2019 Ford Ranger: engine stalls while driving

Filed May 2, 2026 · Brakes, Engine · MT

The brakes failed within hours of owning the Certified, WARRANTIED VEHICLE. ALMOST had an accident. Within <5 weeks of owning this warrantied certified vehicle, was stranded on Rine Ridge Indian Reservation and on the highway. Engine jerk so bad feels like I a derby car. Then just stalls. The dont comply with their own 172 point certified inspection. They claim two keys for specified vehicle. They gave me two 1 starts the vehicle the other errors no key in ignition when you insert into ignition. NOW I have to pay bills to get a warrantied certified vehicle repaired plus loaner car because Ford McKie k owing sold an Unsafe vehicle under deceptive pretense. Multiple engine and brake failures which was supposedly certified inspected.

Filed Apr 2, 2026 · Electrical, Engine · TX

On friday, march 27th, 2026. My 2019 ford ranger began shaking before the engine stalled. Warning lights for an engine check came on and my vehicle would not go above 20 mph after restarting. When pressing on the accelerator the engine would rev but the vehicle would not accelerate. I took the 2019 ford Ranger to a local Ford Dealership service center and they diagnosed the following problems (listed in full below).The cooling fan was at issue and multiple wires connecting my engine to the rest of the vehicle were melted off. The ford dealership said that this issue is extremely rare and they have never seen it before. After receiving this information from the dealership I discovered that the 2019 ford ranger has had several recalls with the areas at issue in my vehicle. The recalls are under number 25V685000 (Engine block heater), and 20V137000 (Fan). Here is the full diagnosis from the ford dealership attached below: VERIFIED CUSTOMER CONCERN FOUND VEHICLE TO HAVE CEL LIGHT ON, AND MULTIPLE WARNING LIGHTS PERFORMED DIAG AND FOUND SHORT CIRCUIT PRESENT. TRACED SHORT FOUND COOLING FAN CLUTCH FAILED AND HARNESS RUBBING IN CLUCH ASSEMBLY FOR COOLING FAN The fan lowers the temperature of the engine. The cooling fan motor is an electric motor that turns the fan blades. When the vehicle is in traffic or under heavy load, the engine relies on the fan to cool itself. Some vehicles may use multiple electric fans for better control of the cooling system. For the most part, electric cooling fans are controlled by the same computer that controls the engine. However, in some engines, the fans are turned on and off by a temperature-sensitive switch mounted in either the radiator or elsewhere in the cooling system. Spark Plug Replacement 4 Cylinder: 4 Cyl Tune Up The platinum spark plug is a type of spark plug. The platinum is a precious metal that is used in the composition of the spark plug. The center electrode is made of platinum.

Filed Jul 24, 2025 · Engine · 44,825 miles · TX

The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 60 MPH and hauling a trailer, the vehicle unintendedly decelerated and stalled. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that there was rainwater inside the engine cylinders, causing two spark plugs to rust and malfunction. The spark plugs, spark plug boots, and spark plug coils were replaced and the vehicle was repaired. The contact stated that recently, while the vehicle was in for routine maintenance, the mechanic discovered rainwater inside the engine cylinders again. The vehicle was not yet repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The contact was informed that the VIN was not included in an Extended Warranty coverage related to the failure. The failure mileage was 44,825.

Filed Jun 17, 2024 · Transmission · VA

The vehicle skips gears when upshifting and does not shift through all the gears when in cruise mode. The truck will buck and bang jolting the passengers and appear to stall out without any warning. This has happened on numerous occasions and has even stalled out in the middle of a very busy intersection almost causing a collision by the truck not having enough power to coast through the intersection. Based on conversations with the dealership, this is not an isolated issue with our vehicle.

Filed Oct 5, 2023 · Transmission · IL

My Vehicle transmission skips second gear going from gear 1 to gear 3 when accelerating from a stopped position. Issue cause jerking and a clunk when gear catches. When this happens, vehicle will temporarily stall until gear catches putting driver and passengers at risk of collision if turning at intersection, proceeding through 2-way stop intersection, or on hills/ on train tracks. My vehicle has never displayed warning lights on the dash. I had the vehicle inspected at a Ford Dealer. Dealership was able to replicate the issue. Dealership related they flashed the TCM, but it did not resolve the issue and recommended replacement of transmission or rebuild. Vehicle is at 62,000 miles and is barely out of warranty. Researching the issue will lead to the Ford Ranger Forum, where multiple other people are experiencing transmission issues with this vehicle.

