Check a VIN

2016 Ford Fusion wheels problems

43 complaints (3% of all complaints for this car). Typical mileage when it fails: 50,425. 1 crash reported.

owner complaints
43
of this car's complaints
3%
typical mileage
50,425
crashes
1
recalls
0

Which part fails

  • Lugs/nuts/bolts/studs
    19

At what mileage

Complaints by mileage at the time of the problem.

0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+

Ford Fusion wheels problems in other years

2006201020152020

Related recalls

No recalls on record for this model year.

What 2016 Ford Fusion owners say

Most recent owner complaints, unedited.

Filed Jan 1, 2026 · Suspension, Wheels · MN

Considering your experience of losing total control of the vehicle even while driving slowly while following a snowplow vehicle dispensing road deicer while plowing; I have a strong suspicion that his has happened in 2024 as well when the vehicle had registered a drive issue and the dealership found now existing reason for it. The compacted snow forms a large layer of snow and ice in the wheel wells to the point that it is rubbing on the tires all around the wheel wells. As this icy snow hardens while the vehicle is parked; it is dangerous to drive on any road surface in this condition at any speed. While the danger was less in the past due to not driving to Cass Lake, Minnesota from Bemidji, Minnesota and back nearly every other day; it has become critical this winter because of the high increase in winter snowy road driving that you are currently doing. Even though doing Hemo-Dyalisis at home decreases the danger; this vehicle is at risk of suddenly going out of control during winter snowing highway driving conditions if ice and snow builds up around the tires where it can suddenly release and jam tires from turning. You need to be aware of the danger you place yourself and other motorists in if you are driving this Ford Fusion Energi while in these dangerous driving conditions. In the past I have seen the condition of ice and snow buildup in the front and rear wheel wells to the point that there is less than one half inch of clearance between the tires and the ice/snow buildup. I did not allow you to drive it that way until I had chopped and removed it from around the tires and wheel wells.

Filed Dec 23, 2025 · Brakes, Wheels · LA

The contact owns a 2016 Ford Fusion. The contact received notifications of the federal safety agency Campaign Numbers: 23V162000 (Service Brakes, Hydraulic) and 25V695000 (Back Over Prevention). The contact stated that the dealer had sent a mobile mechanic to the contact's residence to complete the recall repair of the federal safety agency Campaign Number: 23V162000 (Service Brakes, Hydraulic). During the day, the contact checked the residence ring camera and noticed that two mobile mechanics had stopped by the residence to work on the brakes. The contact stated that after a while, both mechanics left the residence and left the hood of the contact's vehicle lifted. The contact stated that the mechanic returned after a while and continued servicing the vehicle. The contact noticed that the mechanic had difficulty with the lug nuts on the wheels and had to fracture the lug nuts to remove the wheels. The contact noticed that the mechanic had reinstalled the fractured lug nuts back on both front wheels. The contact had not test-driven the vehicle. The manufacturer was not made aware of the issue. Â The mileage was unknown.

Filed Oct 27, 2025 · Body, Brakes · MD · crash

On [XXX], Plaintiff [XXX] was in urgent need of replacing the front passenger side tire on his vehicle. He began searching online to compare automotive service providers, focusing on those offering competitive pricing and professional-grade installation. During my search, 1 came across Mr. Tire's website, which prominently displayed claims such as "Expert installation for less" and "Quality service for superior stopping power." According to their site, their tire installation package included: • Tire mounting and wheel balancing • Standard valve stem replacement • TPMS inspection and reset • Wheel alignment check • Precision wheel torque by hand tools • Lifetime tire rotation • Lifetime rebalancing Believing this was a comprehensive and professional service package, I scheduled an appointment at Mr. Tire, located at 5 Bel Air South Parkway, Bel Air, MD 21014 (Store #771). Upon arrival, I checked in with the store manager, Brianna Adams, who prepared my service contract. She explained the total cost for installing the new tire would be $191.53. The technician assigned to my vehicle was J. Foster, as listed on the service agreement and receipt. On [XXX], while driving, I was involved in a serious accident. The front passenger side tire completely detached from the vehicle while in motion, causing the car to slam into the ground. I was severe risk of injury or death. The way I've taken this to court as / went back and looked at the reviews as of today's date October 18th 2025 they still are committee, consumer fraud, unsafe, work practices, deceptive business practices, and are putting the community and the residence of the state of Maryland and beyond at risk from unsafe work practices and I have submitted the reviews as a PDF as an attachment to this complaint I am requesting for investigation into their business for unsafe work practices and 49 U.S.C.§ 30101 (Purpose and policy)Maryland Transportation Code § 22-405 and § 21-101 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

