The failed/malfunctioning component appears to be the fuel pump controller / fuel pump control unit, and possibly the fuel pump system. The Mercedes-Benz dealer identified water/moisture-related damage and corrosion at the fuel pump controller area. The failed component should be available for inspection if the dealer preserves the part during repair. I have requested that the dealer not discard the damaged component. My safety and the safety of others were put at risk because the fuel pump controller is related to fuel delivery. If it fails, the vehicle may not start, may lose fuel supply, or may stall while driving. This creates a safety risk, especially if the vehicle stalls in traffic, at an intersection, on a highway, or during normal driving. The problem has been confirmed by a Mercedes-Benz dealership. The dealership diagnosed water/moisture damage to the fuel pump controller area and provided an estimate of $768.22 for fuel pump controller replacement, plus $244.88 for the inspection fee. The dealer also indicated that this was the first inspection and that the fuel pump itself may also need further inspection or may have related damage. The vehicle/component has been inspected by a Mercedes-Benz dealership. Mercedes-Benz USA / the manufacturer’s representative has also reviewed the case through its goodwill process, but they refused to treat it as recall-related coverage. To my knowledge, the vehicle has not been inspected by police or insurance representatives. Prior to the current failure, the vehicle had starting/no-start related symptoms beginning around the middle of 2023. The engine could not start successfully at times. I do not recall receiving a clear warning lamp or message specifically identifying the fuel pump controller before the failure. However, the symptoms were consistent with a fuel delivery problem, and the dealer later confirmed water/moisture corrosion damage in the fuel pump controller area.
The worst 2015 Mercedes-Benz ML350 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Engine11
- Fuel system8
- Transmission7
- Brakes6
- Body4
- Electrical4
- Steering4
- Suspension4
- Acceleration3
- Airbags3
- Seat belts2
- Visibility2
- Driver assistance1
- Lights1
- Locks1
- Tires1
- Wheels1
Specific symptoms reported on the 2015 Mercedes-Benz ML350
Recalls 5
Fuel system, diesel: delivery: fuel pump: control/drive module
- What is wrong
- Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML550, 2012-2015 ML350, AMG ML63, 2015 ML250, ML400, 2016 GLE450, GLE300, 2016-2018 GLE350, GLE550, 2016-2019 GLE400, 2017-2019 AMG GLE43, and 2016-2020 AMG GLE63 vehicles. Water might accumulate in the spare tire wheel well and damage the fuel pump control unit, which could cause an engine stall while driving.
- Risk
- An engine stall while driving increases the risk of a crash.
- Remedy
- Dealers will install a water drain plug, inspect for water intrusion, and replace the fuel pump control unit as necessary, free of charge. Owner notification letters were mailed February 15, 2023. Owners may contact MBUSA customer service at 1‑800‑367‑6372. MBUSA's numbers for this recall are 2023010002 and 2023010003.
Recall number 22V955000 · Recall details
Communication
- What is wrong
- Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2013-2017 vehicles due to a software fault that may cause the date and time for the emergency call system (eCall) to differ from the actual date and time, potentially relaying an inaccurate vehicle location. For a full list of the affected models visit:
- Risk
- An inaccurate vehicle location may delay emergency responders, increasing the risk of injury.
- Remedy
- MBUSA has initiated an Over the Air (OTA) remote update. MBUSA will also notify owners, and dealers will check software for a successful OTA or update the communication module software as needed, free of charge. The recall began December 23, 2019. Owners may contact MBUSA customer service at 1‑800‑367‑6372. MBUSA's number for this recall is 2019120008.
Recall number 19V787000 · Recall details
Suspension: front
- What is wrong
- Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML350 Bluetec 4Matic and ML550 4Matic, 2012-2015 ML63 AMG 4Matic and ML350 4Matic, 2013-2016 GL350 Bluetec 4Matic, GL550 4Matic and GL63 AMG 4Matic, 2017 GLS350d 4Matic, GLS450 4Matic, GLS550 4Matic and GLS63 AMG 4Matic, 2015 ML400 4Matic, 2016 GLE400 4Matic, GLE350 4Matic, GLE63 AMG 4Matic, GLE63S AMG 4Matic, GLE450 4Matic Coupe and GLE63S AMG 4Matic Coupe, 2015-2016 GL450 4Matic and 2013-2014 GL450 4Matic vehicles equipped with the Active Curve System (ACS). In certain driving conditions, if the oil level in the ACS reservoir is below the minimum level, the oil may foam and leak out of the vent holes in the reservoir cap.
