2020 Toyota RAV4: water leaks into the cabin

Filed Jun 9, 2026 · Body · 60,000 miles · MD

The contact owns a 2020 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the contact noticed that there was an unusual sound coming from the rear of the vehicle. The contact parked and inspected the vehicle. The contact stated that upon opening the rear passenger's side door, the contact noticed water leaking from the bottom of the door panel onto the ground. The contact stated about a gallon of water leaked from the rear passenger's side door panel. The vehicle was taken to the dealer, where the contact was informed that the repair was not covered under a recall. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to take the vehicle to the dealer for inspection. The failure mileage was approximately 60,000.

Filed Feb 6, 2026 · Suspension, Visibility · 149,782 miles · NH

The contact owns a 2020 Toyota Rav4. The contact stated that while driving or while the vehicle was parked, there was water leaking from the sunroof. While driving at an undisclosed speed, there was a loud clunking sound coming from the front of the vehicle. The vehicle was taken to the dealer, where it was diagnosed and determined that front alignment was needed, and that the roof rails needed to be repaired or replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 149,782.

Filed Aug 7, 2024 · Body · 111,000 miles · FL

The contact's son owns a 2020 Toyota RAV4. The contact stated that when it rained, rainwater entered the vehicle onto the passenger’s side front door panel. The contact stated that the sound of the water slushing around in the front passenger's door panel was very distracting. The vehicle was taken to the dealer where it was diagnosed with a failed door trim. The contact was informed that the front passenger’s side door trim needed to be cut and drained. The contact stated that there was more than a gallon of water released from the front passenger's side door panel drain. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 111,000. The VIN was not available.

Filed Feb 14, 2024 · Acceleration, Fuel system · FL

Vehicle was taken in for a oil change. At check-in I was told that I would be given a rental vehicle due to the overhead rails recall, leaking inside the vehicles at that time I advised of a gas smell which I have been smelling for several years and it was getting stronger. I was told that there was something wrong with the fuel pump and it would need to be replaced and they would also be replacing rails from the top of my vehicle because there was water leaks inside my car, I advised that water has been leaking in my car for several years and clips were already placedbout two years ago. Several days later I received a phone call that my vehicle was ready to pick up when I got there i was informed that the fuel pump assembly was replaced and intake. Manifest gasket , throttle gasket , fuel pump gasket replaced EGR valve replaced EGR inlet gasket replaced EGR valve. ad gasket replaced EGR cooler gasket replaced. I was also told that my air filters would need to be changed and I did consent to my air filters, the air element and a brake system flush as recommended after picking up my vehicle which had 34033 miles on it on 1/24/24. On 2/10 I was driving and a warning flashed on my car and spoke to me it said that there was a malfunction detected in the engine, transmission or throttle of the vehicle and I need to contact Toyota. I was two miles away and drove directly to them. They took the vehicle for several hours. I was told it was the alternator because my lights have been going dim and very bright. I advised that I have issues with the windows closing since the most recent repair as well and the vehicle is losing power. After almost 4 hours I was informed it a thermostat. Everyone had gone home and they could not give me a give me a rental so I had to drive this vehicle until Monday afternoon. The thermostat and gasket were replaced and I was charged because they used insurance without telling me. I believe this is a malfunction in their system related to origina

Filed Aug 20, 2023 · Airbags, Body · AZ

There is a recall for the roof rails leaking water which can damage the air bags and electrical components. They will not fix the roof with new gaskets unless you actually see the water coming in. My concern is that it is leaking and I'm just not seeing it because the 110 degree weather. I do not want to be in an accident with my wife and kids in the car and have the air bags not work. They should fix the gaskets before it leaks and leads to further potential damage or even life threatening results(air bags being wet and not deploying). They will not fix my roof until it actually starts leaking even tho there is a recall in place. This is ridiculous.

Filed Mar 2, 2022 · Airbags, Body · CA

During a road trip with my wife I discovered that the headliner started leaking down the A-frame and into the curtain airbags on the A-pillar on the driver and passenger side of the vehicle. Within 2 minutes of googling the issue I found out that 2019-2020 RAV4s with the factory installed roof rails experience a leak caused by a faulty gasket. This information was confirmed by my service advisor at Toyota of El Cajon after he stated "Yeah you've got the RAV4 leak, I'm finishing up a warranty claim on one right now". I expressed concerns over electrical damage, damage to the air bags, and possible mold growth in the vehicle and was told that Toyota doesn't consider water leaking into an airbag/control panel to be an issue. I would really like the federal safety agency to inform Toyota that water leaking into safety equipment through the roof of a new $50,000 car is indeed a safety issue and just awful quality assurance.

Filed Apr 29, 2021 · Body · 8,100 miles · LA

Tl* the contact owns a 2020 toyota rav4. The contact stated that while driving in inclement weather, water leaked inside the vehicle from the roof rack into the interior cabin and a by the a-pillar. The contact was concerned that the water could corrode the air bags causing them to not deploy in the event of a crash. There was no warning light illuminated. The vehicle was taken to ray brandt toyota (2460 veterans blvd, kenner, la 70062) where it was diagnosed with the roof rack seals needing to be replaced. The vehicle was not yet repaired. The manufacturer was informed of the failure and referred the contact to an authorized dealer. The failure mileage was approximately 8,100.