The contact owns a 2011 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle suddenly lost power steering assist, nearly causing the contact to lose steering control as the steering locked up, and an audible warning chime sounded. The contact safely maintained control of the vehicle and observed that a power steering warning light was illuminated. The contact associated the failure with the federal safety agency Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The vehicle was towed to the residence. The manufacturer was notified of the failure. The failure mileage was 100,000.
Ford Fusion steering lock-up problems
608 of the 22,465 owner complaints about the Ford Fusion describe steering wheel locks up, most of them for the 2010 model year.
- owner complaints
- 608
- worst model year
- 2010
- typical repair cost reported
- $2,000
- typical mileage
- 96,000
Is there a fix? There are 5 recalls for this area of the car. See below
By model year
Often reported together
Engine failure 343Power steering loss 150Loss of power 17Check engine light 14Ball joint 10ABS 8No deployment 7Stalling 6
Trouble codes mentioned
C1963 2U3000 1U2011 1C1511 1C1277 1C102D 1
What owners say
The contact owns a 2016 Ford Fusion. The contact stated that on several occasions while driving, the vehicle lost automotive power, and the steering wheel locked up. The temperature gauge indicated that the engine was hot, and the vehicle needed to be restarted several times. The contact stated that during the failure the check engine warning light illuminated. The vehicle was taken to an independent mechanic but was not yet diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 126,000.
The contact owns a 2015 Ford Fusion. The contact stated that there was an abnormal popping sound coming from the vehicle while pulling out of the driveway and driving approximately 10 MPH. The contact stated that the steering wheel seized and locked up. The power steering, Hill Assist, and brake warning lights were illuminated. The contact associated the failure with the federal safety agency Campaign Number: 19V632000 (Steering). The vehicle was taken to the local dealer, where it was diagnosed that the steering gear had failed and the bolts were corroded. The manufacturer was contacted and confirmed that recalls were VIN-specific, and no assistance was provided. The failure mileage was approximately 177,000.
The contact owns a 2012 Ford Fusion. While the contact’s girlfriend was driving at an undisclosed speed, the steering wheel jerked and pulled to the right. Due to the failure, the steering wheel seized, and excessive force was needed to turn the steering wheel. The driver was able to avoid striking the curve. An unknown code was displayed. The contact was called and went to the scene of the failure. The vehicle was driven back to the residence nearby. The contact stated that the steering wheel was difficult to turn. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. While researching, the contact became aware of the federal safety agency Campaign Number: 15V340000 (STEERING) and associated the failure with the recall; however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.
The steering locked up and was completely unable to turn the wheel. This resulted in an accident that sent the car into a ditch. The safety recall for the steering was fixed and it failed again, in which it cost me 1700 to replace the same part again. It has AGAIN failed!!! This is extremely unsafe and should not fail on multiple occasions. This problem needs to be resolved!!!!
The steering locked up while driving. I was unable to turn the steering wheel. My self and my brother were in the vehicle. At this time, I am contacting the dealer to look at the unit. It will not turn and is stuck in my driveway. I am being told the electronic steering rack may have failed. Why does this not break way and allow some turning like the old hydraulic models? If I had been driving highway speeds, this would have been a serious accident.
The contact owns a 2017 Ford Fusion. The vehicle was started; however, the steering wheel failed to function as intended. The contact moved the gear shift lever to reverse(R), and the steering wheel seized. The tow truck driver had a difficult time trying to move the vehicle onto the flatbed truck. The vehicle was towed to the dealer, where it was diagnosed that high friction on the gear and the entire steering alignment needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 50,000.
The contact owns a 2011 Ford Fusion. The contact stated that while attempting to turn the steering wheel, the steering wheel seized, with several unknown warning lights illuminated. The contact stated that the steering wheel became difficult to turn. The vehicle was towed to the dealer, where it was diagnosed, and determined that the power steering module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 65,000.
A couple of weeks ago My Steering wheel locked up and the codes were reset which unlocked the wheel so i was able to turn it. Mechanic said it was moisture getting to the part and then the power steering light came on & it became Hard to turn the steering wheel while driving. There was no indication of a issue before it started.
Lost power in the steering wheel. My safety and others is at risk because the steering wheel locks up completely at slow speeds and it's difficult to turn the steering wheel when turning a corner or trying to back up. The problem has been confirmed by an independent service center. The component has only been inspected by an independent service center. On 12/5/25 I received a warning on the dashboard, Steering Assist Fault. I drove to work and parked the car. When I got in the car around noon and proceeded to drive the steering wheel was really difficult to turn and I started seeing other notifications that flashed on the screen. As I drove the steering wheel because more difficult to turn. At low speed the steering wheel locked up and I managed to pull the car over to get out of traffic.
Related recalls
Steering: electric power assist system
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2013-2016 Ford Fusion and Lincoln MKZ, 2015-2016 Ford Edge, and 2016 Lincoln MKX vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. Road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.
- Risk
- If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist, requiring a greater steering effort, especially at lower speeds, and increasing the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will replace the steering gear motor bolts and apply a wax sealer. If any of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began October 18, 2019. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 19S26.
Recall number 19V632000 · Recall details
Steering: steering wheel/handle bar
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.
- Risk
- A steering wheel detachment can cause a loss of steering control, increasing the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will replace the steering wheel bolt with a longer bolt, free of charge. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 18S08.
Recall number 18V167000 · Recall details
Steering: electric power assist system
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
- Risk
- If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
- Remedy
- Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 15S18.
Recall number 15V340000 · Recall details
Steering: electric power assist system
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Fusion and Lincoln MKZ vehicles manufactured February 3, 2012, to March 20, 2015, and 2015 Ford Edge vehicles manufactured February 26, 2015, to February 28, 2015, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, snow or water containing road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.
- Risk
- If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist. Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will apply sealer and replace the steering gear motor bolts as required. If one or more of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began on June 24, 2015. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 15S14.
Recall number 15V250000 · Recall details
Steering
- What is wrong
- Ford is recalling certain model year 2013 Fusion vehicles manufactured April 19, 2013, through April 23, 2013. The steering gears may be missing an internal retaining clip. If the clip is missing, components inside the steering gear may become dislodged inside the gear assembly.
- Risk
- This could result in impaired steering, including the loss of steering control, increasing the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will replace the steering gear, free of charge. The recall began on June 17, 2013. Ford's recall number is 13S06. Owners may contact the Ford customer relationship center at 1‑866‑436‑7332.
Recall number 13V232000 · Recall details
Questions about the Ford Fusion steering lock-up
Which Ford Fusion years have steering wheel locks up problems?
The model years with the most reports are 2010 (170 complaints), 2011 (166 complaints) and 2012 (157 complaints).
How much does it cost to fix steering wheel locks up on the Ford Fusion?
Owners who mentioned a price put the repair at about $2,000 (median of 44 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ford Fusion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history