While driving at low speed performing a turn in a residential area, the vehicle suddenly displayed a “Steering Assist Fault” warning message and the steering wheel became completely locked with essentially no movement possible. I attempted to turn the wheel with extreme force but it would barely move, creating a serious safety hazard. I was fortunately driving slowly at the time. If this had occurred at higher speed or in traffic, it could have caused a crash, serious injury, or even death. Prior to the incident, there had occasionally been a slight amount of unusual tension/resistance felt while turning the steering wheel, although it was minor and inconsistent before the complete failure occurred. The failure happened suddenly while driving normally. The issue appears related to the electronic power steering (EPAS) / steering assist system. Similar steering assist failure complaints and recalls/investigations have existed on related Ford Fusion/Mercury Milan vehicles involving sudden loss of steering assist and steering control concerns. The vehicle is also currently affected by brake recall 19S54/19V904 involving braking performance concerns, increasing overall safety concerns regarding the vehicle. At the time of filing this complaint, the steering issue has not yet received a complete repair or confirmed diagnosis because the manufacturer and dealer stated the VIN is not currently included under steering recall coverage.
2010 Mercury Milan: loss of power steering
126 of the 1,003 complaints about the 2010 Mercury Milan describe loss of power steering.
- owner complaints
- 126
- of this car's complaints
- 13%
- typical repair cost reported
- $2,000
- typical mileage
- 93,235
- recalls
- 0
Loss of power steering by model year
- 201146
- 2010126
- 20081
- 20073
- 20061
What owners say
The contact owns a 2010 Mercury Milan. The contact stated that while driving approximately 30 MPH, the "Service Traction Control" and “Power Steering Sensor” warning lights illuminated. The contact stated that the steering wheel became difficult to turn to the left or the right. The contact was able to drive the vehicle back to the residence. The local dealer was contacted and sent an agent to the residence to drive the vehicle to the dealer. The vehicle was diagnosed, and it was determined that the power steering assist had failed, and the steering gears and rack, and pinion needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 60,562.
I experienced a loss of power steering while driving and a dash display "Service Power Steering Now" and "Service Advancetrac". The messages started just before the failure. The lack of power steering was a risk to everyone as the car could only be turned with significant effort and not respond to quick movement. The dash messages are still on after a restart and the car cannot be driven because of safety. My independent mechanic confirmed the issue and fix to be a bad rack. He noted the rack part number is the same as the 2011 Milan, currently under recall for this issue. However, the 2010 is not included.
started vehicle, "power steering assist fault" message appeared on dash message center, unable to turn steering wheel. Turn car off, waited, turn back on, message appeared again. tried an additional 3 times, same results. Had to leave the car where i was visiting.
The contact owns a 2010 Mercury Milan. The contact stated that the power steering assist became inoperable. The driver was unable to turn the steering wheel. The contact stated that the steering wheel had seized. The vehicle was restarted, and the steering wheel operated as designed. The power steering assist fault and service power steering soon messages were displayed. The contact stated that the failure was related to the federal safety agency Campaign Number: 15V340000 (Steering). The local dealer was contacted, and the contact was referred to the Ford Warranty Department for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 38,000.
After turning the car on one morning, an alert displayed on the dash saying "Power Steering Assist Fault" and "Service Advancetrac". I turned the car off, and back on, but the same message appeared. When driving, there is no power steering and it is difficult to turn the steering wheel. The Milan only has 110,000 miles. Ford needs to issue a recall as this is obviously a defect affecting many customers.
I have a 2010 Mercury Milan with only 60000 miles on it and the electric power steering went out. It happened while i was driving causing the car to hard right. The part costs $900 and then it has to be programmed at a dealership. I know there was a recall for this but only for the 2011 model. After researching and reading other safety complaints, it's pretty clear that a recall should be done for the 2010 model.
I have a 2010 mercury milan premier thats power steering went out I found out the part has been recalled on the 2011 model but not the 2010 model and it's the same exact part so now the 2011 has been recalled but not the 2010 and I'm out over 600 dollars + to fix it
The contact owns a 2010 Mercury Milan. The contact stated that at start-up and while driving at various speeds, the power steering assist fault message was displayed on the instrument panel. The contact stated that excessive force was needed to steer the vehicle due to the failure. The dealer and the manufacturer were both notified of the failure and informed the contact’s husband that there were no recalls on the VIN. An independent mechanic was notified of the failure and the contact was provided an estimate for the repair. The vehicle was not repaired. The failure mileage was approximately 67,000.
Steering became hard to steer. Power steering assist failure light on and 75 years old hardly could turn wheel. Many 2010 Milan's are having same problem. I cannot afford the repair. I noticed 2011-2012 Milan's are recalled for a fix not 2010??? Please help
The contact owns a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The "Service Power Steering" message was displayed. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 188,000.
When starting to drive 2 days ago multiple braking warnings went off on the vehicle, including Advance Trac warnings. The vehicle became extremely difficult to stop, requiring high pressure on the pedal. It was able to be stopped safely as there was an empty parking lot nearby. It was taken to a Ford Dealership (Tri-County Ford) and diagnosed with a failure of the ABS Control Module. The part was confirmed by the dealer to be the same as in the federal safety agency recall # 19V904000 (Ford recall 19S54). Repair cost $1220, dealer advised calling Ford. I then called Ford who informed me that my specific VIN was not covered under the recall. There were no issues or warnings prior to this event. The worst part is that this is the second time such an serious incident has occurred with my vehicle which could have harmed or killed me or others. In 2019 the Power Steering failed spontaneously on the car while driving and again, the 2011 Milan Hybrid was covered but not my specific 2010 VIN (I filed a separate the federal safety agency complaint and sent a letter to Ford yet there were multiple reports prior, and multiple similar reports since then, sadly). I have now experienced two major safety events with the vehicle. Thankfully I was very fortunate to walk away from both (at a combined cost of $3000), yet these should have been corrected by Ford and covered under recalls. I am an emergency medicine physician who takes care of people injured in motor vehicle accidents. Shame on you, Ford and the federal safety agency for failing to correct either problem and for keeping similarly unsafe and unrepaired cars on the road! Make sure the correct vehicles are covered with these recalls and if not and additional reports come in, it is your duty to expand them to keep the public safe!
Service bulletins that may apply
Related recalls
No recalls on record for this model year.
Questions about the 2010 Mercury Milan power steering loss
Is loss of power steering a common problem on the 2010 Mercury Milan?
126 of 1,003 owner complaints about the 2010 Mercury Milan (13%) mention loss of power steering. The model year with the most reports is 2010.
How much does it cost to fix loss of power steering on the 2010 Mercury Milan?
Owners who mentioned a price put the repair at about $2,000 (median of 21 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
Is there a recall or service bulletin for this on the 2010 Mercury Milan?
There are 0 recalls and 3 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 2010 Mercury Milan
Loss of power 113Stalling 111Check engine light 79Jerking 47Headlights 45ABS 39Won't shift 24Brake failure 21Steering lock-up 20Engine failure 14Door locks 12Adaptive cruise 11Hesitation 11Misfire 9Fuel leak 7Airbag light 6No deployment 5Fuel smell 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 2010 Mercury Milan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history