- Risk
- The leaking oil in the presence of an ignition source can increase the risk of a fire.
- Remedy
- MBUSA will notify owners, and dealers will correct the oil level as necessary and replace the reservoir sealing cap to prevent oil foam from leaking out, free of charge. The recall began August 30, 2018. Owners may contact MBUSA customer service at 1‑800‑367‑6372. MBUSA's number for this recall is 2018070015.
Recall number 18V272000 · Recall details
Power train: axle assembly: axle shaft
- What is wrong
- Mercedes-Benz USA, LLC. (MBUSA) is recalling certain model year 2015 GL350 4Matic Blutec, GL450 4Matic, GL550 4Matic, ML250 Blutec, ML350, ML350 4Matic, ML400 4Matic and 2015-2016 GL63 AMG 4Matic vehicles manufactured September 29, 2014 through March 27, 2015. The affected vehicles have axle bolts on the front and/or rear drive axle carriers that may not have been assembled correctly. As a result, the remaining bolts may fracture.
- Risk
- If any of the remaining front or rear axle bolts fracture, the vehicle may be unstable, reducing the handling capability and increasing the risk of a crash.
- Remedy
- MBUSA will notify owners, and dealers will replace the axle carrier bolts, free of charge. The recall is began February 2017. Owners may contact MBUSA customer service at 1‑800‑367‑6372.
Recall number 16V900000 · Recall details
Seat belts: rear/other
- What is wrong
- Mercedes-Benz USA, LLC (MBUSA) is recalling certain model year 2015 ML250, ML350, ML350 4Matic, ML400 4Matic, ML63 AMG, and 2016 GLE450 AMG 4Matic vehicles manufactured from April 27, 2015, through May 19, 2015. The affected vehicles may have had the right rear seatbelt anchor bolt incorrectly installed.
- Risk
- In the event of a vehicle crash, the right rear seatbelt anchor bolt could fail to secure the passenger, increasing their risk of injury.
- Remedy
- MBUSA will notify owners, and dealers will inspect and, if necessary, correct the installation of the right rear seat belt anchor bolt, free of charge. The recall began on July 22, 2016. Owners may contact MBUSA customer service at 1‑800‑367‑6372.
Recall number 16V442000 · Recall details
Technical service bulletins for the 2015 Mercedes-Benz ML350 125
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Mercedes-Benz USA, LLC will provide an Extended Modification Warranty for each vehicle that has received...
- Visibility/wiper
- Customer complaints relating to automatic transmission 725.0 (NAG3 Classic /9G‑TRONIC automatic...
- Repeat workshop visit for vehicle vibration while braking from 60MPH. NOTE: Although the symptom is...
- Only vehicles with a variable transfer case are affected
- Clanking noise from the area of the speakers in the doors
- Customer complaints relating to automatic transmission 725.0 (NAG3 Classic / 9G‑TRONIC automatic...
- During part of the steering movement, it feels heavier or more difficult to steer in the same spot every time
- This document is intended as a pre-case diagnostic reference for transmission related concerns
- Mercedes-Benz USA is currently experiencing limited availability of transmission fluid specification ATF...
What 2015 Mercedes-Benz ML350 owners say
Most recent owner complaints, unedited.
In July 2025, the sunroof panel had lifes and was flapping at highway speeds. I immediately contacted a Mercedes-Benz dealer to report the hazard. I was told they were unaware of such an issue and that I would have to pay for the repair out-of-pocket. Due to financial hardship, I could not afford the repair at that time. in. In early February, while driving on the highway, the entire sunroof panel catastrophically detached and flew off the vehicle. This created an immediate and severe road hazard for other drivers. This incident matches the 'adhesive bonding failure' described in other Mercedes-Benz sunroof recalls (e.g., Recall 21V‑197), but my specific VIN was not included in that list.
