Upon auto inspection, I was informed that the subframe of the van was rotted and needed to be addressed. As the vehicle was not put into service until 2017, the van had less than 7 years on it at the time yet this bolt in member which supports the front lower control arms as well as the steering rack was severly compromised. Due to financial constraints, the member wasn't replaced until recently at which point there were multiple locations that the decay was so severe that one could fit both hands through the voids created by the rust. I spoke numerous times with Ford customer care which quoted body, not frame, rust through warranties. The cost to replace this is well over $3k and most dealerships refuse to do them. As has been reported to you before, this item has such a history of rust through that there is an open class action suit. I was lucky. The issue was found and repaired, at great expense, before either my steering or suspension failed.
The worst 2016 Ford Transit problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Transmission60
- Engine24
- Fuel system14
- Body13
- Electrical12
- Brakes11
- Seat belts11
- Driver assistance9
- Steering8
- Suspension7
- Acceleration6
- Wheels5
- Airbags4
- Lights2
- Tires2
- Locks1
- Seats1
- Visibility1
Specific symptoms reported on the 2016 Ford Transit
Stalling 14Backup camera 13Loss of power 8Check engine light 5Fuel pump 5
Trouble codes owners of the 2016 Ford Transit mention
P2111 3
Recalls 21
Back over prevention: sensing system: camera
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
- Risk
- A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 25S89. This recall expands previous the federal safety agency recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on beginning September 8, 2025.
Recall number 25V572000 · Recall details
Parking brake: conventional: mechanical: linkage and cable
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.
- Risk
- Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.
- Remedy
- Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 21S39.
Recall number 21V631000 · Recall details
Power train: driveline: driveshaft
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2015-2017 Transit vehicles. This recall includes all full-size Transit vehicles previously recalled under 17V‑408 except ones that received mechanical universal joint (u-joint) as a remedy and any 156" or 178" wheelbase Chassis Cab and Cut-Away bodies models. The flexible coupling connecting the transmission to the driveshaft may prematurely fail.
- Risk
- If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash or injury.
- Remedy
- Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling every 40,000 miles until the final remedy is available. The final remedy will consist of installation of a driveshaft front section equipped with a mechanical u-joint in place of the flexible coupling. These repairs will be made free of charge. Owner notification letters were mailed on April 1, 2020. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 19S38. Note: This recall supersedes recall number 17V‑408.
Recall number 19V767000 · Recall details
Seats
- What is wrong
- New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- New England has notified owners, directing them to contact Freedman for repairs to the foldaway seats, free of charge. The recall began May 27, 2019. Owners may contact Freedman customer service at 1‑800‑443‑4540 or New England at 1‑800‑886‑9247.
Recall number 19V333000 · Recall details
Seats
- What is wrong
- Fenton Mobility Products, Inc. (Fenton Mobility) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- Fenton Mobility will notify owners, and a Fenton Mobility technician will repair the foldaway seats, free of charge. The recall is expected to begin in June 2019. Owners may contact Fenton Mobility customer service at 1‑716‑484‑7014.
Recall number 19V329000 · Recall details
Seats
- What is wrong
- Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1‑734‑453‑6452.
Recall number 19V313000 · Recall details
Equipment adaptive/mobility
- What is wrong
- Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.
- Risk
- If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
- Remedy
- Mobility Specialists, working with Ricon, has notified the owners. Ricon will provide instructions and materials for replacing defective parts. Owners may contact Ricon customer service at 1‑800‑322‑2884.
Recall number 19V271000 · Recall details
Seats
- What is wrong
- Cabot Coach Builders, Inc. DBA Royale Limousine (Royale) is recalling certain 2015-2018 Ford Transit-based mini-coaches equipped with Freedman GO-ES foldaway seats recalled under 18E-076. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- Royale will notify owners and dealers will inspect and repair the seat. The recall began June 6, 2019. Owners may contact Royale customer service at 1‑800‑544‑5587.
Recall number 19V247000 · Recall details
Seats
- What is wrong
- Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1‑800‑443‑4540.
Recall number 19V238000 · Recall details
Seats
- What is wrong
- TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1‑800‑443‑4540 or TransitWorks customer service at 1‑855‑337‑9543.
