2023 Nissan Rogue: engine overheating

Filed Oct 31, 2026 · Engine · NC

After taking the Nissan Rogue to the dealer where I purchased the vehicle, the dealer was able to reproduce the reported issue of the vehicle not starting. After completing an inspection of the vehicle, it was determined that due to the EGR Cooler failing, coolant leaked and mixed with the engine oil that caused a catastrophic engine failure. There were no warning messages or symptoms prior to the engine failure.

Filed Oct 28, 2026 · Engine · KS

Vehicle Mileage: 82,775 Component Affected: Engine / Cooling System / Fuel/Emission System (EGR Cooler) My 2023 Nissan Rogue equipped with the 1.5L VC-Turbo engine suffered a catastrophic internal engine failure, leaving the vehicle completely inoperable and causing a dangerous situation due to severe engine overheating (Diagnostic Trouble Code P1217). A professional inspection and pressure test by a certified technician (Repair Order #38473) revealed that the Exhaust Gas Recirculation (EGR) cooler completely failed to hold pressure. As a direct result of this internal component failure, coolant drained entirely from the reservoir and rapidly flooded Cylinder 2. The coolant cross-contaminated the engine lubrication system, mixing water into the engine oil and permanently destroying the internal integrity of the long block engine assembly. The vehicle now requires a completely new long block engine, turbocharger, catalytic converter, and EGR cooler. Nissa is currently aware of widespread, premature catastrophic engine failures across this exact 2023 Rogue 1.5L VC-Turbo engine line, having issued a massive engine replacement recall and 10-year/120,000-mile warranty extension in March 2026 (the federal safety agency Campaign 26V080) for main crankshaft bearing failures. However, Nissan is currently exploiting a technical loophole to deny coverage for my vehicle. Because the root cause of my engine's destruction was an internal EGR cooler pressure failure rather than a crankshaft bearing failure, Nissan claims it is exempt from covering the repair despite the final mechanical damage, safety risk, and engine destruction being completely identical. Nissan should not be permitted to avoid liability for a known, systemic powertrain defect by restricting recall remedies to a singular root cause when adjacent components like the EGR cooler are causing identical, catastrophic engine failures well under their self-declared 120,000-mile engine lifespan. It is identical to what has been happening.

Filed Oct 28, 2026 · Engine, Transmission · TX

I am reporting repeated loss of engine power and subsequent engine failure involving my 2023 Nissan Rogue SV equipped with the 1.5L VC-Turbo engine. On February 3, 2026, at 151,975 miles, Nissan of Boerne performed recall R25D1 and campaign PA447. Following that service, the vehicle experienced repeated loss of power and limp-mode conditions, creating a safety concern while driving because the vehicle could not accelerate normally. In April 2026, World Car Nissan documented an engine malfunction complaint accompanied by forward and rear collision warning lights. In May–June 2026, at 163,589 miles, Nissan of Boerne confirmed trouble code P2564 and diagnosed a turbocharger wastegate stuck open. The dealership replaced the turbocharger assembly. In September 2026, at 172,431 miles, the vehicle again experienced a severe loss of acceleration. The engine RPM increased when pressing the accelerator, but the vehicle would not accelerate normally. The dealership documented the complaint as loss of power without warning lights and replaced the three-way catalytic converter. In October 2026, Nissan of Boerne diagnosed a blown head gasket, coolant leaking into cylinder 3, overheating, and trouble code P04FA (EGR over-temperature). The dealership recommended replacing the engine long block for $7,166.52. The vehicle is currently inoperable. These problems have been examined by authorized Nissan dealerships, and the service invoices document the diagnoses and repairs. The vehicle's current condition may be available for inspection through the dealership, subject to confirmation. I am concerned about the recurring loss of power, the potential danger of being unable to accelerate in traffic, and whether the vehicle was adequately inspected under applicable VC-Turbo engine safety recalls. Nissan Consumer Affairs advised that the recall had been completed and declined further assistance.

Filed Oct 26, 2026 · Engine · TX

Complete engine failure due to leaky EGR valve at 74k miles. Vehicle overheated suddenly in the middle of busy traffic, needing to stop the vehicle in the middle of the road. Problem has been confirmed by an independent contractor. Vehicle has not been inspected by manufacturer or dealership, due to high cost of diagnosis and car being just out of warranty. There was no warning lamp or symptoms before failure.

