On [XXX], My car began attempting to overheat. This caused me to stop, and park the car until it cooled down, multiple times. (Unsafe) All of my fluids have been filled and checked occasionally prior to this. After multiple roadside trips, I presented my car to AutoNation FORD which is located on Philips Highway in Jacksonville, Florida. An inspection was performed on my vehicle over the weekend which proved my car in fact has a coolant intrusion which is the Latest Recall for the Ford Model. The dealership informed me that my car does not qualify under the recall due to the mileage of the vehicle which is currently 130k. This seems so unfair because I did not do anything wrong that led to this. I am unable to drive my car a mile or 2 without it trying to overheat. This is a risk and I do not feel safe operating this vehicle. It was also very displeasing hearing that operating the unsafe vehicle is my only other alternative besides coming out of pocket with 14k. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2018 Ford Fusion engine complaints
Page 5 of 10: complaints 101 to 130 of 274, newest first, as owners wrote them.
The contact owns a 2018 Ford Fusion. While the contact's daughter was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the check engine warning light and several other unknown warning lights were illuminated. The vehicle was taken to several independent mechanics; however, the vehicle was not diagnosed. The vehicle was not repaired. The vehicle was towed to the dealer where it was diagnosed with a coolant leak in the engine and engine failure. The contact was informed that the engine and the cylinders needed to be replaced. The vehicle was repaired. The contact was informed of an Extended Warranty Program; however, the contact was informed that the mileage had been exceeded by 9,000 miles. The contact was informed that the repair was not covered under the extended warranty. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 93,451.
The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated, and the vehicle was driving rough. In addition, the contact noticed that the engine was consuming an excessive amount of coolant. The failure progressed, and the engine started overheating. The vehicle was towed to the dealer where it was diagnosed with a cracked engine and coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and provided no assistance. The contact referenced Technical Service Bulletin: 22-2134; however, the contact was informed that the repair was not covered under the program. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 27,800.
The contact owns a 2018 Ford Fusion. The contact stated while driving 45 MPH, the message "Coolant Temperature Overtemperature" was displayed, causing the vehicle to decelerate. The contact stated that another message advising that the engine power was reduced, and to pull to the side of the road was displayed. The contact pulled to the side of the road and checked the coolant level. The contact noticed that the coolant was overheating and leaking. The contact added coolant to the vehicle. The contact stated that the failure recurred intermittently. Additionally, the contact stated that the engine was misfiring on cold starts. A message advising to service the engine soon was displayed. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the engine, and the dealer determined that the short block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 21N12 due to the mileage. The failure mileage was approximately 120,000.
The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 30 MPH, the "Engine Overheated Idle Engine" message was displayed on the instrumental panel. The check engine warning light was illuminated. The vehicle was taken to a dealer to be diagnosed and it was determined that the engine needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 102,405.
The contact owns a 2018 Ford Fusion. The contact stated while driving at various speeds, the vehicle shuddered and white smoke came out of the exhaust pipe; there was an abnormal sound coming from the engine compartment. The "Engine Coolant Overtemperature" message was displayed on the instrument panel and the check engine warning light was illuminated. The failure occurred on several different occasions. The vehicle was taken to a dealer where it was diagnosed that there was a coolant leak intrusion into the cylinder and that the engine needed to be replaced. The dealer made the contact aware of Technical Service Bulletin Number: 19-2346. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that there was no recall associated with the failure; the manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 111,700.
The contact owns a 2018 Ford Fusion. The contact stated while driving at 35 MPH, the check engine warning light illuminated. The vehicle was able to restart on the third attempt however the failure recurred. The vehicle was driven to the dealer where it was diagnosed that the engine and the cylinder heads needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was 13,000.
The contact owns a 2018 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an engine misfire with the check engine warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the spark plugs had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 122,000.
