1999 Oldsmobile Intrigue problems

What is wrong

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V‑118, 09V‑116, and 15V‑201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Risk

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy

The remedy applied under recalls 08V‑118, 09V‑116, and 15V‑201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V‑118, 09V‑116, or 15V‑201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1‑800‑222‑1020, Buick customer service at 1‑800‑521‑7300, Oldsmobile customer service at 1‑800‑442‑6537 and Pontiac customer service at 1‑800‑458‑8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Recall number 15V701000 · Recall details

What is wrong

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Risk

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

Recall number 14V400000 · Recall details

What is wrong

General motors is recalling 1,497,516 my 1997-2003 buick regal, my 1998-2003 chevrolet lumina, monte carlo and impala, my 1998-1999 oldsmobile intrigue, my 1997-2003 pontiac grand prix vehicles equipped with a 3.8l v6 naturally aspirated engine. Some of these vehicles have a condition in which drops of engine oil may be deposited on the exhaust manifold through hard braking.

Risk

If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and may spread to the plastic spark plug wire channel and beyond increasing the risk of an engine compartment fire.

Remedy

Dealers will replace the engine’s front valve cover and front-valve-cover gasket with new parts of an improved design and remove the engine’s plastic cover and plastic oil-fill-tube extension, free of charge. The recall is expected to begin during may 2016. Owners may contact chevrolet at 1‑800‑630‑2438, oldsmobile at 1‑800‑630‑6537, and pontiac at 1‑800‑620‑7668 or http://www.pontiac.com or http:www.gmownercenter.com.

Recall number 09V116000 · Recall details

What is wrong

Vehicle description: passenger vehicles. Some of these vehicles were built with rear seat shoulder belts that could twist, allowing the webbing to be jammed in the retractor. When the shoulder belt webbing becomes jammed in the retractor, the seat belt becomes unusable.

Risk

This could prevent a person from using the seat belt system, and a risk of injury to an unbelted person in a crash would be increased.

Remedy

Dealers will remove any twists from the rear shoulder belt(s) and install clips to the belt web guide to prevent twisting.

Recall number 00V044000 · Recall details

What is wrong

Vehicle description: passenger vehicles equipped with a 3.8l v6 engine. Some of these vehicles were built without a heater hose clip which could allow the hose to sag and contact the oxygen sensor resulting in a coolant leak.

Risk

If a coolant leak were to occur, and leaking coolant contacted the hot exhaust manifold, an engine compartment fire could result.

Remedy

Dealers will install a heater hose clip.

Recall number 98V241000 · Recall details

What is wrong

Vehicle description: passenger vehicles. The owner manuals do not contain the requirement information pertaining to the vehicle headlamp aiming device. This does not comply with requirements of fmvss no. 108, "lamps, reflective devices, and associated equipment."

Risk

If the headlamp assemblies are replaced, customers may not be able to properly aim the headlights.

Remedy

Owners will be mailed an owner manual's insert which contains the appropriate information.

Recall number 98V102000 · Recall details

Ea02-030 is closed with gmea02-030 is closed with gm?s actions in 03v‑473 and 04v‑090 recalling approximately 529,000 my 1998-99 c- and h-body vehicles equipped with defective fuel pressure regulators.these vehicles were equipped with plastic intake manifolds that are unable to contain pressures that occur in some backfire events and defective fuel pressure regulators with leaking diaphragms that can provide a source of fuel to produce a combustible air-fuel mixture in the manifold.the closing of this investigation does not constitute a finding by odi that no safety defect exists in the vehicles that are not included in gm?s recalls.odi will continue to monitor the incidence of manifold ruptures and related fires in other my 1995-2002 gm passenger cars equipped with the subject intake manifold.for additional information, see the attached closing report.

EA02030

PE02005

The alleged defect concerns two major symptoms:failure to retract webbing and inability to extend the webbinng for use. The root cause of these symptoms is the design of the trim bezel through which the sebbing passes. Built into the rear package shelf, the bezel includes a vertical slot to facilitate vehicle assembly.the slot is positioned such that the shoulder belt webbing tends to slip into it.webbing ingestion by the vertical slot may retard webbing retraction, or allow webbing twists to accumulate on the retractor spool.in either case, the retractor may fail to maintain appropriate tension on the seat occupant.failure of the shoulder belt to completely retract may also result in an inability to extend it for use if the child restraint cinch feature has been inadvertently engage (by extending the webbing to its maximum length).gm will remedy the alleged defect in the subject vehicles by straightening an twisted rear shoulder belt webbing and them installing a plastic cover that will prevent further webbing ingestion by the webbing guide vertical slot.this engineerign ananlysis is closed.

EA99019