Filed Aug 8, 2025 · Wheels · SD

Lug nuts are swollen and need replacement. Ford service department informed me that lug nuts are aluminum clad steel and over time swell and are unusable. Further informed that this is a common problem with ford products, but ford will not replace the lug nuts. Safety risk: Consumer would be unable to remove & reuse factory original lug nuts if a tire replacement were necessary away from a ford service facility. This condition is only diagnoseable when attempting to remove the lug nuts for service. I feel that any competent engineer could foresee that mixed metal will develop an electrolytic reaction and, further, that ford willingly continues this practice.

Filed Jan 15, 2024 · Wheels · CT

Stamford Ford in Stamford CT said I need to replace frozen lug nuts due to corrosion. they said it is not covered and I have to absorb the cost of $ 300. All service on this vehicle have been performed by ford service department. a recall should have been issued to correct this issue. this is a safety issue and FORD must fix this at their cost, not the customer's.

Filed Nov 29, 2023 · Wheels · 120,000 miles · TN

The contact owns a 2016 Ford Fusion. The contact stated that upon taking the vehicle to the dealer for service, he was made aware that the driver’s and passenger’s side front wheel lug nuts were severely deformed. As a result, the dealer declined to complete the service due to safety concerns. The vehicle was not repaired. The manufacturer was notified of the failure but did not assist. The failure mileage was 120,000. The VIN was not available.

Filed Nov 29, 2023 · Brakes, Wheels · TN

Ford Dealership is refusing to preform the brake line recall 23S12, if I do not purchase new lug nuts saying that they are swollen, deformed. I called the corporates number and they told me they are aware of the issues with the lug nuts, but also said I would have to pay out of pocket for them to preform the brake line recall. I'm now worried about the condition of the lug nuts since the hold they wheel on as well as the brake line in the above mentioned recall which they are refusing to service without taking payment over a recall !!!

Filed Oct 26, 2023 · Wheels · 22,545 miles · TN

The contact owns a 2016 Ford Fusion. The contact stated that the vehicle was at the dealer for a scheduled service appointment; however, the service could not be completed because the bolts were swollen. The contact was informed that the bolts for all four wheels needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the federal safety agency Hotline. The failure mileage was approximately 22,545.

Filed Jul 21, 2023 · Wheels · MN

the lug nuts had swollen and were not able to loose without damage. In order to rotate my tires the dealership had me pay for new lug nuts. If they the parts were that cheaply made at the factory, why am i asked to pay for them.

Filed Jun 25, 2023 · Wheels · AL

Lug wrenches don't go on lugs. Can't remove lugs.

Questions about the 2016 Ford Fusion wheels

Does the 2016 Ford Fusion have wheels problems?

Owners have filed 43 complaints about the wheels of the 2016 Ford Fusion, 3% of all its complaints.

At what mileage do 2016 Ford Fusion wheels problems start?

The typical (median) mileage in owner complaints is 50,425 miles.

Was there a recall on the 2016 Ford Fusion wheels?

There is no recall for this problem on this model year.

What year does the Ford Fusion have bad wheels?

The Ford Fusion model years with the most wheels complaints are 2010 (143 complaints), 2011 (49 complaints) and 2016 (43 complaints).

Other 2016 Ford Fusion problems

Engine 536Transmission 311Driver assistance 181Steering 176Electrical 150Brakes 137Fuel system 92Airbags 50Body 50Acceleration 47Locks 35Visibility 26Seat belts 17Lights 16Seats 8Suspension 8Tires 4

VIN decoder

See the problems and recalls for an exact car

Buying a used 2016 Ford Fusion?

Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.

Check its history