The contact owns a 2018 Ford Fusion. The contact stated while driving 50 MPH, the check engine warning light illuminated, and the vehicle started sputtering. The vehicle was taken to an independent mechanic, where it was diagnosed with coolant intrusion in the engine. The vehicle was then taken to the dealer, where it was diagnosed with coolant intrusion in the engine. The dealer determined that the short block needed to be replaced. The dealer informed the contact that the failure was related to Ford Campaign Number: 21N12; however, the vehicle was not covered due to the mileage. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that a notice for Ford Campaign Number: 21N12 was previously sent; however, the contact had not received the notice. The failure mileage was approximately 120,000.
The contact owns a 2018 Ford Fusion. The contact stated while his wife was driving 60 MPH, the wrench symbol became displayed. The power train fault warning light was illuminated. The vehicle started to shake with the check engine warning light illuminated. The power steering was inoperable. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 58,000.
The contact owns a 2018 Ford Fusion. The contact stated while attempting to start the vehicle, the vehicle took approximately three minutes to start. The vehicle started after several attempts. The contact stated while driving at approximately 35 MPH, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the vehicle needed a tune up and an oil change. The vehicle was repaired but the power train warning light illuminated. The manufacturer was notified of the failure. The failure mileage was approximately 96,000.
Driving down the interstate and lost power due to rough running engine. I barely made it to the emergency lane before someone hit me. Coolant intrusion in the cylinders cause the engine malfunction. Ford is fully aware of this problem and refuses to help.
The car overheated and threw the code p1299, pulled over and there was no visual coolant leak. Put coolant in it and drove it to the garage a few days later, they told me coolant has leaked into the block and that I will need a whole new cylinder block and head gasket. Looked up recalls for my type of car and it showed 2013-2018 ford fusions have recalls about my problem and showed the symptoms and my car has every symptom of that recall but yet there is no active recall for my car.
Engine has misfire in cylinder one from coolant intrusion. TSB 22-2229. Engine coolant leak can cause many problems for the engine and other components to fail and even break. Dealership confirmed, they’re are other fusion models and same engines with the same problem in the 2.0l. There were no previous lights on the dashboard the car is maintained well.
The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle was smoking with the engine overheating. The wrench symbol was displayed and was flashing on and off. The engine warning light was illuminated and flashing on and off. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The vehicle was taken to the local dealer, where it was diagnosed that the thermostat housing was leaking. The vehicle was not repaired. The manufacturer was contacted, and informed the contact that there was no recall coverage for the failure. The contact was referred to the local dealer for assistance. The failure mileage was approximately 76,422.
2018 fusion ecoboost with no lights or warnings would not start. Took to ford to repair, took them several weeks and several of the same part to fix crankshaft position sensor. Was given a clean bill of health on car. Everything was I'm good condition they said after I paid the 1500.00$ repair bill. Less than 1 week later the car dies while on highway going 65 mph without warning. No lights, nothing. Just sputtered and died. Done all I could to get out of the way so I would not be hit on highway. Catastrophic engine failure resulting in engine locking up had occurred. This car has been taken care of, less than 75k miles on it and the engine is garbage. I lost my job, almost lost my life, lost my home, over half of my possessions all as a direct result of this faulty car that was designed to fail. Ford knows about this engine problem, they continue to sell these cars and refuse to pay for repairs or recall them.
The contact owns a 2018 Ford Fusion. The contact stated that the vehicle had experienced rough starts and there was a slushing liquid sound coming from inside the dashboard. Additionally, while operating the vehicle the check engine warning light remained illuminated and the vehicle stalled. The vehicle was taken to the local dealer who diagnosed that the engine block was cracked and causing coolant to leak into the engine. The contact was advised that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 120,000.