Filed Oct 21, 2026 · Engine, Fuel system · CA

2023 Nissan Rogue SV Midnight Edition, 1.5L 3-cylinder VC-Turbo. Bought Nissan Certified Pre-Owned 12/11/2024 at 6,843 miles. Recall 25V‑437 (engine bearings, Nissan R25D1) was open on my car and never done before the failure, even though I was at the dealer 1/6/2026 after the remedy came out. On 9/9/2025 at 19,759 miles I told the dealer the car burps, the RPMs drop and it loses power from a stop. They said it was operating as designed. On 7/9/2026 at 29,203 miles I was driving at normal street speed with my mother and my dog in the car. The RPMs surged and the engine ran rough with heavy vibration. I pulled into my parking spot, thick white smoke poured out of the exhaust and a burning wire smell came into the cabin. I got them out. It would not restart. No warning lights at any point. The dealer found coolant in the oil and coolant leaking between the head and block, and replaced the engine, turbo, catalytic converter and 2 sensors under the recall. The new engine kept having problems. 8/12 cylinder 3 misfire before I picked it up. 8/19 check engine light on the freeway. 8/21 limp mode on the street: Engine Malfunction, Power reduced, Service now, and a collision warning message. Code P0303, cylinder 3 injector replaced. Codes set again on the dealer's test drive in heavy traffic and the advisor had to pull over, so all injectors were recalibrated. At least 16 Nissan text alerts and 4 alert emails. 54 days out of service. After that I had a fuel smell in the cabin, loss of power on hills, then engine roughness and a burning rubber smell until I turned it in. Nissan bought it back under the California lemon law on 10/20/2026 at 30,995 miles. Nissan engineers inspected it at the dealer in August. The car now belongs to Nissan, and I do not know what happened to the original engine. Full timeline attached.

Filed Oct 16, 2026 · Engine, Transmission · WI

Vehicle began overheating out of nowhere on highway fluctuating up and down it happened right as I was getting home, towed in for service the next morning the company has been stonewalling me on the information I’ve asked for . I’ve asked for freeze frame data and the codes so I can know the moment everything occurred but they haven’t released the informative asked of them. Also asked to perform a metal shaving testing for them on the oil pan from the bearing but they haven’t released if it was found or not and gave me a lack of loyalty and it being a used car as reason for denial. I’ve only been thru Nissan dealers since I’ve got the car. But this isn’t as much of a goodwill as it is a warranty issue that known with a this engine and Nissan affairs basically didn’t listen to my complaints about the dealer ship service manager and open a goodwill case instead of looking into if it was more vehicles effected by this same engine issue

Filed Aug 14, 2026 · Electrical, Engine · 95,600 miles · PA

The contact owns a 2023 Nissan Rogue. The contact stated that while driving out of town, the vehicle suddenly went into LIMP Mode. The accelerator pedal was depressed; however, the vehicle failed to exceed 70 MPH and decelerated unintendedly. The vehicle was driven approximately 30 MPH to the residence. The message “Engine Malfunction” was displayed, and the temperature gauge rose to HOT. The 4WD message was displayed. The vehicle was pulled over and inspected, and the contact became aware that one of the coolant reservoirs was empty, and coolant was added to the coolant reservoir. The odometer and infotainment screen also repeatedly turned on and off. The vehicle was towed to a local Nissan dealer, where it was diagnosed with a coolant leak in the engine, which caused the engine failure and turbocharger failure. The vehicle was not repaired. The vehicle was previously repaired under the federal safety agency Campaign Number: 26V080000 (Engine and Engine Cooling). The manufacturer opened a case regarding the failure but offered to cover only 30 percent of the cost of the repair. The failure mileage was approximately 95,600.

Filed Jul 28, 2026 · Engine, Fuel system · CA

The vehicle was running when it overheated and started smoking from the gasket area, with no warning lights appearing on the dashboard; the car will not start now.