Recall number 19V229000 · Recall details
Seats
- What is wrong
- Quality Van Sales, Inc. (Quality Van) is recalling certain 2015-2018 Ford Transit and E-350 vehicles modified to be equipped with Freedman GO-ES Foldaway Seat back cushions. The seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- Quality Van will notify owners and dealers will inspect and repair the foldaway seat, free of charge. The recall began March 21, 2019. Owners may contact Quality Van customer service at 1‑800‑408‑8550.
Recall number 19V205000 · Recall details
Equipment adaptive/mobility
- What is wrong
- Fenton Mobility Products, Inc. (Fenton) is recalling certain 2015-2017 Ford Transit passenger vans modified to be equipped with Ricon S & K Titanium Wheelchair Lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."
- Risk
- If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
- Remedy
- Fenton will notify owners, and a service technician will install Ricon Recall Parts Kit RI61396, free of charge. The recall began April 24, 2019. Owners may contact Fenton Mobility customer service at 1‑716‑484‑7014. Fenton's number for this recall is RI61396.
Recall number 19V183000 · Recall details
Seats
- What is wrong
- Prime-Time Specialty Vehicles (Prime-Time) is recalling certain 2016-2018 Ram ProMaster and Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats. When the seat back cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- Prime-Time Specialty Vehicles has notified owners, and Freedman dealers have inspected and repaired the foldaway seats, free of charge. The recall began November 16, 2018. Owners may contact Freedman customer service at 1‑800‑443‑4540 or Prime-Time Specialty Vehicles at 1‑574‑293‑9191.
Recall number 19V332000 · Recall details
Power train: driveline: driveshaft
- What is wrong
- XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
- Risk
- If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
- Remedy
- XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1‑833‑953‑5338.
Recall number 19V103000 · Recall details
Seats
- What is wrong
- National Van Builders, Inc. (National Van) is recalling certain 2015-2018 Ford Transit vehicles equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
- Risk
- In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
- Remedy
- National Van will notify owners, and dealers will inspect and repair the foldaway seat, free of charge. The recall began November 26, 2018. Owners may contact National Van customer service at 1‑508‑222‑2272.
Recall number 18V782000 · Recall details
Electrical system: wiring
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
- Risk
- An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. Owners may contact Ford customer service at 1‑866‑436‑7332. Note: This is an expansion of recall 17V‑668 (Ford recall 17S34). Ford's number for this recall expansion is 17S34-S1.
Recall number 18V275000 · Recall details
Electrical system: wiring
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
- Risk
- An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. The recall began on February 9, 2018. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 17S34.
Recall number 17V668000 · Recall details
Power train: driveline: driveshaft
- What is wrong
- Ford Motor Company (Ford) is recalling all 2015-2017 Transit vehicles except 156" and 178" wheelbase Chassis Cab and Cut-Away bodies. In the affected vehicles, the flexible coupling connecting the transmission to the driveshaft may prematurely fail.
- Risk
- If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash.
- Remedy
- Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling on any vehicle with more than 30,000 miles. A final remedy repair of a redesigned flexible coupling or a revised driveshaft equipped with a universal joint is being developed and is expected in early 2018. These repairs will be made free of charge. Interim notifications informing owners of the safety risk were mailed July 21, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 17S15.
Recall number 17V408000 · Recall details
Fuel system, diesel
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
- Risk
- If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
- Remedy
- Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 16S32.
Recall number 16V618000 · Recall details
Air bags: side/window
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured March 12, 2014, to March 18, 2016. In the affected vehicles, the side curtain air bag may not deploy with the proper trajectory due to being folded and packaged incorrectly.
- Risk
- A side curtain air bag that does not deploy as intended may increase the risk of occupant injury in the event of a crash.
- Remedy
- Ford will notify owners, and dealers will inspect and re-orient the side curtain air bag assembly, as necessary, free of charge. The recall began on May 18, 2016. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 16S13.
Recall number 16V188000 · Recall details
Seat belts: rear/other: buckle assembly
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured February 13, 2014, to January 13, 2016 and equipped with rear passenger seats. The rear seat belt buckles may be damaged if a heavy object is placed on, or impacts, the top of the buckle. The damage may prevent the buckle from latching or from remaining latched.
- Risk
- An unlatched seat belt increases the risk of injury to the occupant in the event of a crash.
- Remedy
- Ford will notify owners, and dealers will modify or replace the seat belt buckles, depending on their location in the vehicle, free of charge. The recall began May 18, 2016. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 16S06.
