2012 Kia Sorento: fire, smoke or burning smell

Filed Sep 13, 2026 · Fuel system · MD · fire

While driving I smelled gas, a few minutes later I saw smoke coming from the hood of the car. I stopped, turned the car off, got my dog, exited the car, which then exploded into flames. I saw that I was not safe the minute I saw the smoke. I was unsure that the gas smell was coming from my car until I saw that my gas needle was on E when I had filled up 3 hours prior. The police and the fire department was on scene. No warnings came up on the dash board other than the gas light.

Filed Jun 14, 2026 · Fuel system · TX · fire

On June 6, 2026, while driving home, the vehicle suddenly began smelling strongly of gasoline and burnt rubber. Within seconds, thick black smoke became visible in the side mirrors, followed immediately by white smoke pouring from the front hood and into the passenger cabin through the air vents. ​As I attempted to pull over to safety, the vehicle completely stopped responding. The brakes failed to operate, the engine stalled, and the steering wheel locked completely. We were barely able to bring the vehicle to a stop. Immediately upon exiting, visible flames erupted from underneath the driver's side of the vehicle and out of the front hood. The engine compartment and motor burnt completely.The safety of the driver and front passenger was put at extreme risk of death or severe injury. Because the brakes and steering locked up simultaneously while the cabin filled with smoke, we almost lost the ability to safely exit a moving vehicle that was actively catching fire. Furthermore, at no moment prior to or during the failure did any warning lamps, check engine lights, or diagnostic messages illuminate on the dashboard. There was absolutely zero advance warning from the vehicle's safety systems.The fire originated from a catastrophic fuel system failure, specifically matching the known issues of the high-pressure fuel pump leak.The vehicle is a total loss and is currently located at a tow yard. It is fully available for inspection upon request.Local police responded to the scene and generated an incident log number. A corporate claim has been opened directly with KIA but as of today, no inspector from the manufacturer or insurance has been sent out.

Filed May 7, 2026 · Engine · NY · fire

The contact owned a 2012 Kia Sorento. The contact’s spouse stated that while driving at an undisclosed speed, the vehicle suddenly lost motive power with no warning lights illuminated. The contact's spouse noticed smoke coming from the front of the vehicle, prompting the contact’s spouse to pull over to the side of the roadway. Moments later, the front of the vehicle caught fire. The local fire department responded to the scene and extinguished the fire; however, the cause of the fire had not yet been determined. The vehicle was completely consumed by the fire and deemed destroyed. No police report was filed, The manufacturer was not notified of the failure. The contact’s spouse stated that the incident was extremely traumatic and believed the vehicle posed a serious safety hazard. The failure mileage was not available.

Filed Feb 11, 2026 · Engine · 200,000 miles · VA · fire

The contact owns a 2012 Kia Sorento. The contact stated that after parking and turning off the vehicle, she entered the post office; after 3 to 4 minutes, she was alerted by a consumer that the vehicle had caught fire. The contact noticed fire emerging from the undercarriage. The TPMS warning light had been illuminated prior to the incident. Post office employees attempted to extinguish the fire. The fire department was called and successfully extinguished the fire. There were no reported injuries. Police were also present at the scene. The contact related the failure to the federal safety agency Campaign Number 23V-652000 (Service Brakes, Hydraulic). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted; however, no assistance was provided. The failure mileage was approximately 200,000.

Filed Jan 4, 2026 · NY · fire

The check engine light came on 12/29 and was driven approximately 50 miles. On Jan 3, 2026 vehicle was driven app. 5 miles and left parked at a friends. There was a little smoke coming out from under the hood, but this is not unusual as car had small oil leak for at least 3 years that no one could find to fix but burned off on engine and gave constant oily smell. Under 10 minutes later driver was notified that neighbors heard 3 explosions, car was on fire and fire department was coming. When driver went back to where vehicle was parked, fire was out and vehicle was almost totally destroyed. Vehicle was towed to a scrap yard.

Filed Dec 5, 2025 · Brakes · 212,000 miles · GA · fire

The contact owns a 2012 Kia Sorento. The contact stated the vehicle was serviced at the local dealer for the federal safety agency Campaign Number: 23V652000(SERVICE BRAKES, HYDRAULIC) regarding a safety fire hazard. Days later, while the vehicle was idling, smoke was suddenly present coming from under the hood. The contact opened the hood of the vehicle and discovered flames and smoke coming from the fuse box located in the front of the engine bay. The contact, who was a local fire investigator, retrieved a fire extinguisher and extinguished the flames. The fire department was called to the scene, and a fire report was filed. The vehicle was later towed to the home, and the manufacturer and local dealer were notified of the incident. The manufacturer sent an investigator to the home to examine the vehicle. The investigator determined that the fire had originated at the front of the engine compartment, but did not determine the cause of the fire. No injuries were reported. The contact was concerned that the fire was related to the recall service previously performed. The failure mileage was 212,000.

