2019 Toyota RAV4 body problems

Filed Oct 23, 2026 · Body · 130,000 miles · FL

The contact owns a 2019 Toyota Rav4. The contact stated that while the vehicle was parked, the contact stated that while attempting to open the driver's and rear passenger's side doors from outside the vehicle, the exterior door handles fractured. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured rear exterior driver's door handle and rear exterior passenger's door handle. The contact was informed that the exterior door handles needed to be replaced. The dealer was contacted and made aware of the failure. The contact was advised to contact the federal safety agency Hotline to report the failure. The manufacturer was contacted, and a case was filed. The failure mileage was approximately 130,000.

Filed May 13, 2026 · Body · NY

The rear door (lift gate) hinges are failing and tearing away from the vehicle body, causing misalignment of the rear door, operational failure of the automated lift gate, and water leaking into the interior. This has occurred under normal use conditions. It appears that the hinge design is insufficient to handle the load and forces of normal operation of the door. The failure has been documented in pictures. The Toyota dealership where the vehicle was purchased stated that the vehicle is out of warranty and there is no recall for the hinges, therefore the owner is responsible for repair costs. Had the issue not been found and the hinges failed completely, it could have been extremely hazardous.

Filed May 6, 2026 · Body, Electrical · NY

The rear hatch hinges are undersized causing them to fail and undue stress on the motor.

Filed Apr 8, 2026 · Body · MD

Tailgate problem since Purchase. Tailgate won't close. Gets stuck open. Dangerous. Known issue. Fixed 3 times at Toyota dealer. Faulty hinge and other real parts problems. Dealer says there is a class action lawsuit about the problem. 1st occurred only during Winters starting 2022. Gas door broken 2023. Water leaking into passenger front door 2022. Also door actuator . Have had to replace front 2, now rear broken. Can report separately.

Filed Apr 6, 2026 · Body · MN

While driving, the moonroof on my 2019 Toyota RAV4 XLE AWD suddenly exploded with a loud bang and the glass blew outward. There was no impact, debris, or external cause. The sound was similar to a gunshot. The remaining glass appeared to be pushed upward/outward, not inward. This created a safety hazard due to potential driver distraction and risk of injury from falling glass. This appears consistent with other reported incidents involving spontaneous sunroof shattering. No warning light. Moonroof was shut.Sunny day about 40 degrees outside. Traveling at 68 mph. Dog in crate in back

Filed Mar 24, 2026 · Body · SC

I have a 2019 Toyota Rav4 and my liftgate hinges are breaking . The welds are breaking and its causing my truck to no close all the way. Also is truck itself had misaligning itself to the driver side and its also breaking my tail light from the truck hitting it. This is a known problem with this model of car. Toyota has refuse to fix this problem. Leaving people to pay for this repair out of their pocket. The price i have quote for is $2,288.27 that's alot of money. This problem needs to be fix without us coming out of our pocket to fix something that Toyota has known about for some time now. I have been back and forward with my local deal ship snice 3/20/2026. Today i s 3/24/2026 and nothing has changed. I have called Toyota corporate to see if i can some help with is repair. All they keep saying is my car" doesn't meet the reequipments. There should be a recall cause this isnt one two RAV4s its hundreds maybe even tens of thousands.

Filed Mar 18, 2026 · Body · FL

I have noticed visible rust forming on the roof, specifically the front drivers side adjacent to the inside edge of the roof rail that runs forward to aft on the vehicle. The same stated rust spot is near where the roof meets the windshield. It is available for inspection upon request. My 2019 Toyota Rav4 along with several other 5th generation Rav4 owners online are experiencing rust in the same exact spot. This rust may be a result of the Toyota Customer Service Program (CSP) #22TE05 and T-SB-0016-23 that came of a result of the Fishkind v. Toyota Motor Sales, USA et al. No. Case 2:23-cv-02279 Class Action Lawsuit. This rust may have been formed by the leaking roof rail gaskets that have a slow enough leak rate to penetrate the roof rail clip holes and create moisture and rust over an extended period of time but not high enough of a leak rate to cause excess leakage into the vehicle that would immediately alarm the driver to have the vehicle taken into the dealership for immediate repair before the corrosion and rust can have a chance to spread. After several conversations with Toyota Corporate and my Toyota dealership they have denied me CSP inspection and any coverage or good will assistance through the CSP# 22TE05 & T-SB-0016-23 despite evidence of water residue buildup on the headliner visible through a UV blacklight. Even if the rust is not caused from the roof rail gasket leakage, there are still multiple other instances online of other 5th gen rav4 owners experiencing roof rust in the same exact spot adjacent to the drivers side roof rail near the windshield, which points to a manufacturing defect. My safety will be put at risk when the corrosion worsens and leaks through into the electrical components of the vehicle. My dealership witnessed the rust but denied performing an inspection of the roof rail clips since there is currently visible rust, likely due to the roof rail clips leakage. No manufacturer inspection. No noticeable warning symptoms.

Filed Mar 15, 2026 · Body, Seats · FL

A recall was issued for a roof leak defect that allowed water intrusion into my vehicle. The recall repair was performed at Autonation Toyota of Weston dealership, where the roof was replaced due to water staining. However, water intrusion which led to black mold growth into the interior carpeting and floor board remained after the repair. The dealership stated that the remaining water intrusion affecting the carpeting was caused by another source. Documentation showing that the recall repair procedure was completed according to the manufacturer’s requirements was requested but has not been provided. The defect involving water entering the vehicle interior remains unresolved. I was last told by the General Manager that my requests and concerns were forwarded to legal, but I have not heard back from October of 2025.

Filed Mar 7, 2026 · Body · SC

The rear liftgate began malfunctioning and would intermittently fail to open or close properly. The issue had previously been reported to a Toyota dealership, but the problem could not be reproduced at the time. I noticed recently that the liftgate was not fully closing on the passenger side. While inspecting the liftgate more closely, I discovered that the passenger side liftgate hinge is cracked and the metal at the hinge base is separating. The crack appears to run through the hinge bracket where it attaches to the body. The driver side hinge also shows signs of stress. Because the hinge is cracked and separating, there is concern that the liftgate could eventually detach or fall unexpectedly. The liftgate is heavy, and a hinge failure could allow it to drop suddenly, posing a risk of injury to someone standing near or underneath it. If both hinges fail at the same time, the liftgate could become detached from the vehicle while driving resulting in an accident and potential injury to myself, my family, and others that are hit by or hit the liftgate. The dealership suggested the damage may have occurred from forcing the liftgate closed when the liftgate struts failed to function. However, the cracking appears consistent with progressive metal fatigue rather than a single impact event. This appears to be a structural hinge failure that could affect the safe operation of the liftgate. The dealership has documented my concerns on numerous occasions and today they visually saw the hinges in their current shape.

Filed Feb 11, 2026 · Body · NC

The hinge has broken from the body, causing the liftgate to fail to close the back trunk area of the vehicle. The defective hinge has caused misalignment of the door and an unsecure compartment which is a violation of NC State Law according to NC GS 20-116. This puts the passenger's and driver of the vehicle and other surrounding vehicles at risk by failing to stay aligned or seal properly. I fear that glass may crack due to the currently misalignment. I have sought out further information from a Vehicle Repair Center, who confirmed there is a current Lawsuit on the Case No.: 5:24-cv-00912ZACH HUGHES, individually and on behalf of all others similarly situated, Plaintiffs, v. TOYOTA MOTOR SALES, U.S.A., INC., TOYOTA MOTOR CORPORATION, and TOYOTA MOTOR.