2019 Subaru Ascent: fire, smoke or burning smell

Filed Mar 24, 2026 · Airbags, Engine · OH · crash · fire · 1 injury

The contact owns a 2019 Subaru Ascent. The contact stated that while his wife was driving at approximately 75 MPH, a deer ran across the highway and hit the left driver's side of the vehicle. The air bags did not deploy upon impact. A grayish smoke began to emit from the vehicle as the contact's wife immediately pulled off to the side of the road. Due to the damaged cause by the impact of the deer, the contact's wife had difficulty exiting the vehicle. The contact's wife used excessive force to open a crack in the door, which was enough to slide herself out of the vehicle. The vehicle became engulfed in flames soon after exiting the vehicle, and the authorities were called to the scene. The fire department arrived at the scene and managed to extinguish the fire. The contact's wife sustained bruising to her left shoulder, left leg, and left arm but did not seek medical attention. A police report was filed. The vehicle was initially towed to an independent tow yard and was later towed to an insurance holding facility. The contact stated that the vehicle was destroyed as a result of the fire, but the insurance adjuster had yet to determine a final ruling on the vehicle. Neither the dealer nor the manufacturer had yet been notified of the failure. The failure mileage was unknown.

Filed Jun 27, 2025 · AL

As a veteran and spouse of an active duty service member, we are currently fulfiling our overseas tour in South Korea. We were notified of the recall of our Subaru Ascent and made contact with Subaru via email for guidance on how to proceed as we are not within the continental United States. My email to them was as follows: Our family is currently stationed overseas in South Korea. Our family has been stationed here the past two years and will be completing an additional duty of two more years here in service of our country. I previously contacted Subaru addressing the concern of the Recall for our PTC Heater Ground Bolt which has been found to be unsafe and can lead to the vehicle catching on fire. It was disheartening to be told we could not be offered assistance as Subaru only services those in the U.S. Subaru prides itself as providing one of the safest vehicles for families on the market which is why we chose Subaru. What can be done to assist us? I look forward to hearing back soon. Subaru responded with: Thank you for reaching out to Subaru of America. Regrettably Since we do not have a reciprocal agreement with Korea we would not be able to assist with the repairs until you return to the states. I do apologize as there would be no other loopholes that we will be able to provide to have the repair done. If fyou have any further questions, you can always give us a call back or email back in as well. Hope you have a good day ahead. We will not be able to ship our vehicle until all recalls have been fixed especially as this specific recall does come with a noted safety risk by Subaru and is as follows: This potential condition may result in the melting of the ground terminal and surrounding components when the PTC heater is in operation, increasing the risk of a fire. I am submitting a claim to acquire assistance as to how to proceed. -thank you.

Filed Jan 27, 2025 · Electrical · KY · fire

I have a 2019 Subaru Ascent Limited model with 96,xxx miles as of January 2025. In 2023, there was a safety recall for the PTC heater ground bolt sent first class mail for multiple year Ascent models. This recall was completed by local subaru dealership on 3/27/2023 stating "WRL 22 completed. Removed ground bolts and cleaned threads. Found no signs of heat damage. Removed and replaced bolts." Move forward to Saturday, [XXX]. I remote started vehicle from inside the house while on vacation in Bristol Tennesee. Car was running for roughly 5 minutes, when fire alarms inside the house starting going off. Seemed odd considering nothing was going on inside. Walked inside to see large amounts of white smoke coming from the windows of the Ascent. I was able to jump into the car and turn the engine off. I opened all 4 doors to let the car air out. I checked the engine, nothing seemed off. I then turned my attention to the air cabin filter, everything seemed normal as well. After the engine cooled and aired out, there is smoke damage to the vehicle. I was able to transport the car safely to Wallace Subaru which was less than 0.25 mile from our airbnb. I was quickly notified by the service technician that the car is not safe to drive until it was fixed. After further investigation, it was found that the PTC ground bolt has failed again, and this time melting the wiring harness and bolt around it. This was right next to the carpet and put my life as well as my wife, who is [XXX] and my [XXX] daughter. Thankfully we weren't in the vehicle when this occurred. There was no warning. No check engine light, nothing. No other issues leading into the incident. Car is still parked in Bristol TN at the dealership and I am 5 hours away in Lexington KY. Subaru has been uncooperative with this situation and is avoiding talking to me or making this situation better. I literally have no answers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 17, 2024 · Electrical, Engine · WV · fire

