2013 Hyundai Sonata: engine failure

Filed Nov 5, 2026 · Engine · 114,719 miles · FL

The contact's mother owns a 2013 Hyundai Sonata. The contact stated that while driving at approximately 70 MPH, the engine failed and the vehicle stalled. The vehicle was towed to an independent mechanic, who determined that the engine seized and required replacement. The engine long block was replaced under the federal safety agency Campaign Number: 17V226000 (Engine and Engine Cooling). The contact stated that approximately 11,000 miles after the replacement, the vehicle stalled again. The vehicle was towed to an independent mechanic, who diagnosed the vehicle with engine failure. The vehicle was taken to the dealer; however, the cause of the engine failure could not be confirmed. The manufacturer was notified of the failure. The failure mileage was 114,719.

Filed Oct 7, 2026 · Engine · NY

2013 Sonata 2.4 81,953 mi, seized on highway with fresh oil change 1 week prior, loss of power, steering/braking. Happened on George Washington Bridge (NY/NJ) with near collision. Asssited by Police to move vehicle out of highway. Inspected by dealer (Paramus Hyundai) and confirmed loss of power due to engine problem. Dealer denied warranty for poor maintenance despite receipt showing recent maintenance. This vehicle is covered under life warranty by Hyundai for manufacture defective engine, yet they denying engine replacement. The engine problem is a serious safety risk.

Filed Sep 28, 2026 · Engine · FL

Factual summary * Vehicle: 2013 Hyundai Sonata * VIN: [XXX] * Incident date: XXX * Failure: Sudden knocking noise, immediate check‑engine illumination, loss of power, and catastrophic engine failure; vehicle towed to Allen Turner Hyundai, 6501 Pensacola Blvd, Pensacola, FL 32505. * Recall: My VIN appears on Hyundai’s engine recall list; the recall notice was issued before the vehicle received a rebranded title. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 8, 2026 · Engine · NC

On September 8, 2026, while driving a 2013 Hyundai Sonata Limited at highway speed, the check-engine light began flashing and the vehicle suddenly lost power. The vehicle slowed to approximately 40 mph, then approximately 20 mph, before the engine completely shut off. I had to maneuver the vehicle to the side of the highway while surrounding traffic continued traveling at highway speeds. This created a serious risk of a rear-end collision or other accident. The engine would not operate afterward and appears to have seized. The vehicle had approximately 100,000 miles at the time of the incident. There had been no clear warning of an imminent engine failure before the check-engine light began flashing and the vehicle lost power. The vehicle has not yet received a complete diagnostic inspection, so the precise cause of the failure is currently unknown. The vehicle is available for inspection upon request. No crash, fire, or injuries occurred, but the sudden and severe loss of power created an immediate safety hazard.

Filed Sep 5, 2026 · Engine · IL

I am reporting a serious engine failure involving my 2013 Hyundai Sonata. The vehicle's engine was previously inspected by a Hyundai dealership as part of a Hyundai engine recall. I followed Hyundai's instructions and brought the vehicle to the dealership for the required inspection. I was informed that the engine passed the inspection, and an orange marking was placed on the oil dipstick. The Hyundai dealership should have the service record documenting this recall inspection. Many years later, at approximately 120,000 miles, the same engine suddenly failed without warning and became locked/seized. A mechanic attempted to turn the engine and determined that it would not turn. I understand that many years had passed and the vehicle had accumulated additional mileage since the recall inspection. I am not claiming that the previous recall issue necessarily caused the current failure. However, I believe the circumstances warrant investigation because this is the same engine that had previously been inspected under a Hyundai engine recall and determined to have passed the inspection. The vehicle had been routinely maintained. Much of the routine maintenance was performed outside Hyundai dealerships by a mechanic in my family and by me, so the Hyundai dealership service history may not contain all maintenance records. I am concerned that the sudden engine seizure may represent a safety-related engine defect or may potentially be related to the previously recalled engine condition. An unexpected engine seizure can result in a sudden loss of propulsion and create a significant safety risk if it occurs while the vehicle is being driven. I am requesting that the federal safety agency review this complaint, including the vehicle's recall history and any related complaints or investigations involving the 2013 Hyundai Sonata, and determine whether this failure warrants further investigation. The Hyundai dealership that performed the recall inspection have documentation of that inspection.

Filed Sep 3, 2026 · Engine · 52,973 miles · FL

The contact owns a 2013 Hyundai Sonata. The contact stated that while driving 40 MPH, the vehicle suddenly lost power. The contact was able to coast to the side of the road and turned off the vehicle. The vehicle was unable to restart on the side of the road. The vehicle was towed to a certified mechanic who diagnosed that the engine had seized and needed to be replaced. The vehicle was then towed to the dealer, who confirmed the diagnosis. The dealer asked the contact to provide receipts of past oil changes. After submitting the information to the manufacturer, the request to cover the repair was denied. The vehicle remained with the dealer for a month. The manufacturer was informed of the failure by the dealer. The failure mileage was 52,973.

