2019 Toyota RAV4 seats problems

Filed Mar 15, 2026 · Body, Seats · FL

A recall was issued for a roof leak defect that allowed water intrusion into my vehicle. The recall repair was performed at Autonation Toyota of Weston dealership, where the roof was replaced due to water staining. However, water intrusion which led to black mold growth into the interior carpeting and floor board remained after the repair. The dealership stated that the remaining water intrusion affecting the carpeting was caused by another source. Documentation showing that the recall repair procedure was completed according to the manufacturer’s requirements was requested but has not been provided. The defect involving water entering the vehicle interior remains unresolved. I was last told by the General Manager that my requests and concerns were forwarded to legal, but I have not heard back from October of 2025.

Filed Dec 22, 2025 · Seats · OR

I am reporting a concern regarding the driver’s seat design in my Toyota RAV4. While driving this vehicle, I experience consistent back pain that can begin within approximately 15 minutes of driving and often persists for about two hours after driving has ended. The pain includes sharp discomfort in my mid-to-upper back and occurs despite adjusting the seat position and using aftermarket lumbar and seat supports. I do not experience similar pain when driving other vehicles for comparable durations, including a Toyota Highlander, Toyota Camry, Subaru Impreza, Ford Focus, Rivian truck, or a pickup truck. This strongly suggests the issue is related to the RAV4’s seat ergonomics rather than a preexisting condition. Because of this issue, I have begun avoiding driving my own vehicle when possible. I am submitting this report to document a potential seat design issue that may affect driver comfort and safety.

Filed Mar 23, 2025 · Airbags, Seat belts · UT

After driving for 5-10 minutes, the center console screen stated: “A malfunction in the SRS Airbag System has been detected. Contact your dealer in order to have your vehicle inspected immediately” This continues to happen on subsequent trips. It only happens when somebody is actually sitting in the front passenger seat. There were no warning signs or symptoms prior to this message appearing. It makes me very concerned about passenger and driver safety and that the airbags may not deploy when needed.

Filed Mar 7, 2025 · Seats · CO

The seat warmer/heater burned a hole through my driver's side seat and my coat. Luckily, I was not injured but I have severe concerns about this problem also occurring in the passenger seat where my children sit. This problem causes me worry about my own safety and that of my children. I am disappointed to be unable to use a feature that I specifically purchased this vehicle to use and enjoy. I currently have my vehicle at a Toyota dealership for diagnosis and evaluation.

Filed Mar 3, 2025 · Airbags, Electrical · CA

I have been experiencing water intrusion with my vehicle, I first noticed it by a mildew smell. Acknowledged under Toyota’s Customer Support Program 22TE05. This water leak has led to multiple secondary issues, including: Interior water damage Clogged A/C drainage system Sunroof drainage issues I reported this issue to a Toyota, but they denied repairs under 22TE05, claiming the issue was only due to a sunroof leak and clogged drains. [2/14] – Took my car to AutoNation Toyota due to a persistent water leak. The dealership diagnosed the issue as a clogged sunroof leak and clogged drains but did not provide clear documentation that they properly inspected the roof rail gasket. [2/18] – Dealership denied repair under 22TE05 but then stated they could replace the roof rail gaskets if my insurance paid for it—which contradicts their claim. [2/18] – I escalated my case to Toyota Corporate for review, but I am still waiting for a response. My car was left outside in the rain, potentially worsening the water damage. The dealership never provided me with a written repair estimate. Safety Concerns & Impact on Vehicle Use: I am worried about driving my car due to potential electrical system failure and airbag malfunctions caused by water damage. According to industry knowledge and Toyota customer experiences, a roof rail leak can directly contribute to all of the issues the dealership claims my car has: Clogged A/C Drainage System – Water leaking from the roof rails can enter the A/C system, causing drainage backup, mold, and excessive moisture buildup. Sunroof Leaks & Drainage Problems – If excess water enters through roof rail failure, it can overwhelm the sunroof drainage system, making it appear clogged when the root cause is actually the failing roof seal. Interior Water Damage – If the roof rail clips fail, water leaks into the headliner, side pillars, dashboard, and footwells, leading to electrical issues, carpet damage, and excessive moisture inside

Filed Jul 24, 2023 · Seats · 35,000 miles · FL

The contact owns a 2019 Toyota Rav4. The contact stated that while driving at an undisclosed speed and attempting to adjust the front driver's side seat when the seat adjuster failed to operate as needed. The vehicle was taken to the dealer where it was diagnosed that the seat track assembly needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 35,000.

Filed Feb 11, 2023 · Airbags, Electrical · TN

Car randomly switches into different driving modes, BSM and anti collision goes off while driving. Seat warmers randomly come on high and can’t be turned off. Dealership identified water damage from leaking roof rack resulting in mold and electrical damage. Possible damage to airbags as water leaking into the pillar at front window. Many instances documented online.

Filed Aug 3, 2022 · Seats · FL

hi, the driver lower seat frame being detached, the right slide is seized /stuck on the rail track and inoperable causing risk for unsafe driving equipment. I have a child and cannot drive with a broken seat - I don't reach it is a liability for safety! thanks, very respectfully [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Filed Sep 16, 2021 · Seats · 39,000 miles · LA

The contact owns a 2019 Toyota Rav4. The contact stated that while picking up her husband, upon sitting on the front passenger’s seat, he noticed that the seat was extremely hot. The contact stated that the heated seat feature was in the off position. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer and the vehicle was being diagnosed while filing the complaint. The vehicle was not yet diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 39,000.

Filed Jun 25, 2021 · Electrical, Seats · NV

Seat heater turns on automatically and randomly and gets way too hot. I'm afraid it might burn me. I have an appointment with the Toyota dealership however it's my only mode of transportation and I work 3 hours away from home. This puts me at high risk of getting hurt. None of the lights or any indicators came on. There has been no indication that there might be an issue before today. Today is 6-25-2021.