2017 Toyota Prius problems

Filed May 19, 2026 · Engine, Fuel system · PA

The catalytic converter heat exchanger failed internally, causing coolant to leak into the exhaust system. Symptoms included white smoke from exhaust and coolant loss with no visible ground leak. This is a documented factory defect per Toyota Technical Service Bulletin T-SB-0135-19 affecting 2016-2019 Prius models. Toyota has denied warranty coverage despite the vehicle was originally bought & spent its entire prior operational life registered in New York, a state covered under Toyota's full 15-year/150,000-mile emissions warranty. Defect was confirmed by an authorized Toyota dealership, in PA. Vehicle had approximately 83,104 miles at time of diagnosis. Manufacturer denied coverage and is forcing the customer (me) to pay a huge amount for this very well known & defective case. MOST IMPORTANTLY ITS dangerous and unsafe for all the cars our there too, since it is very well known that at a certain point this will happen, but despite TOYOTA never sent a RECALL. Due to this, engine light goes on & off, refrigerant is flammable and leaks in the exhaust pipe happens with this specific case, which ultimately could catch on fire, while the vehicle is moving or stalling. Lots of white smoke comes out of the car that directly impact the environmental aspects, and above all, people owning such vehicle, will be running into this issue, which will 100% put the safety of owner and anyone close in proximity to their vehicle at RISK. PLEASE ADD RECALL WITHOUT CAP for ALL SUCH TOYATA PRIUS due to flammable refrigerant leak inside the car engine components, and proven via strong white smoke coming out of exhaust that has the potentially to put the entire car on fire, specifically.

Filed Dec 19, 2025 · Electrical · 225,810 miles · FL

Odometer Fraud. The contact purchased a 2017 Toyota Prius. It was discovered when the contact listed the vehicle for sale that there was a mileage discrepancy. The vehicle was as a private sale. At the time of the purchase, the mileage was 126,611. The potential purchaser provided a CARFAX report that recorded the mileage on 11/6/2024 at 225,810.

Filed Jul 18, 2025 · Fuel system · AZ

During hot temperatures and after coming to a full stop, the car stalls/hesitates significantly (5-6seconds) when pushing the gas pedal. The car eventually proceeds but the issue reoccurs. It can only be intermittently reproduced and no codes are shown on the car dashboard. Mechanics are unable to identify the source of the issue so it cannot be resolved.

Filed Jul 18, 2025 · Body · CA · crash

Standing at a red light and someone rear ended

Filed Feb 27, 2025 · Engine · 81,700 miles · IL

The contact owns a 2017 Toyota Prius. The contact stated that while driving approximately 25-30 MPH, the vents were blowing out cold air. The check engine warning light was illuminated. The contact was adding coolant to the coolant reservoir every three to four days. The vehicle was taken to the local dealer, where it was diagnosed and determined that the coolant was leaking into the exhaust pipe. The dealer recommended that the exhaust system front pipe be replaced. The manufacturer was contacted, opened a case, and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 81,700.

Filed Nov 27, 2024 · Transmission · 68,000 miles · CA

The contact owns a 2017 Toyota Prius. The contact stated while the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed. The accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The contact stated that the vehicle stalled and jerked. The vehicle was driven to the residence. The contact stated that the battery indicator did not look as if the battery was charging. The contact stated that the vehicle was taken to two independent mechanics; however, the failure was not duplicated. In addition, the vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the failure had become persistent. The contact stated that during one failure his wife was driving, and the vehicle lost motive power and stalled. The vehicle failed to restart. The vehicle was towed to an independent mechanic however, the failure was not duplicated. In addition, the contact stated that during one failure, the excessive acceleration warning light illuminated. The contact had not depressed the accelerator pedal during the failure. The manufacturer was made aware of the failure and a case was filed. The contact was informed that no assistance was available. The failure mileage was approximately 68,000.

Filed Nov 21, 2024 · Engine, Fuel system · CA

I am seeking assistance and compensation for ongoing warranty and repair issues with my Toyota Prius. Key Incident Timeline: •March 21, 2024: Dashboard message “Grille Shutter Inoperable” •March 25, 2024: Toyota of Glendale visit •Charged $220 for diagnostics •Refused to honor service bulletin •Vehicle mileage: 149,217 Customer Service Interactions: •April 9, 2024: •Contacted Toyota customer service •Confirmed CA emissions coverage to 150,000 miles •Discovered extended warranty unexpectedly canceled Brand Engagement Claim: •April 9, 2024: Filed claim with Toyota’s Brand Engagement line •June 26, 2024: Claim denied, dealership’s decision upheld Repair Challenges: •July 5, 2024: Wondries Toyota diagnostic visit •Charged $200 for diagnostics •Confirmed active service bulletins would have covered repairs Repair Management: •Northeast Mechanic has handled all subsequent repairs due to Toyota’s failures Financial Losses Breakdown: •Initial diagnostic fee (Toyota of Glendale): $220.00 •Diagnostic fee (Wondries Toyota): $200.00 •Car rental (July 6, 2024 - Hertz): $1,356.17 •Car parts: $1,706.55 •Labor on vehicle: $754.22 •Water pump: $167.78 •Head Gasket, Spark Plugs, Engine Water Pump: $2,161.00 •Total financial loss: $6,565.72 I request a comprehensive investigation into these warranty and repair issues, seeking full compensation for the financial burden caused by Toyota’s repeated failures. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 30, 2024 · MO

While driving the speed limit of 70mph on a major highway, the sunroof on my 2017 Toyota Prius exploded. There was no warning of any kind: no other traffic nearby so no rock or debris from another vehicle; no overpass or bridge so nothing from above; it was a mild sunny day of 76 degrees so not a weather factor; and by the angle of the glass that remains being in an outward position rather than inward, reveals to me that it was from inside out, not from outside in as if it were a rock hitting. It just exploded. I was the only person in the car. Thankfully, the visor was shut on it or the shattered glass would have caused injury and of greater serious concern is just the sudden sound of what sounded like a bomb going off over my head was enough to cause a reaction which easily would result in an accident. It was a terrifying experience! I was lucky no other vehicles were nearby and could react and safely get off the road. I called 911 immediately and reported it. I have read many such claims from other Toyota owners online (see ToyotaNation.com and search by "exploding Sunroof") and even from a technician at my nearby Toyota Collision Center that it just happened to a friend of theirs also. This is not a one time issue. When I took the car to the Collision Center for an estimate and inquired about the damage, they could find no recall on it by Toyota. This is certainly a dangerous and hazardous issue that needs to be addressed asap before someone is seriously hurt or there is a fatality.

Filed Jul 22, 2024 · Engine · CO

Coolant leaking into exhaust And engine also vehicle suddenly stops for no reason now engine is completely broken due to the coolant going into the motor oil

Filed Jul 3, 2024 · Engine, Fuel system · CA

Dashboard pop up came up saying that the grille shutter is inoperable to visit a dealer. Went online and noticed there were recalls for my Prius year and because emissions is affected I contacted Toyota financial customer service who said to go to a dealer and that they would fix no charge. Went three times to the dealer and they did not want to honor the recall. Charged me $200 to run diagnostics on the vehicle and confirmed that the code that was being recalled matched. They made excuses and in the end did not fix. The pop up appeared March 2024 and since then I now have another pop up appear about the hybrid system overheating due to them not fixing. I went to a local mechanic who said it was the dealers responsibility since there are service bulletins but they do not want to help. The car has stalled out on the freeway almost leaving me to get hit and my fuel has gotten worse.