While driving, the low oil pressure warning light illuminated on the dashboard. Within 5-10 minutes, the vehicle began to lose power and struggled to maintain speed. Over the next 15 minutes, the vehicle's performance continued to deteriorate, eventually shutting down completely. Despite multiple attempts, the vehicle was unable to be restarted, the vehicle has not been inspected and the vehicle never gave any prior warning of potential failure this was the frist and only issue I had with this vehicle I had to have the vehicle towed home due to not starting
It was losing calling but no coolant leak, rough idle/driving and blows white smoke out of the exhaust and threw the code p1299 so I took it to a garage and they told me it was the cylinder head gasket but my car has no recalls on it and I looked up my problem and it said 2013-2018 ford fusions with the 1.5l built before June 2019 and mine was built in feb 2018 and I haven’t received any mail about a recall.
The contact owns a 2018 Ford Fusion. The contact stated that while driving 45-50 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the head gasket was blown. The dealer determined that the engine block needed to be replaced. The vehicle was then taken to an independent mechanic, where the engine was replaced. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 97,000.
Coolant leaked into engine cylinder #4, requiring a new engine.
The contact owns a 2018 Ford Fusion. The contact stated while driving at an undisclosed speed, there was an engine misfire, and the low coolant level warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion into cylinder #2 and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that the repair was not covered under Customer Satisfaction Program: 21N12. The contact was advised to contact the federal safety agency Hotline to report the failure. The failure mileage was approximately 56,000.
Summary: I purchased a 2018 Ford Fusion from Reliable Chevrolet on [XXX]. After driving the vehicle a little less than 15,174 miles the check engine light came on. The Ford dealership concluded there was a coolant leak into cylinder 2 and suggested a long block replacement. After further investigation it appears this vehicle falls under the federal safety agency CSP 21N12, 19B37 and TSB 22-2229. The Ford dealership and Ford Motor company refused to assist in providing financial assistance for the needed repairs. We were also not notified by Ford, Reliable Chevrolet, or the extended warranty company (purchased through Reliable Chevrolet (MPP Co)) that this vehicle is subject to multiple the federal safety agency CSPs or TSBs before the purchase (possible violation of Section 17.46 of TBCC and Section 17.41 of DTPA). Ford Motor Company Customer Ticket - [XXX] Auto Nation Ford (Frisco, TX) Invoice Date July 24, 2024 It is my opinion one or more of the parties mentioned above should be held accountable for the needed repairs as this is a documented defect that should have been disclosed before purchase or at the minimum before out extended warranty expired in March of 2024. Please let me know what other information is needed to help complete this complaint. Best Regards, [XXX] Frisco, Texas [XXX] email - [XXX] mobile - [XXX] Supplement Details: Culpable Parties Manufacture Ford Motor Company 1 American Road, Dearborn, MI 48126 PO Box 6248 Dearborn, MI 48126 Called and opened a case on 08/24/2024 Case [XXX] Seller Reliable Chevrolet 800 North Central Expressway Richardson, Texas 75080 Extended Warranty Company (provided by dealer) MPP Co., Inc P.O. Box 634, Shawnee Mission, KS 66201 Vehicle Information 2018 Ford Fusion VIN- [XXX] Manufacturer: FORD MOTOR COMPANY, MEXICO Series: SE FWDTrim: Gross Vehicle Weight Rating: Class 1: 6,000 lb or less (2,722 kg or less)Drive Type: FWD/Front-Wheel Drive Cylinders: 4Primary Fuel Type: Gasol INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford Fusion. The contact stated while driving 45 MPH, the engine started to overheat, and there was smoke coming from underneath the hood. The message "Vehicle Temperature Overheating" was displayed. The contact pulled over to the side of the road and allowed the vehicle to cool down. The contact was able to continue driving; however, the failure recurred several times while driving. The contact pulled to the side of the road several times until arriving to the residence. The vehicle was taken to the dealer, where it was diagnosed that the PCM had failed. Additionally, the dealer diagnosed there was coolant intrusion in the engine cylinders. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21N12. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 181,000.
