2016 Ram 1500: gas smell in the cabin

Filed Sep 29, 2026 · Engine, Fuel system · 116,000 miles · FL

The contact owns a 2016 Ram 1500. The contact stated that the messages "Service Emissions Control" and "Exhaust Filter 100 Percent Full - Service Required - See Dealer" were displayed, and there was a strong fuel odor coming through the vents while idling or while driving. Additionally, while attempting to refuel the vehicle at the gas station, fuel splashed out and the vehicle could not be refueled. The manufacturer was notified of the failure by phone and initially informed the contact that the vehicle was still covered under Emission Recall Number: V08 and referred the contact to the dealer. The vehicle was taken to the dealer, where it was determined that the failure was associated with the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) and Emission Recall Number: V08; however, the contact was informed that the manufacturer had not approved the recall repairs. The contact called the manufacturer was advised that she would receive a call back from a supervisor; however, the contact had not been contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 116,000.

Filed Sep 10, 2025 · Fuel system · 99,964 miles · NY

The contact owns a 2016 Ram 1500. The contact stated that while his son was driving at an undisclosed speed after the dealer had repaired the vehicle under the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel), the vehicle stalled. The driver was unable to pull over to the side of the road. The vehicle failed to restart. The contact stated that the vehicle was nearly rear-ended several times while in the middle of traffic. The driver called 911, and a nearby Police Officer arrived and redirected traffic away from the vehicle. The vehicle was towed to the dealer, where the driver was informed that the failure had occurred due to air intrusion into the fuel lines while the recall repair was being performed. The dealer informed the contact that the air was removed by turning off and restarting the vehicle several times. The dealer informed the contact's son that the vehicle was drivable. Additionally, the contact stated that there was an abnormally strong fuel odor coming from the vehicle. The contact stated that upon inspecting the vehicle while the vehicle was started, the contact noticed that the fuel line from the HPFP to the driver's side fuel injector rail was leaking. The contact stated that the undercarriage was soaking wet with fuel, and there was a puddle of fuel on the ground while the vehicle was idling. The dealer was notified of the failure and informed the contact that the part had been ordered to repair the vehicle. The contact stated that the dealer failed to perform the recall repair correctly, causing more damage to the vehicle and creating a potential road safety hazard. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 99,964.

Filed Jan 9, 2024 · Fuel system · 110,000 miles · MI

The contact owns a 2016 Ram 1500. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The fuel warning light was illuminated. Additionally, a fuel odor was detected while driving. The vehicle was able to be restarted. The contact later received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer and several other unknown dealers were made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000. VIN tool confirms parts not available. The contact made an appt for Feb 14 to assess the recall. The contact stated she had to cancel the appt. due to unforeseen circumstances, but the dealership wants to charge rental fees.

Filed Jul 5, 2023 · Transmission · NY

My 2016 Ram 1500 Sport developed an exhaust leak originating from the exhaust manifold like many other Rams. I noticed it because I could hear a ticking noise upon starting the vehicle, specifically coming from the passenger side front wheel-well. The vehicle was brought to a local Ram dealer and was diagnosed as having multiple sheared studs on the passenger side exhaust manifold. Due to the truck being over 5 years old, the power train warranty no longer covers this. Ram is well aware of this issue but still refuses to initiate a recall. This issue presents a safety concern and has a potential to endanger myself and any other passengers who get in the vehicle due to raw engine exhaust fumes being released within the engine bay while the vehicle is running which could enter the cabin of the vehicle while in operation causing potential injury.

Filed Jan 14, 2023 · Engine, Fuel system · NJ

My 2016 Ram 1500 Sport developed an exhaust leak originating from the exhaust manifold like many other Rams. I noticed it because I could hear a ticking noise upon starting the vehicle, specifically coming from the passenger side front wheel-well. The vehicle was brought to a local Ram dealer and was diagnosed as having multiple sheared studs on the passenger side exhaust manifold. Due to the truck being over 5 years old, the power train warranty no longer covers this. Ram is well aware of this issue but still refuses to initiate a recall. This issue presents a safety concern and has a potential to endanger myself and any other passengers who get in the vehicle due to raw engine exhaust fumes being released within the engine bay while the vehicle is running which could enter the cabin of the vehicle while in operation causing potential injury.

Filed Aug 27, 2022 · Fuel system · AZ

Fuel pump leaking. Gasoline leaked in garage. I park in a garage and the smell of gasoline extremely strong. Water heater located in garage. Fuel pump replaced on 8/27/2022. No warning lamps or messages.

Filed Apr 29, 2022 · Engine · GA

Header bolt has broken off and have exhaust fumes being released from the engine compart that should be going thru the header and out the exhaust pipes. The dealer is aware and wont repair due to out of warranty when this issue is hazard to the people and the environment

Filed Nov 19, 2019 · Engine · 122,000 miles · WA

When the vehicle's HVAC is activated a very strong smell of exhaust fumes permeates the cab of the vehicle. A haze from the exhaust also enters into the cab. Both of these occurs whether the vehicle is stopped or moving. This requires that the HVAC not be operated.