Recall number 16V111000 · Recall details
See all 21 recalls for the 2016 Ford Transit
Defect investigations
Zipcar Rental Concerns
the federal safety agency opened this audit query to determine whether Zipcar, Inc. (Zipcar) complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental car company not rent, lease, or sell a recalled vehicle until the safety defect or noncompliance is remedied. 49 U.S.C. § 30120(i). Based on the federal safety agency’s inquiry, including information provided by Zipcar, the federal safety agency asserted that, during 2017 and 2018, Zipcar rented certain unremedied recalled vehicles in violation of the Safety Act. In October 2023, the federal safety agency and Zipcar entered into a Consent Order in which Zipcar agreed to pay a total civil penalty of $300,000. The total civil penalty included a payment of $150,000 as a Non-Deferred Amount. Zipcar also agreed to a sum of $150,000 as an Abeyance Amount, to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by the federal safety agency, of the requirements of the Consent Order. The requirements of the Consent Order include performance obligations that relate to process improvements to Zipcar’s recall compliance procedures and its training materials. Zipcar agreed to conduct an audit of all Zipcar vehicles with an open recall within 150 days after the Effective Date of the Consent Order. Zipcar also agreed to quarterly meetings with the federal safety agency staff to discuss the progress of the performance obligations and issues or concerns from either party. This audit query investigation, AQ18001, is closed. Closure of this AQ has no bearing on the terms of the Consent Order, including Zipcar’s ongoing performance obligations or other legal obligations, and does not represent a determination by the federal safety agency about Zipcar’s performance under the Consent Order to date.
AQ18001
Technical service bulletins for the 2016 Ford Transit 233
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Some 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles...
- Customer Satisfaction Program 25N15
- Some 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles...
- Advance Notice – Customer Satisfaction Program 25N17 Certain 2015-2025 Model Year Multiple Vehicle Lines...
- Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless...
- Certain 2015-2019 Model Year Multiple Vehicle Lines Rear View Camera Inspection For One-Time Replacemen
- Certain 2015-2019 Model Year Multiple Vehicle Lines Rear View Camera Inspection For One-Time Replacement
- This article supersedes TSB 24-2165 to update the TSB Service Procedure
- Some 2015-2021 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes...
- All Transit accessory stick-on keyless entry keypads come with a wallet card containing the master code.
2016 Ford Transit fuel economy
Official EPA estimates in miles per gallon (MPGe for electric). Ranges cover trims that share the same engine.
| Engine | Drive | City | Highway | Combined |
|---|---|---|---|---|
| 3.7L 6‑cyl | RWD | 14 | 18 | 16 |
| 3.5L 6‑cyl | RWD | 15 | 19 | 16 |
What 2016 Ford Transit owners say
Most recent owner complaints, unedited.
The rearview camera on my 2016 Ford Transit 150 intermittently fails while the vehicle is in reverse. At times, the rearview mirror display shows a blue/blank screen instead of the rear camera image. At other times, the camera image appears reversed/inverted. Ford Safety Recall 25S89 includes certain 2016 Ford Transit vehicles for a rearview camera condition that can result in a distorted, inverted, or blank image. My vehicle is exhibiting these same symptoms, but VIN [XXX] is not currently included in the recall. I am concerned that the population of vehicles included in recall 25S89 may not include all 2016 Ford Transit vehicles affected by this rearview camera defect. The intermittent loss or incorrect orientation of the rearview image reduces rear visibility while backing and creates a safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2016 Ford Transit. The contact stated that while reversing, the back over prevention camera malfunctioned and displayed an upside down or distorted image, with the distance being inaccurate. The contact stated that due to the failure, the vehicle reversed into a fence. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 25V572000 (BACK OVER PREVENTION). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 25,000.
The contact owns a 2016 Ford Transit. The contact stated that while driving 50 MPH, the rubber-flexible coupling between the transmission became shredded into pieces and the vehicle swerved off the road. There were no warning lights illuminated. The vehicle was towed to the independent mechanic, who confirmed that the rubber transmission coupler had failed and needed to be upgraded to the metal version by the manufacturer. The local dealer was contacted and confirmed that the vehicle was previously repaired under the federal safety agency Campaign Number: 17V408000 (Power Train). The vehicle was not diagnosed or repaired. The contact called another local dealer, Winner Dover Auto Body Shop (591 S Dupont Hwy, Dover, DE 19901), but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 197,000.
