass.

Filed May 11, 2026 · Brakes, Transmission · 86,000 miles · LA

The contact owns a 2019 Ford F-150. The contact stated that while pressing the brake pedal a grinding noise was present coming from the frontend of the vehicle. While inspecting the vehicle the husband discovered that the brake vacuum line was damaged. The vehicle was taken to the local dealer who replaced the four wheel drive vacuum hose. After retrieving the vehicle the failure reoccurred and the vehicle was taken back to the local dealer who installed a vacuum tube and actuator assembly but the failure continued to occur. The manufacturer was not yet contact regarding the failure. The failure mileage was 86,000.

Filed Jun 11, 2025 · Brakes · 118,000 miles · GA

The contact owns a 2019 Ford F-150. The contact stated that while operating the vehicle, the check engine warning light was illuminated. The vehicle was taken to the local mechanic who diagnosed that the brake fluid hose had ruptured while rubbing on the steering column. The contact was advised that the brake fluid hose needed to be replaced. The manufacturer was notified of the failure, but no assistance was offered. The vehicle was not yet repaired. The failure mileage was 118,000.

Filed Apr 21, 2025 · Brakes · MN

All of a sudden I lost almost all braking. Brake light came on and a message saying low brake fluid prompted on screen. I see this was recalled for the 3.5l ecoboost. Why wouldn’t this be recalled for the 2.7l eco boost? Reading online it seems I had the same problem other people had.

Filed Jan 13, 2025 · Brakes, Engine · NH

When pressing the gas pedal to accelerate , the truck will not accelerate rather it begins to rev the engine loudly (as if the gas pedal was being pushed while the truck is in neutral) the RPM shoots high to 6-7 (again the truck isn’t accelerating any faster just loudly revving,) then the truck jolts as if it has just been rear ended. The shifting is stuttering staying stuck in 3rd and 4th gear severing going back to 1 even at a stop. Vehicle messaging alerted 1/10/25 powertrain malfunction /reduced power . However this issues has been going on and Ford Said it was related to a 4x4 control module which was replaced and yet the issues continue. Brought it back to ford because the problem was not fixed and they are asking for payment of additional diagnostic testing and NOW saying it’s a transmission issue AFTER saying it was issue with the control module unit. Work was completed 10/2024 at Ford

Filed Jan 4, 2025 · Brakes, Transmission · AL

Having major issues with the auto stop control, it has turned the truck off while sitting in the middle of an intersection, has stalled my truck multiple times in busy areas of on coming traffic, has shortened my battery life and my starter, and it has shown different warning icons. The power train is also acting up by hard shifting, not wanting to switch gears, skipping gears, and also making it difficult to pin point problem. My rear left brake functions are causing an issue as well, some function is making my brakes either stick or something because I get a burning odor constantly coming from my rear wheel even after changing my brakes and rotors.

Filed Sep 16, 2024 · Brakes, Electrical · MA

While driving 65mph on I-495 on a +90 degree day in August my 2019 Ford F-150 Lariat 4x4, the horn of the F-150 beeped. It beeped again a couple more times then the F-150 powered down forcing me to coast through some lanes of traffic to reach the break down lane. ABS and maintenance due light were both illuminated. My code reader said a switch was shorted so I cleared codes to retest. I restarted the truck and after re-boott was able to drive the vehicle home. Not associated with this enroute power failure incident, I notice intermittent rough idle issues, a tail gate that opens by itself 24/7 with alarm and it is now normal for this F-150 to burn 3-4 quarts of extra oil between each oil change.

Filed Aug 19, 2023 · Brakes · IL

I bought this truck last April, and have not had an issue like this since I bought it. Today, when I got off the highway I made a stop on a light and proceeded on a road (45mph) about a quarter mile down I felt my truck slowing down and all of the sudden it stopped in the middle of the road. I gave it a little gas but it didn’t move much, at first I thought the transmission blew but I didn’t have any lights illuminated nor did I hear any noises. The road I was on was on an incline so I put the truck into neutral and the truck stood still, the brakes felt odd, stiffer than usual. To make a long story short I managed to pull into a parking lot, and started to inspect the vehicle. The rotors were very hot, so I thought maybe something is wrong with the brakes. I opened the hood and I started disconnecting vacuum hoses, one of the hoses closest to the brake booster was stuck and as I disconnected it I heard a loud hiss of air suction. I plugged it back in and started the truck, I put it in N and it started to roll again, and I regained normal brake pedal feeling. On the uploaded image, I circled where I disconnected the vacuum line.