In mid-trip as we were going down the highway went to change lanes and the turn signals were no longer functioning. No errors, no alerts, no warnings they just stopped working. After pulling over and turning off the vehicle and turning back on they work for a time then stop working again. After researching with other owners of these and similar model Mercedes Benz vehicles this is a prevalent and highly dangerous safety issue that many many others have experienced.
Cam Shaft replacement diagnosed after week and half visit to Mercedes Benz dealership for engine rattling at cold start up. We are left with a $10,000 repair after performing all scheduled maintenance at the Mercedes Benz dealership since owning in 2015.
The contact owns a 2015 Mercedes-Benz ML350. The contact stated that while driving at various speeds, the vehicle shook abnormally before the vehicle lost automotive power. The contact was able to restart the vehicle and take the vehicle to a local dealer. The contact stated that the vehicle was repaired under the federal safety agency Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline); however, the repair failed to prevent the failure. The contact stated that two weeks after the recall repair, the failure reoccurred. The check engine warning light was illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The vehicle was scanned by a local independent mechanic who retrieved DTC: P035413, A10D, P072102, U016886, V1FBD04, 94C3, V1DAV54, V1DBD31, P030085, and V142E31. The manufacturer was made aware of the failure. The failure mileage was approximately 88,000.
I was in drive mode and was looking to park the car on the open spot on the street. Had engaged the reverse gear and was attempting to get in the parallel parking spot. While i was doing that, suddenly the wheel locked up and car stopped with a jerk/jolt. Then came warning that the parking brake was not working (Remember I had not engaged the parking brake as I was in drive mode). The locked up wheel would not move and I had great difficulty in making the car safe in the cross traffic. The issue here is parking brake cannot engage by itself. That has nothing to do with the age of the car, it is like the wheel cannot come off just because the car is old. This could have easily happened while the car was in motion at a higher speed, in that case with 1 wheel locked, a car would spin out of control in a moving traffic causing major damage to other vehicles and myself. Mercedes's rep claimed it was a maintenance item. Parking brake engaging by itself is a maintenance item?? We should put a notice to all customers and your life is in danger because the parking brake can engage by itself locking the wheel anywhere anytime. I am very apprehensive of this design which allows for auto lock of a wheel. It must be investigated and all the parking brake systems should be replaced as it can happen to anyone. Thank you
The contact owns a 2015 Mercedes-Benz ML350. The contact stated while reversing, the vehicle stalled and failed to restart. The vehicle was towed to the local mechanic who determined that the fuel pump was faulty and needed to be replaced. The fuel pump was replaced, and the vehicle was repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was included in the federal safety agency Campaign Number: 22V955000 (Fuel System, Diesel, Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 120,000.
The center console box will jot close. I have researched and this is a common problem with this car. You can not just replace the closure part it requires a whole new box. This is at a cost of 400.00plus dollars. This is obviously a defect.
precense of some liquik oil from up motor litle meiby ist because change oil because i buy recently , i need observed ,ore time today i clean this area.
The contact owns a 2015 Mercedes Benz ML350. The contact stated that the rear driver’s side door failed to close properly after several attempts. The vehicle was taken to a dealer and the contact asked the mechanic to inspect the vehicle. The door failed to open after several attempts. The contact was provided an estimate for the repair. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 58,000.
Compare the 2015 Mercedes-Benz ML350
Other model years
Questions about the 2015 Mercedes-Benz ML350
Is the 2015 Mercedes-Benz ML350 reliable?
Owners have filed 52 complaints about the 2015 Mercedes-Benz ML350, fewer than a typical ML350 model year.
What is the 2015 Mercedes-Benz ML350 year score?
The 2015 Mercedes-Benz ML350 scores 74 out of 100 (average). The score compares it with the other model years of the Mercedes-Benz ML350: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2015 Mercedes-Benz ML350?
Engine and cooling, with 11 complaints, typically around 15,750 miles. Next is fuel system (8).
How many recalls does the 2015 Mercedes-Benz ML350 have?
5 recalls, covering fuel system, diesel, communication and suspension.
What year does the Mercedes-Benz ML350 have bad engine?
The Mercedes-Benz ML350 model years with the most engine complaints are 2012 (23 complaints), 2014 (17 complaints) and 2013 (13 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Mercedes-Benz ML350?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history