2017 Toyota Prius: engine stalls while driving

Filed May 19, 2026 · Engine, Fuel system · PA

The catalytic converter heat exchanger failed internally, causing coolant to leak into the exhaust system. Symptoms included white smoke from exhaust and coolant loss with no visible ground leak. This is a documented factory defect per Toyota Technical Service Bulletin T-SB-0135-19 affecting 2016-2019 Prius models. Toyota has denied warranty coverage despite the vehicle was originally bought & spent its entire prior operational life registered in New York, a state covered under Toyota's full 15-year/150,000-mile emissions warranty. Defect was confirmed by an authorized Toyota dealership, in PA. Vehicle had approximately 83,104 miles at time of diagnosis. Manufacturer denied coverage and is forcing the customer (me) to pay a huge amount for this very well known & defective case. MOST IMPORTANTLY ITS dangerous and unsafe for all the cars our there too, since it is very well known that at a certain point this will happen, but despite TOYOTA never sent a RECALL. Due to this, engine light goes on & off, refrigerant is flammable and leaks in the exhaust pipe happens with this specific case, which ultimately could catch on fire, while the vehicle is moving or stalling. Lots of white smoke comes out of the car that directly impact the environmental aspects, and above all, people owning such vehicle, will be running into this issue, which will 100% put the safety of owner and anyone close in proximity to their vehicle at RISK. PLEASE ADD RECALL WITHOUT CAP for ALL SUCH TOYATA PRIUS due to flammable refrigerant leak inside the car engine components, and proven via strong white smoke coming out of exhaust that has the potentially to put the entire car on fire, specifically.

Filed Jul 18, 2025 · Fuel system · AZ

During hot temperatures and after coming to a full stop, the car stalls/hesitates significantly (5-6seconds) when pushing the gas pedal. The car eventually proceeds but the issue reoccurs. It can only be intermittently reproduced and no codes are shown on the car dashboard. Mechanics are unable to identify the source of the issue so it cannot be resolved.

Filed Nov 27, 2024 · Transmission · 68,000 miles · CA

The contact owns a 2017 Toyota Prius. The contact stated while the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed. The accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The contact stated that the vehicle stalled and jerked. The vehicle was driven to the residence. The contact stated that the battery indicator did not look as if the battery was charging. The contact stated that the vehicle was taken to two independent mechanics; however, the failure was not duplicated. In addition, the vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the failure had become persistent. The contact stated that during one failure his wife was driving, and the vehicle lost motive power and stalled. The vehicle failed to restart. The vehicle was towed to an independent mechanic however, the failure was not duplicated. In addition, the contact stated that during one failure, the excessive acceleration warning light illuminated. The contact had not depressed the accelerator pedal during the failure. The manufacturer was made aware of the failure and a case was filed. The contact was informed that no assistance was available. The failure mileage was approximately 68,000.

Filed Jul 3, 2024 · Engine, Fuel system · CA

Dashboard pop up came up saying that the grille shutter is inoperable to visit a dealer. Went online and noticed there were recalls for my Prius year and because emissions is affected I contacted Toyota financial customer service who said to go to a dealer and that they would fix no charge. Went three times to the dealer and they did not want to honor the recall. Charged me $200 to run diagnostics on the vehicle and confirmed that the code that was being recalled matched. They made excuses and in the end did not fix. The pop up appeared March 2024 and since then I now have another pop up appear about the hybrid system overheating due to them not fixing. I went to a local mechanic who said it was the dealers responsibility since there are service bulletins but they do not want to help. The car has stalled out on the freeway almost leaving me to get hit and my fuel has gotten worse.

Filed Feb 4, 2019 · Engine · VA

The involved vehicles were designed to enter a failsafe driving mode in response to certain hybrid system faults. Toyota has found that in rare situations, the vehicle may not enter a failsafe driving mode as intended. If this occurs, the vehicle could lose power and stall. While power steering and braking would remain operational, a vehicle stall while driving at higher speeds could increase the risk of a crash.

Filed Dec 4, 2018 · Acceleration, Steering · 28,000 miles · TN

Car was on 2 lane blacktop in 40 MPH zone driving apx 35 MPH, a female, responsible owner/driver age 79 was driving when suddenly,without any warning,comes to near halt in road and pulls/hard to right hand side of shoulder off the road. Driver had no control over direction or speed before finally able to stop car on top of ditch. Driver was able to get car to stall/stop engine before reaching ditch and possibly a turnover. Driver had never been so fearful in her life,had she been unable to stop car it would have driven her over.reported situation to local toyota dealership and they stated they could not;t find anything wrong with car sending driver back out on road with car, this is very serious situation. Thankful she was on small country ioad and not on busy hwy or this car would have "pulled/lead" her into other traffic, or worse, a sidewalk full of people and or children. She had no control of car for what seemed like a full minute or more