Over the course of 5 years, a lot has been mechanically wrong with our vehicle. Each service appointment yielded a 'cannot duplicate' response. Recently, my car has been in the service department a few times. My car had recall work performed on a ground bolt, and my husband advised them that the car had a 'rich fuel' smell when starting with the hood open. I've complained since 2021 of a smell when pulling up the mountain. The smell is what I described as a perm solution smell. Each time, the response was 'cannot duplicate.' In February, I took the car in to have the exhaust inspected because it was getting louder each passing day. I was advised that the entire exhaust needed to be replaced, and I would be responsible for costs. I brought my car home, unrepaired, and called Subaru of America to file a claim through them. I had repeatedly expressed concerns, and nothing was done, yet I'm expected to foot the bill now. Since February 12th, I have been back and forth with Subaru and just made the appointment to get the exhaust work completed, with a small contribution from Subaru. However, this past Saturday, [XXX] my vehicle caught on fire while driving. I am fine, but my vehicle has now been deemed a total loss. As I was descending the mountain, I smelled the same 'perm solution' smell, and shortly after, there was smoke coming from under the hood. The smoke entered the cabin as I pulled off the road. Upon exiting the vehicle, flames and smoke were visible from the hood. I grabbed my purse and ran, called 911, and watched my vehicle engulfed in flames. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 26, 2021 · Fuel system · CA

Hi Issue #1: My Subaru never gives the MPG what they promised, on average I get 17 or 18 MPG mixed drive supposed to get 21MPG, whenever I complain to the dealership they give a standard answer about it depends on driving style never attempted to find the root cause. Never had this issue with my previous cars, I used to get the same as what they promised. So I feel not related to driving style. Issue #2: Blue smoke came multiple times, so not consistent reproducing not sure. Issue #3. My battery died many times couple of times had called roadside, later I got a jump starter and I have used it multiple times to start my car, and replaced the new battery under warranty and Subaru paid for it, but unfortunately, the new battery I got had also died and got it replaced by warranty.

Filed Dec 16, 2020 · Electrical · 19,848 miles · TX · fire

The car caught fire while sitting in the driveway (stationary). The car was having electrical/battery issues in the morning. I charged the battery, then started the car and left it running in the driveway, when I came out of the house, the engine of the car was on fire. I called the fire department to put the fire. The fire marshal determined that an electrical issue ignited the engine. After posting the photos of the fire on facebook, we received multiple comments that other people's subaru's have had battery/electrical issues. The insurance company stated that they would have a specialist examine the vehicle to help determine the cause of the fire.

Filed Nov 29, 2019 · Body, Fuel system · 21,300 miles · KS · crash · fire · 1 injury

Traveling on highway at 70 MPH when a deer jumped in front of our car and we hit it with the front end of the vehicle crushing the front end. All air bags immediately deployed and the front end began smoking profusely. Within minutes of getting out of the vehicle it burst into flames and the entire vehicle burned up. Concerned that these vehicles will burst into flames during a front end collision at high speeds.

Filed May 16, 2019 · Electrical, Engine · 9,600 miles · TX

Almost 9500 miles, raining outside wife driving normal speed (highway driving) and eyesight stopped working and check engine light came on. Vehicle still ran. Secondly took to local subrau dealership for 10,000 service they found nothing wrong and did service. Wife left dealership and noticed car pulling to left after tires rotated. Returned to dealership , they said it was normal feathering of tires. Worried eyesight and engine can be affected with rain. Also at a few hundred more miles we now smell burning oil on and off outside of car. We have also experienced high revving motor with no foot on gas pedal.(stationary when smelling burnt oil smell and motor revving. Also once high revving while my 17 year old was city driving. Love to drive the car, hope it holds up!