2019 Toyota RAV4 engine problems

Filed Nov 3, 2026 · Engine · PA

My transmission failed, torque converter. My check engine light came on with "AWD malfunction" on the dash on 10/21/26. I had to get it towed to the closest dealership. I was told it is covered under warranty to replace and repair, the following Tuesday 10/27/2 I havd to call and ask what was going on. They then informed me the part is on back order until end of December (they do not have a date) 2026- Leaving me with no vehicle for 2 months, Krause Toyota will not let me drive the car (not state legal with a faulty transmission) and only gave me a rental for 5 days. I am now forced to pay out of pocket for however long they will have my Rav4. I have called the Brand Engagement department and they have not been very helpful. The guys in the service department at Krause are extremely rude and bothered by the fact that I had questions. I did ask about the lawsuit regarding my 2019 Rav4 faulty transmissions and they said they didn't know anything about it. Any help regarding this very frustrating matter would be helpful.

Filed Oct 20, 2026 · Electrical, Engine · MD

Code P26CB likely a premature error on water pump causing overheating

Filed Sep 28, 2026 · Engine · TX

I am reporting a potentially recurring safety-related failure of the electric engine coolant/water pump on my 2019 Toyota RAV4 equipped with the 2.5L A25A-FKS engine. My vehicle recently developed DTC P26CB/P26CB71, indicating an electric engine coolant pump performance/speed problem. The failure caused loss of proper coolant circulation and resulted in my vehicle overheating while I was driving on the highway. An unexpected cooling-system failure at highway speed creates a safety hazard and can result in severe engine overheating, potentially catastrophic engine damage, and an unexpected need to stop near traffic. Approximately two months before this failure, my vehicle received a separate cooling-system repair from an authorized Toyota dealer under Customer Support Program 24TE04, which covers the flow shut-off valve/water-bypass assembly on certain 2019–2021 RAV4 vehicles. Approximately two months later, the vehicle developed the P26CB coolant-pump fault. Toyota previously documented electric water-pump problems involving P26CB71 on A25A-equipped vehicles. In Tech Tip T-TT-0614-20, dated May 28, 2020, Toyota identified P26CB71, P26CA14, and P26CA31 and/or coolant leakage from the electric water pump on A25A applications, including the RAV4. Toyota stated the issue was "currently under investigation." Toyota subsequently confirmed to me that the P26CB water-pump issue is separate from the 24TE04 repair and that there is currently no Customer Support Program or warranty extension covering the physical electric coolant pump on my 2019 RAV4. I request that the federal safety agency review complaint, warranty, repair, and manufacturer data to determine whether premature electric coolant-pump failures involving P26CB/P26CB71 represent a broader safety-related defect trend, particularly in 2019–2021 RAV4 vehicles equipped with the A25A engine, and whether further investigation or corrective action is warranted.

Filed Sep 15, 2026 · Engine · FL

Component: Engine — Engine Cooling System — Coolant Pump Summary: The electric water pump on my 2019 Toyota RAV4 failed prematurely at 64273 miles. The check engine light illuminated with diagnostic trouble code P26CB (Engine Coolant Pump Performance/Stuck Off). The engine coolant temperature fluctuated rapidly / coolant level dropped. The vehicle required immediate repair to avoid engine damage. This is a recurring failure pattern on 2019–2021 Toyota RAV4 and Camry vehicles equipped with the 2.5L A25A-FKS engine, where the electric water pump seizes due to an apparent defect in its plastic housing and rotor assembly. Failures are routinely reported at 30,000–60,000 miles—far below the expected service life of the component. Loss of coolant circulation creates an overheating hazard and can lead to sudden loss of propulsion and engine damage while driving. Toyota has issued technical service bulletins related to coolant seepage at the pump but has not recalled the component or extended warranty coverage, leaving owners to bear repair costs of $600–$1,300 for a premature defect-driven failure. I request the federal safety agency to evaluate this defect for a safety recall.

Filed Sep 9, 2026 · Electrical, Engine · MN

As soon as my vehicle hit 100K mileages and there's "AWD System malfunction" sign showed up on dash. Got it done replaced it cost roughly more than $500. After 2 days later another problem shows up on dash this time it was "engine maintenance required" show on dash again. Heard people had the same issue to whoever own 2019 RAV4 and they all had the same for those 2 issues. Toyota company should pay attention for these kind of problems or like some of of recall.

Filed May 18, 2026 · Engine · FL

The Coolant Bypass Valve on my vehicle failed, leading to a risk of sudden engine overheating and potential coolant leaks into the electrical harness. This is a documented defect (CSP 23TE03) that Toyota has failed to address for vehicles over 100,000 miles, creating a safety hazard for high-mileage owners. This is a major concern on a known issue and those that don't have funds to pay for this known failure. They need to do a recall for ALL!

Filed May 16, 2026 · Engine, Transmission · MA

The 8-speed automatic on my 2019 RAV4 (2.5L 4 Cyl) has been shifting super rough at lower speeds, to the point to where downshifts can send the revs into redline territory, but the car really doesn't move. No warning lights, passed state inspection, recently serviced. purchaced this car in Janurary with 50k miles on it and noticed it within a few weeks of driving. I am now at 57k and the issue is signifigantly worse than it was before. Will be taking it to Toyota soon. The safety issues arise when I do not know how the car is going to accelerate or respond to throttle input in traffic. I don't trust the car to handle any fast throttle input if I need to move out of the way quickly.

Filed Mar 26, 2026 · Engine · 116,000 miles · NC

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the message "Engine Maintenance Required - Visit the Dealer" was displayed on the screen. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the coolant flow control valve needed to be replaced. The vehicle was repaired out-of-pocket. Upon further investigation, the contact related the failure to Customer Support Program: 24TE04. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 116,000.

Filed Feb 4, 2026 · Engine · WA

I was driving down a road and my engine just stopped working lights came on saying there were several issues including the engine. I researched online and found there were recalls due to this same problem for the same make, model and year as my Vehicle, but there is no recall on my vehicle. The dealer confirmed the engine was seized up or whatever wording they used. No one has inspected it other than Rodland Toyota. There were no warning lights or messages or symptoms before the issue.

Filed Jan 1, 2026 · Engine, Fuel system · TN

This is another complaint with the same issue. Got gas on January 1, 2026, the truck did not how any indication that it was going to have any problems. Engine shut down and wouldn’t turn back on. This has happened twice after getting gas, no dealership knows the problem. This is casing me stress and putting myself and family in danger. Considering it stops out of no where