The contact owns a 2018 Ford Fusion. The contact stated while driving approximately 15 MPH, the vehicle stalled occasionally and returned to normal operation once the contact had turned off and restarted the vehicle. In addition, there was smoke coming from the tailpipes. The check engine warning light was illuminated. The vehicle was drivable and was driven to an independent mechanic where it was diagnosed with a coolant leak, and the mechanic suggested that the vehicle be taken to a Ford dealer. The vehicle was towed to a Ford dealer where it was confirmed that there was a coolant intrusion into the cylinder head gasket. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for further assistance. The failure mileage was approximately 135,000.
The contact owns a 2018 Ford Fusion. The contact stated while operating the vehicle, the message "Turn Engine Off" was displayed, and the engine temperature gauge indicated that the engine had overheated. The vehicle was taken to the local mechanic who diagnosed that the engine had failed due to coolant intrusion into the cylinders. The contact was advised that the engine short block needed to be replaced. The vehicle was not repaired. The manufacturer was contacted regarding the failure. The failure mileage was approximately 87,000.
My Vin # is: [XXX] and matches TSB 22-2322 // Customer Satisfaction Program 21N12 by all written criteria. My vehicle is exhibiting the exact symptoms as coolant leaking into cylinder bore (#3 in my situation). When I called my local Ford dealership and Ford Corporate office, they told me that my vehicle doesn't fall under that coverage, but couldn't tell me why. My make/model/year/manufacturer date/location/engine, etc. all match what is written in the TSB/CSP. If Ford states that my vehicle doesn't qualify for this program, I need an exact/specific explanation as to why my vehicle doesn't qualify for this TSB/CSP. Nobody can tell me and I keep getting the run around. This is unethical as everything written matches my vehicle and situation but I am being denied coverage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I drive a 2018 Ford fusion ecoboost. It started with a misfire on cylinder 4 and in that same week the engine started to over heat. Had the spark plugs replaced. Upon checking and monitoring coolant levels noticed I was losing coolant. Wasn't having any puddles in the driveway and no visible leaks under the hood. After few trips to work and home the engine would overheat and my work is less than 2 miles from my home. Started to quickly get worse, more codes popping up on my fixt obd2 scanner. From po304, PO300, PO303, B124D, PO313, PO316, PO317.
My fusion has been acting up lately. Everytime I turn on the car In the morning it sounds super rough and it shakes more than usual. I have to fill the coolant every once in a while because the car just eats the coolant up. I took it to a ford dealership to make sure there are no leaks but there weren’t. Car seems to have coolant intrusion by the amount of times I need to re fill coolant. I have attached picture of coolant always below minimum line.
I took my vehicle into a Ford dealership due to having a engine code of P0302 for engine misfire 8/3/24.Received a call from the dealership stating that I have coolant intrusion in cylinder 2 and has caused catastrophic engine failure.It has never been stated that there had been 2 previous recalls for this issue at any time while owning this vehicle.I called the Ford dealer that I recently had my oil changed at and asked if there was any notes on any issues or concerns when my oil was changed and was told no but there was a recall on the vehicle for this exact issue but it had expired.The dealership stated a new motor is needed costing $5,600 for a short block or $8,600 for a long block.I called Ford Customer Care and was told that with this being an ongoing issue to report it. I am at a loss after reading how many people have had this issue and Ford knowingly has had 2 recalls on it but people are still having to pay for a new engine because of the mileage on their vehicles at engine failure due to the boring between the cylinders causing the head gasket to fail. My car has a little over 135k miles and the previous recall stopped at 85k miles.I don't have an extended warranty and that would be the only way at this point that Ford would cover the expense.When buying a vehicle from a trusted company and then not being notified of an actual recall by Ford or even from the dealerships when being serviced if you aren't having that specific issue I don't think that is ethical or making sure their customers are safe.It puts not only my family but others at risk that have the same engine which can cause engine fires,failure while driving and money out of pocket that shouldn't have to be paid because of a known issue that currently has a pending class action lawsuit over.Ford needs to stand by their customers and reinstate this recall to include higher mileage cutoffs to make things right for all customers with the same manufacturer defect even if it takes longer to comeup
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Ford Fusion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history