Filed Aug 13, 2026 · Engine · AZ

My engine was decreasing in speed and shutting off if I brake to slow down on major exressways and local roads. I was advise by my dealership mechanic shop that my engine had a recall and need to have it towed to a hyundai service dealer for a replacement engine . My engine light on the dashboard had a constant blinking light. My vehicle was inspected camelback hyundai and a new engine was replaced. The dealership is holding my vehicle hostage demanding I pay 2500.00 for replacement engine that was a recall. They are threatening to place an abandonment charge against me

Filed Aug 1, 2026 · Engine · AZ

This vehicle is subject to a known Theta II connecting rod bearing defect (Recall 162 / KSDS) and a related class action settlement. On October 2, 2025, the vehicle stalled while entering the highway. It was taken to Ken Garff Hyundai Surprise, and the following day, October 3, 2025, it entered engine protection mode (limp mode) during the dealership's own test drive, the exact behavior the Knock Sensor Detection System is designed to trigger for connecting rod bearing wear. The dealership's own service advisor documented in writing, as early as December 27, 2025, that he did not like how the vehicle ran and drove and wanted to resubmit a warranty claim. Despite this documented concern, on May 5, 2026, the dealership's service manager told Hyundai corporate that nothing was wrong with the vehicle and that it could be picked up. Hyundai corporate maintained that the engine had passed bearing clearance testing on two occasions, October 3, 2025 and May 23, 2026. I was told the vehicle was safe and retrieved it on June 29, 2026, out of necessity after my family's other vehicle was totaled in an accident. Approximately ten days later, the engine failed completely while I was driving with my family in the vehicle. Hyundai's own repair order documented the crankshaft as seized at over 95 lb-ft of torque. Hyundai subsequently approved and completed a full engine replacement. I am filing this report because a vehicle with a documented, known defect and a documented internal safety concern was represented to me as safe to drive, and it failed catastrophically with my family inside it within days of that representation

Filed Jul 14, 2026 · Engine · AZ

Bought car from a used car dealership, car fax report filed 3 other owners, with a well maintenance report on file with oil change done atleast every 5K miles. Bought car in January 2026, maintenance had been done before car was taken off the lot. At 3k miles since hsving the ca on 05/15/26 I got my oil changed and cabin filters replaced. It’s only been less than 1500 miles and car engine had reportedly seized.

Filed Jul 8, 2026 · Engine · MO

Driving my car, oil light comes on. I take to a local mechanic who said he sees this often, my engine is going to seize up and confirmed via VIN my car is affected by the Sonata Engine Recall campaign XXX. Vanessa At Hyundai said to take it to a dealership immediately for further inspection as it may not be safe to drive. Took to dealership on XXX. While at the dealership, service manager said on XXX “my car was perfect, didn’t know why it was even there and trying to find something wrong with it was like chasing unicorns.” I said please look again and on XXX the engine seized up as it was taken on a drive by said advisor. Via dealership, they took pictures of manifold, but Hyundai denied my replacing my engine per the recall. I called Hyundai to request an appeal and received a case number/case manager ( Madge case # XXX) on XXX. I then submitted maintenance records which showed at least one oil change at each requested interval and still denied on XXX. I continued to call both parties: dealership & case manager but got no reply. I received my case manager’s direct line at Hyundai on XXX via [XXX] who said no notes were on file and case manager would return call in 1-3 days and he has never returned my calls, nor has the service manager who said my car was in perfect driving condition. Today is July 8 and I am still waiting for a written letter or phone call explaining the reason for my denial. Napelton Hyundai is also charging me $215.00 for the engine inspection when my paperwork shows a NO CHARGE to you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 7, 2026 · Engine · IN

Engine developed a loud rod-bearing knock at approx. 107,771 miles, consistent with the Theta II GDI connecting-rod bearing defect addressed by the federal safety agency Recall 17V‑226 (Hyundai Recall 162). The vehicle was taken out of service and delivered to Webb Hyundai, Highland, IN, on 06/13/2026, where it remains. Hyundai's own campaign records confirm Recall 162 (GDI engine inspection/replacement) was completed on this VIN on 10/02/2017 and the KSDS engine-monitoring software (Service Campaign 953) was installed 08/09/2019 - yet the engine has now failed in exactly the manner the recall was meant to remedy, indicating the recall remedy was ineffective for this vehicle. Hyundai Motor America (case #42847594) has refused repair, citing a "branded title"; the only brand on the title is a "Not Actual Mileage" odometer disclosure, not a salvage or rebuilt brand. the federal safety agency guidance is that title branding is not a valid basis for denying a recall remedy. The defect poses a risk of sudden engine failure and stalling while driving. No crash, fire, or injury. Requesting the federal safety agency review of recall remedy effectiveness and of Hyundai's denial.

Filed Jul 2, 2026 · Engine, Transmission · GA

My vehicle began experiencing excessive oil consumption several years before the engine failed. In approximately 2019, I reported the oil consumption to an authorized Hyundai dealership and expressed concern that my vehicle might have one of the known Theta II engine defects. I was told the Knock Sensor Detection System (KSDS) campaign had been completed and that my vehicle was not one requiring engine replacement. The excessive oil consumption continued. On June 6, 2026, the engine developed severe metal knocking, misfires, and became unsafe to operate. I was concerned the engine could fail completely or lose power while driving, creating a safety hazard for myself and others. The vehicle had to be towed to a Hyundai dealership on June 7, 2026. Hyundai of Kennesaw inspected the vehicle and verbally advised that the engine failure was caused by connecting rod bearing failure. Although the dealership identified connecting rod bearing failure, Hyundai Motor America declined to replace the engine and instead advised that it would not proceed with repairs because of the settlement provisions related to the vehicle's age and mileage. As a result, the vehicle remains inoperable. I am submitting this report because I believe this engine failure presents a significant safety concern due to the potential for sudden engine failure or loss of power while driving. I am also concerned that I reported symptoms years before the failure, yet the engine ultimately failed from the same type of defect associated with many Hyundai Theta II engines.