The contact owned a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the vehicle was involved in a crash. The contact stated that the vehicle flipped over and landed on its roof of the vehicle. The air bags did not deploy. The vehicle was towed to a local tow yard. The contact was later taken to the local medical center. The contact sustained pain and bruises to the chest area, the left and right knees from the impact of the steering wheel, the middle back, and the left side hip. A Police report was filed. The vehicle was deemed a total loss by the insurance company. In addition, the contact stated that an unknown recall for the air bag was completed in 2025. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000.
2010 Mercury Milan: airbags did not deploy in a crash
5 of the 1,003 complaints about the 2010 Mercury Milan describe airbags did not deploy in a crash.
- owner complaints
- 5
- of this car's complaints
- 0%
- recalls
- 6
Airbags did not deploy in a crash by model year
- 20105
- 20093
- 20085
- 20073
- 20061
What owners say
I collided with three parked vehicles and my airbags did not deploy causing me to hit my head
Tl* the contact owned a 2010 mercury milan. While driving approximately 45 MPH, the driver crashed into the rear of a second vehicle. The front end of the vehicle was severely damaged, but the air bags did not deploy. There were no injuries. A police report was filed and the vehicle was towed away. The vehicle was destroyed. The cause of the failure was not determined. The manufacturer was notified of the failure. The local dealer (sellers sexton ford, 341 vfw memorial dr, st. Roberts, mo) was notified. The contact indicated that the vehicle was previously serviced per an unknown takata recall. The failure mileage was 170,000.
Tl* takata recall. The contact owns a 2010 mercury milan. The contact stated that the federal safety agency campaign number: 18v04600 (air bags) exceeded a reasonable amount of time for repair. The contact received the recall notice in february of 2018. The dealer and manufacturer were not contacted. The contact had not experienced a failure. Vin tool confirms parts not available. *tt consumer stated airbag failed to deploy upon low speed impact. Passenger bruised,sore and with back issues. Updated 10/16/18*jb
I have mercury milan and I had an accident. A car was turning and turned in front of me I swerved and hit the car that was turning a stop sign, street sign, and a tree. The air bags did not deploy. The car was totaled.
Service bulletins that may apply
Related recalls
Air bags: frontal: driver side: inflator module
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
- Risk
- An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
- Remedy
- Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 21S12.
Recall number 21V158000 · Recall details
Air bags: frontal: passenger side: inflator module
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
- Risk
- In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
- Remedy
- Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 21S05.
Recall number 21V081000 · Recall details
Air bags: frontal: passenger side: inflator module
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
- Risk
- An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
- Remedy
- Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 13, 2019. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall 19S01.
Recall number 19V001000 · Recall details
Air bags: frontal: passenger side: inflator module
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2010 Ford Fusion, Mercury Milan and 2010-2012 Lincoln MKZ vehicles that previously received a replacement passenger air bag under recall 16V‑384, 17V‑024 or 18V‑046. In the event of a crash requiring deployment of the passenger air bag, the bracket that secures the air bag inflator to the module housing may deform, allowing the gas that inflates the air bag to leak out.
- Risk
- If the air bag does not inflate as intended, there is an increased risk of injury in the event of a crash.
- Remedy
- Ford will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began November 21, 2018. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 18S34.
Recall number 18V775000 · Recall details
Air bags: frontal: passenger side: inflator module
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2013 Ford Mustang vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2010 Ford Edge, Fusion, Mustang and Ranger, Lincoln MKX and Zephyr/MKZ, and Mercury Milan vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2009 Ford Edge, Fusion, Mustang and Ranger, Lincoln MKX and Zephyr/MKZ, and Mercury Milan vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
- Risk
- An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
- Remedy
- Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 19S01.
Recall number 18V046000 · Recall details
Air bags: frontal: passenger side: inflator module
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
- Risk
- An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
- Remedy
- Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 19S01.
Recall number 16V384000 · Recall details
Questions about the 2010 Mercury Milan no deployment
Is airbags did not deploy in a crash a common problem on the 2010 Mercury Milan?
5 of 1,003 owner complaints about the 2010 Mercury Milan (0%) mention airbags did not deploy in a crash. The model year with the most reports is 2008.
Is there a recall or service bulletin for this on the 2010 Mercury Milan?
There are 6 recalls and 2 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2010 Mercury Milan
Power steering loss 126Loss of power 113Stalling 111Check engine light 79Jerking 47Headlights 45ABS 39Won't shift 24Brake failure 21Steering lock-up 20Engine failure 14Door locks 12Adaptive cruise 11Hesitation 11Misfire 9Fuel leak 7Airbag light 6Fuel smell 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 2010 Mercury Milan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history