2016 Ram 1500: engine knocking or ticking

Filed May 21, 2026 · Engine · 161,292 miles · CA

The contact owns a 2016 RAM 1500 The contact stated while driving 55 MPH, occupied with her husband in the vehicle they could hear a knocking and shatter noise coming from the engine. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed that engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified on the failure, and they informed her they will give her cash value for the vehicle and they can run a report until warranty in cancel. The approximate failure mileage was 161,292.

Filed Dec 6, 2024 · Acceleration, Engine · SC

Husbands car started making a ticking noise and was loosing power while driving, so we brought it into the dealership. It will be $5796.58 to fix the rocker arms and camshaft. The estimate is for rocker arm roller failed damaging the camshaft. We are thankful that it has not caused any major incidents while driving that would casue serious harm to him and others on the road. Upon doing research we have found that this is a common issue with the engine that is in his Ram 1500, 2016. It was sold to us and we were not informed that this could be an issue. Again, we are thankful that he was not hurt before we were able to get it to the dealership.

Filed Jul 22, 2024 · Engine · NY

Engine ticking noise. Concerns about safety due to engine failure.

Filed Jul 5, 2023 · Transmission · NY

My 2016 Ram 1500 Sport developed an exhaust leak originating from the exhaust manifold like many other Rams. I noticed it because I could hear a ticking noise upon starting the vehicle, specifically coming from the passenger side front wheel-well. The vehicle was brought to a local Ram dealer and was diagnosed as having multiple sheared studs on the passenger side exhaust manifold. Due to the truck being over 5 years old, the power train warranty no longer covers this. Ram is well aware of this issue but still refuses to initiate a recall. This issue presents a safety concern and has a potential to endanger myself and any other passengers who get in the vehicle due to raw engine exhaust fumes being released within the engine bay while the vehicle is running which could enter the cabin of the vehicle while in operation causing potential injury.

Filed Jan 14, 2023 · Engine, Fuel system · NJ

My 2016 Ram 1500 Sport developed an exhaust leak originating from the exhaust manifold like many other Rams. I noticed it because I could hear a ticking noise upon starting the vehicle, specifically coming from the passenger side front wheel-well. The vehicle was brought to a local Ram dealer and was diagnosed as having multiple sheared studs on the passenger side exhaust manifold. Due to the truck being over 5 years old, the power train warranty no longer covers this. Ram is well aware of this issue but still refuses to initiate a recall. This issue presents a safety concern and has a potential to endanger myself and any other passengers who get in the vehicle due to raw engine exhaust fumes being released within the engine bay while the vehicle is running which could enter the cabin of the vehicle while in operation causing potential injury.

Filed Jun 25, 2022 · Engine · NV

The Main as well as Connecting Rod Bearings prematurely failed at approximately 87,000 miles. Please note that the manufacturer warranty on the 3.0 Diesel engines from FCA/Stellantis is 100,000 miles. As the result, I was stranded on the road with horrible sounds coming from the bottom of the engine block and had to get towed. From my research, I found out that the 1st generation of this engine which I believe were installed on Ram 1500s from 2014 to 2016, had major issues with the above bearing failures well below 100,000 mile warranty period.

Filed May 20, 2022 · Engine · CO

My 2016 RAM 1500 Laramie Crew Cab 5.7 Liter HEMI engine has an engine ticking sound that is most noticeable when the truck is first started when the engine is cold. The ticking sounds does start to go away after one to three minutes, when the engine temperature increases. The ticking noise happens both in the winter and summer when the engine is cold. This engine noise first became noticeable when the truck was two years old with approximately 30,000 miles. I purchased the RAM 1500 Laramie new on October 5, 2016. I am a former Nissan service technician. I am acutely aware of the importance of changing engine oil and oil filter at the manufacturer recommended intervals. I am VERY diligent about changing the engine oil and oil filter every 5000 miles with Mobil One synthetic or Pennzoil Platinum synthetic 5W-20 oil. As of May 20, 2022, my RAM 1500 Laramie has 76,040 miles. Other RAM 1500 5.7-Liter HEMI engine owners have reporting a ticking sound when the exhaust manifold bolts break. I inspected the exhaust manifold bolts on May 20, 2022, and they are not broken.

Filed Apr 9, 2021 · Engine · TN

Broken right side manifold bolt. Leaking and ticking. I paid a large amount for this truck, you need to recall this issue that thousands are having and better bolts and/or manifold.

Filed Sep 29, 2020 · Engine · TX

Exhaust manifold bolts have broken on passenger side. This is a common known issue and ram will not fix the design flaw. They will fix if its still covered under power train warranty . Signal of issue is the ticking at cold startup you can hear by fenderwellls. Will go away once engine is warm.

Filed Jun 30, 2020 · Engine · 64,500 miles · IL

I took my 2016 ram to the dealership with a ticking noise. They told me it was the manifold bolts and that ram were notorious for having this issue. I have 64,500 miles on the truck and they told me it was out of warranty. I then email dodge cares and was asked why we took it somewhere else other than an authorized location when it still had an active warranty? We explained that we were told it did not have an active warranty. They said they would look into it. I get an email today stating that it is not covered. I drive this 3 times a week to deliver meals on wheels. It was very dangerous from my understanding and this is a known problem on rams. They should investigate why this is happening with ram models 2009- current models.

Filed Sep 30, 2019 · Engine, Fuel system · 66,000 miles · CT · fire

I bought my truck on the 25th at 6pm. And at 7p on the 26th it had caught fire on the highway and burnt ro the ground with me and my pregnant wife in the truck. I heard ticking coming from the motor followed by a loud pop and then lost all power no gas response and coasted to breakdown lane just barley got mi wife out of the truck and the truck was fully elguffed.

Filed Sep 16, 2019 · Engine, Transmission · 50,026 miles · NC

I own a 2016 ecodiesel ram 1500, and ever since I completed the required software update on my vehicle due to the class action lawsuit I have noticed a drastic decrease in the amount of acceleration my vehicle has under conditions where the vehicle is not fully warmed up and occasionally under normal driving conditions as well. There are times the vehicle will take 3 to 5 entire seconds to finally start accelerating and when trying to merge into heavy traffic or at intersections this is extremely dangerous! I need to be able to trust the my vehicle will respond in the manner I need it to while traveling highway and local. I become a hazard to other drives as well as to myself and my occupants. The ecodiesel owners community was promised that this software update would not impede fuel economy, engine performance, engine noise, and many other things, yet myself and what appears to be many others are suffering from what can only be classified as a ticking time bomb. When one or multiple lives are lost, will it then be a large enough issue to correct? I cant fear every single intersection and curved road I come across because I am afraid that my engine will respond sluggish and delayed. This is an issue that fca needs to address and quickly!