Filed Jun 4, 2026 · Engine · SC

Purchased 2023 Nissan Rogue March 2026 drove for 3 months never was informed of a recall. On XXX would not start but it did after removing key from FOB then saw a little gray smoke shut the car down and XXX contacted Lugoff Nissan SC was told of recall and that engine was fully covered. Tuesday called again to inquire about progress none was done. Informed me they would not replace engine unless I paid $2,000 to replace catalytic converters but did not do a clog test so not even sure they are damaged but even if they were it is covered under damages caused by a faulty engine oil system cause the oil is cleanse by the converters and which is a Federal requirement but was told they could put old ones back on and I could smoke which was rude and is illegal to run converters that do not function properly and control smog and pollution per the Federal Government. Then agreed to put engine in Wednesday nobody even heard my request that I needed a loaner then worst part was today I was told car had a bad head gasket which I inquired researched talked to two licensed mechanics with over 40 years experience a bad engine causes all that they are refusing to fix oil runs through a system which is filtered by the converters and can damage if not functioning properly and a head gasket is part of the system; it effects the heads by overheating the oil which overheats engine. They said it would be a few days next week before they could check the warranty no it’s been few days it is 10yrs/120,000 extended warranty per the gov required because over 484,000 2023 Nissan engines were defective dangerous mfg in Japan so either or recall or warranty my car is covered I want engine replaced all necessary repairs properly done free of charge a recall engine malfunctioned caused damages; not any my fault and I don’t want to wait a week I can’t even get my [XXX] husband to his cardiology appt. I need answers please asap tomorrow and a loaner while waiting. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C

Filed May 12, 2026 · Engine · GA

On 5/9/2026 my 2023 Nissan Rogue overheated, lost all power and was inoperable. No alerts from dash or Nissan Connect app received. Had to be towed to the Nissan Lithia Springs Dealership and was told that a new engine is needed. My family was in the car and my children had to get out on the highway and walk until a bystander offered to assist. The dealership and Nissan Consumer Affairs is not answering any questions or providing any solutions. The service manger Carrissa is also avoiding all calls related to my vehicle. I see there is an active recall on this issue via the internet but not tied to my VIN number. Filed a case with Nissan Consumer Affairs no response

Filed May 8, 2026 · Engine · MD

I went into the dealorship for an oil change and was told that I had to replace the whole oil pan because it's plastic and breaks. I should not have to worry about replacing the whole oil pan every time I get an oil change or be stranded (since it leaves me no option but to remain at the location until they replace it). This is horrible nissan design and the manufacturer should replace with a metal pan and do a recall. This is very concerning especially in light of the engine recall due to overheating and other parts getting into and damanging the Nissan Rogue engine. Can Nissan guarentee that these plastic pans do not disintegrate over time causing microplastics to destroy my engine and causing my engine to potentially fail while I am driving on the expressway?

Filed May 7, 2026 · Engine · GA

I am the owner of a Nissan Rogue subject to recall campaign R25D1, which addresses a manufacturing defect affecting engine bearings and/or engine components that may progressively fail over time, leading to engine damage and engine failure. I brought my vehicle to Headquarter Nissan in Columbus, GA (the same dealer that issued the recall notice) for diagnosis after experiencing engine problems. The dealer’s diagnostic findings document a complete engine failure consistent with the recall description, including: •EGR valve failure (valve could be opened to 70 degrees with no change in engine performance, when anything over 20 degrees should cause the engine to stall) •Engine overheating •Blown head gasket •Failed EGR cooler •Total coolant loss (vehicle arrived with no coolant; 2 gallons had to be added before fluid registered in the overflow) The dealer’s recommended repair is full replacement of the engine, turbo, catalytic converter, EGR valve, and EGR cooler, along with all gaskets and hardware. The estimate provided is $9,514.72. Despite the failure pattern matching the recall description (progressive component failure leading to engine damage), the dealer is denying recall coverage by attributing the root cause to the EGR cooler rather than the bearings or engine components named in the recall. This causation is also inconsistent with the diagnostic write-up itself, which describes the EGR valve as the initiating failure that led to overheating and subsequent damage to the head gasket and cooler. I am filing this complaint because the dealer’s denial appears to be a reframing of a recall-eligible failure to shift repair costs onto the consumer. I am requesting the federal safety agency review of how recall R25D1 is being applied at the dealer level and whether failures like mine are being inappropriately excluded.