Filed Oct 4, 2023 · Engine · MA

2019 Ford Ranger Problem-1- Engine tried to stall several times during driving and operation. Problem-2- When trying to shift from Park to forward or Reverse, the engine shuts off. My truck has been at the dealership for several weeks now and they have not been able to fix or identify the cause.

Filed May 9, 2023 · Engine · WV

Ford failed to install a upper engine cover on Rangers with the 2.3 Eco Boost engine, this lets water to gather around the spark plugs causing misfires and stalling. This can cause vehicles to stall on the highway. This has been a on going problem with these vehicles. These covers were installed from the factory on Ford Explorers with the same engines from the factory. Ford service has used air to blow water from around the spark plugs. Then they tell the customer the need to buy the cover to prevent this from happening again.

Filed Jul 14, 2022 · Engine · 35,999 miles · AL

The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 65 MPH, the vehicle inadvertently lost motive power and stalled. The check engine warning light was illuminated. The vehicle was towed to the local dealer and diagnosed with water absorption in the engine. The dealer replaced the boot cover, spark plugs, and engine cover. The manufacturer was notified of the failure. The approximate failure mileage was 35,599.

Filed Jun 1, 2022 · Transmission · AL

The 10r80 10 speed Transmission will slip, shutter, stall, jump in and out of gear, slam into gear, and often times will wait till you are at a complete stop to downshift into 1st gear which makes the entire truck lunge forward almost like you’ve been rear ended. I’ve been to 2 different ford dealerships, had my truck in the shop multiple times and all I hear is them telling me that it’s normal and they get these complaints a lot. Long Lewis ford of prattville Alabama will play dumb and hold my truck in their parking lot for a few days then say they found nothing wrong. Collier ford of wetumpka Alabama told me over the phone that the symptoms I’m experiencing are normal and they they will not touch my truck unless it has a wrench light on. A $36,000 truck should not have these issues and it be deemed “normal” or even “acceptable”.

Filed Mar 18, 2022 · Fuel system · NY

Unknown, My vehicle seems to stall in low gear. I already informed the dealership several times, and they stated that everything was fine. The stalling appears to be getting more frequent as time goes on, and worried that this could cause further damage to the vehicle. This is a safety concern as well.

Filed Jan 10, 2020 · Driver assistance, Engine · 700 miles · ND

Sometimes truck stays in gear after shifting into park. Has rolled forward after I exited the vehicle. Lane keep assist has misjudged lane & turned the wheels sharply causing unwanted lane change. Pre collision warning often sounds alarms & shows visual warnings with no traffic nearby, the system has emergency braking & I'm afraid of it applying brakes when I'm on the interstate. Crash detected audible & visual warnings often appear when there has never been a crash. Driver's door mirror is not secure, vibrates/rattles when truck is at highway speeds. Front & rear differentials make grinding noises & front end jumps, wheels lock up when using 4x4l. Does not always shift into 4x4h. Vehicle has overheated & stalled while in traffic. Pedestrian detection system is non-functional. A man stepped off the sidewalk in front of my truck on monday, jan 06 2020, I was traveling about 15-20 MPH. Luckily I saw him in time and put the brakes on, when I came to a stop the man was a mere 2" from the front of my truck & we were both extremely shaken. Had I applied the brakes 1 second later the man would be dead. The pedestrian detection system never alerted me to the pedestrian with any type of warning, audible or visual. The system never assisted with emergency braking as a result. The parking & cross traffic sensors rarely work correctly, almost never detect cross traffic when pulling out of a parking spot. I can pull up to a vehicle, with my front license plate touching the receiver bar on the hitch of the vehicle in front of me before the sensors detect the vehicle. As a disabled veteran I'm more cautious than most, but all of these issues, of which there are more, make this truck a severe hazard, I do not feel safe driving it. Dealership refuses to service anymore, has been in shop 5 times, they have witnessed some issues but won't acknowledge them. Uploaded list of defects