The backup camera and parking collision warning periodically do not work and this resulted in a collision with a parked car.
I bought the car in 2017 with 7800 miles within the first few months. The rear camera began to freeze sometimes I once went to the dealer but they said they can’t find it because at that point in time it wasn’t freezing so they couldn’t do anything about it now at least 95% of the time the rear camera does not work either is upside down or it doesn’t work at all I see there has been a recall for my year similar vehicles for this problem of the rearview camera. For some reason my car was not included and I would like to log the complaint and hopefully get my car included. thank you so much.
The contact owns a 2016 Ford Transit. The contact stated that while attempting to reverse, the back over prevention camera was inoperable. The screen displayed a black screen or a blue screen. Occasionally, the back over prevention camera operated intermittently or displayed a message that the camera was currently unavailable. The contact referenced the federal safety agency Campaign Number: 25V572000 (Back Over Prevention); as a possible cause for the failure; however, the VIN was not included in the recall. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 170,000.
My 2016 Ford Transit experienced a sudden loss of engine power while I was driving on the highway. The vehicle entered limp mode, stalled, and emitted excessive black smoke from the exhaust, creating a hazardous situation for me and surrounding motorists. I was forced to pull off the roadway because the vehicle could no longer operate safely. When a warning first appeared, I promptly took the vehicle to an authorized dealer, the dealership preformed some type of update and a DPF regeneration and instructed me to drive the vehicle on the highway for 50 miles to complete the regeneration process, I followed these instructions. The light returned and the vehicle was inspected by another authorized Ford dealership, All-State Ford, which confirmed the condition covered under Ford Customer Satisfaction Program (CSP) 23M01 involving the catalytic converter system. The dealership confirmed that the required repair cannot be completed because Ford has not supplied the necessary replacement part after I called to get an update. Approximately five months have passed since the vehicle was diagnosed, and the required part remains unavailable. During this time, my vehicle has remained unusable. Ford has been unable to provide a repair date or any estimated timeline for when the part will become available. Ford’s response has been to direct me back to the dealership. However, the dealership has confirmed that it cannot obtain the part, provide a repair timeline, authorize reimbursement, or offer any alternative remedy because those decisions are controlled by Ford Motor Company. In researching this issue, I found online discussions from owners describing similar catalytic converter failures and extended delays across multiple Ford vehicle models. While I cannot independently verify those reports, they suggest this may not be an isolated incident. I respectfully request the federal safety agency review whether the remedy offered under CSP 23M01 is adequately addressing the safety issue.
The back up camera is upside down
I purchased this vehicle, used, back in 2024 from STG Auto Group of Montclair. At the time I purchased the vehicle, they informed me there were no open recalls and ensured me the vehicle was safe to operate. About a year later, the driveshaft coupling (the federal safety agency 17V408000) completely sheared and I lost control for a bit on the freeway while trying to stop safely. Before I got the vehicle towed, I noticed the coupling was destroyed and it was all made of rubber. At the time I didn’t know about the recall repair that was supposed to replace this rubber coupling with a more robust version. Since I had a service contract with STG, they performed the repair and installed the same type of rubber coupling that had just been destroyed. I got the vehicle back and it drove fine for a few months, and last month the coupling blew out again. I did some due diligence and found out about the recall. I informed STG about it and they said the vehicle was sent to a dealership that is now out of business for the recall repair. The car has been sitting on their lot for over a month while they “source” parts and try to figure out who’s going to pay for repairs. Please help, I need the vehicle back to transport my family.
Compare the 2016 Ford Transit
Other model years
Questions about the 2016 Ford Transit
Is the 2016 Ford Transit reliable?
Owners have filed 156 complaints about the 2016 Ford Transit, 2.7 times a typical Transit model year. It is one of the years we flag to avoid.
What is the 2016 Ford Transit year score?
The 2016 Ford Transit scores 33 out of 100 (poor). The score compares it with the other model years of the Ford Transit: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2016 Ford Transit?
Transmission and drivetrain, with 60 complaints, typically around 105,000 miles. Next is engine (24).
How many recalls does the 2016 Ford Transit have?
21 recalls, covering back over prevention, parking brake and power train.
What gas mileage does the 2016 Ford Transit get?
Official estimates for the 2016 Ford Transit range from 16 mpg combined. The most efficient version (3.7L 6-cyl, RWD) gets 14 city and 18 highway.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Ford Transit?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history