Filed Oct 20, 2025 · Engine · 106,334 miles · OR · fire

The contact owns a 2012 Kia Sorento. The contact stated that, while driving at 60 MPH, she observed smoke emanating from the engine compartment, prompting her to attempt to pull to the shoulder of the roadway. During the attempt, the contact stated that she then heard an abnormal pop, after which the vehicle lost motive power, and within a moment, the entire front end of the vehicle was engulfed in flames. Upon exiting the vehicle and being assisted by bystanders, the contact was informed that the bystanders had attempted to alert her on the road as they had observed flames emanating from underneath the vehicle. No warning lights were illuminated. The vehicle was towed to a storage facility but had yet to be deemed a total loss by the contact's insurance provider. A fire report was filed. A police report was not filed, and injuries were not reported. The manufacturer was not notified of the failure. The failure mileage was 106,334.

Filed May 17, 2025 · Engine · FL · fire

[XXX] brought car in to dealer with engine problem, I was told it needed a new engine and would be replaced under warranty. April 27th 2025 I picked up my car, two weeks later on [XXX], driving home from work the engine caught on fire, I was able to pull over, got out and called 911. In 5 minutes the whole front end was engulfed in flames. Coconut Creek Police arrived first, then the fire department. The fire department extinguished the fire. I didn't notice any warning lamps, car was driving fine, I filed a claim with my insurance, AAA, I also spoke with the KIA service manager about it, He said it could have been an old brittle fuel line, they only replaced the engine. My AAA insurance company has the vehicle and is inspecting it. The Coconut Creek Police in FL has a report # [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 13, 2025 · Engine · PA · fire

The engine was replace May 1, 2025 and on May 11, 2025 the car caught on fire. It was a total loss.

Filed Feb 10, 2025 · Brakes · 100,000 miles · MO · fire

The contact owns a 2012 Kia Sorento. The contact stated that upon parking the vehicle at his home, an abnormal burning odor began to emit from the vehicle's vents. Upon inspection of the vehicle, the contact discovered that the engine had caught fire and did not engulf beyond the vehicle's firewall. The contact used his home's water hose and sprayed the engine for approximately 25-30 minutes until the fire was fully extinguished. The police and fire departments were not notified of the failure and no injuries were reported. Upon investigation, the contact discovered the federal safety agency Campaign Number: 23V652000 (Service Brakes, Hydraulics) which was linked to the failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was not repaired. The failure mileage was approximately 100,000.

Filed Jan 13, 2025 · Brakes · 142,739 miles · AR · fire

The contact owned a 2012 Kia Sorento. The contact stated that while the vehicle was parked and unoccupied, she was informed by an individual if she was the owner of the vehicle since it was smoking and caught on fire. Prior to the fire, unknown warning lights would illuminate and un-illuminated intermittently. The Fire Department was on the scene and extinguished the fire. The vehicle was towed to an impound lot and then towed by the insurance company. The vehicle was deemed a total loss by the insurance company. The local dealer was contacted; however, the vehicle was not repaired due to the VIN not being included in a recall at the time the failure occurred. The contact received the federal safety agency Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC) after the vehicle caught fire and was destroyed. The manufacturer was not made aware of the failure. The failure mileage was approximately 142,739.

Filed Aug 28, 2024 · Electrical, Engine · ME · fire

On August 23rd 2024, I drove this vehicle all day. But, upon reaching our final destination (ER department entrance) smoke began rolling out from under the hood. Once getting out to inspection the vehicle someone hollered for a extinguisher. I turned to look at the vehicle and I could see underneath of the 2012 kia sorento had flames. My son was still in the car so my mother and I ran to get him out of his rear facing carseat and ran away from the vehicle. At this time the vehicle still had a fire that went out with extinguisher but quickly light back up. After this the whole are and car filled with smoke. Fire department was called and this took them awhile to fully extinguish the fire. This could have hurt myself, my child, and my mother. I lost alot of valuable things including my son's new carseat, my children's double stroller, a tablet, clothing, etc. I have called Kia as I found out there was a recall that kia has none about and started sending notices out November 14th 2023. My vehicle sat at a kia dealership from January to March 6th and if this recall was so drastic such as a car fire why was this not taken car of when my vehicle sat for 2 months. I have a call into Kia as of Monday August 26th 2024. I am still waiting for a rep to be assigned my claim and to speak to them. As of Today August 28th 2024 Noone has reached out to me.