2025 Ford F-250 SD problems

Filed Oct 2, 2026 · Seats · MI · crash · 2 injuries

During collision seat did not retain its upright position and collapsed/reclined backwards fully.

Filed Sep 22, 2026 · NC · fire

Driving for 10 minutes when I started smelling a burnt smell. 30 to 45 seconds later I noticed smoke coming out the vents. A few seconds later (while at a stop sign at this point) I see smokecoming out of the hood. Vehicle would not go into park. After several attempts I finally was able to get the vehicle in park and get it to shut off. Opened the hood, saw a small 1 inch flame behind the motor near the firewall on the driversside and immediately called the fire department or emergency responders. Within 3 mins my vehicle was up in flames for a catastrophic vehicle loss.

Filed Jun 25, 2026 · Lights · FL

For years FORD vehicles, especially pickup trucks, have blinded drivers with their improperly adjusted headlights; because FORD gives incorrect instructions to adjust them. I refer to page 474 of the 2025 Superduty owners manual as evidence. The instructions FORD gives are to set the low-beam LEVEL, shinning the beam onto a vertical surface 25 feet from the vehicle with the beam at the same height as the headlight on the truck. This is incorrect. There should be at least a 3 inch drop of the low-beam at 25 feet. If there is no drop of the tall truck's headlight (the F-250 stock ride height of the headlight is 44 inches above the ground) it will always blind other drivers of cars/sedans--especially via the outside mirrors. This problem has become acute now that the extra bright LED headlights are becoming the norm; making two-lane roads on a rainy night a truly blinding experience. Please require FORD to correct their dangerous mistake.

Filed Jun 12, 2026 · Steering, Suspension · 13 miles · FL

The contact owns a 2025 Ford F-250. The contact stated that while driving at various speeds, the steering wheel inadvertently turned to the right, then pulled to the opposite direction. The contact stated the steering wheel was cocked to the left or right even though the vehicle was driving straight down the road. There was no warning light illuminated. The contact stated the failure was due to the steering angle sensor. The vehicle was taken to the local dealer, where it was diagnosed that an alignment was needed. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, and a complaint was filed. The failure mileage was approximately 13.

Filed Mar 19, 2026 · Steering, Suspension · IL · crash

The contact was an insurance company that called on behalf of the previous owner. The contact's Insurance Company took possession of a 2025 Ford F-250. The contact stated that while driving at an undisclosed speed, a loud popping noise was heard coming from the vehicle with no warning lights illuminated. The contact stated that following the failure, the driver lost control of the vehicle, which resulted in a collision with another vehicle. The contact also stated that a tire unexpectedly detached from the vehicle during the incident. The vehicle then veered off the roadway and collided with a tree, where it came to a stop. No injuries were sustained, and no medical attention was required. A police report was filed. The contact confirmed that the air bags deployed during the crash. The vehicle was towed from the scene and deemed a total loss by the insurance company. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The contact mentioned that there was an unknown Ford recall regarding the suspension but was unable to reach Ford to confirm if the VIN was associated. The failure mileage was not available.

Filed Feb 18, 2026 · Brakes · CA

I have about 6,000 miles on the vehicle which was purchased new. There were 2 incidents prior to 2/15/26 (the 3rd incident), but it was only this 3rd incident whereby I could identify the problem. The 2 early incidents I only experienced the smell of burning rubber when driving and exiting the vehicle. Which, i couldn't fathom where it was coming from. And, there was probably a month between incidents. This latest 2/15/26 incident, I was driving and started smelling rubber again, but now I happened to have my fuel mileage indicator on and saw my fuel indicator drop from it's normal average of 17mpg to about 6 mpg. I immediately suspected the parking brake had independently engaged but there was no light or any indication of that on my dashboard screen. I pulled over, turned the engine off, got out and smelt strong scent of rubber burning. While standing next to the vehicle (the engine is off mind you) and making a note of this event on my phone, I heard hydraulics start and stop underneath the truck . That made me suspect the parking brakes even more. I got in, started up, and drove. All was back to normal, no more burning rubber or bad mileage. There's a software glitch PROBLEM here and I have to believe I'm not the only one! After this, I'll be reaching out to Ford to see what they're going to do.

Filed Feb 2, 2026 · SD

I was driving down HWY 79 in South Dakota. It was 3:00 pm on Saturday Jan. 31st. Out of know where, with not a single vehicle within eyesight, my sunroof exploded. It sounded like a gun shot went off right above my head, and there was glass flying everywhere. This 100% was not due to another vehicle throwing an object up in the air. There was not another vehicle anywhere. After researching this on the internet, it seems this is a reoccurring issue with these Fords that Ford is not taking accountability for. I called the local dealer and was told it would not be covered under warrantee.

Filed Jan 20, 2026 · Electrical · SC

The info system (Bluetooth) is not working and makes a high piercing noise. The vehicle is available for inspection upon request. The safety of others is at risk due to the fact that you can only use your phone in your hand in this vehicle. The state of South Carolina where this vehicle was purchased and used passed a law on September 1, 2025 (Hands-Free and Distracted Driving Act) banning handheld cell phone use. The vehicle has been to two different Ford dealerships and has been at the most recent since December 3, 20025 until present. The vehicle has been inspected with several attempts to repair without success.The problems started the first week of ownership with no prior warning.

Filed Jan 20, 2026 · Driver assistance · OK

The pre collision system on this truck is not working, dealer tried twice to fix it and says it is working, but they can’t test it and make it work in real word conditions.

Filed Jan 6, 2026 · Brakes · NE

When backing up the brakes will lockup