2020 Toyota RAV4: sudden loss of power

Filed Sep 14, 2026 · Fuel system · AZ

While driving on the highway, the vehicle suffered a sudden loss of engine power and went into a low-power/vapor lock state due to severe fuel starvation. This created a major safety hazard by stranding the vehicle on the highway shoulder and exposing occupants to high-speed traffic. Prior to the power loss, there were no advance warning lights until the engine stalled. A diagnostic scan performed immediately following the incident confirmed code P0087 (Fuel Rail/System Pressure - Too Low), along with cylinder misfire codes P030027 and P030100. To allow the vehicle to safely limp home from a remote location, an independent technician cleared the diagnostic trouble codes. An independent scan tool report clearly documented and confirmed the low fuel pressure fault prior to code clearance. The dealership subsequently declined to perform a warranty or recall fuel pump replacement citing the absence of active codes upon arrival, despite receiving the timestamped diagnostic report of the failure. The component has not been inspected by the manufacturer beyond the dealership's initial turn-away, but the vehicle and diagnostic documentation remain available for inspection upon request.

Filed Aug 18, 2026 · Transmission · PA

**VEHICLE:** 2020 Toyota RAV4 LE **VIN:** [XXX] **CURRENT MILEAGE:** 126,776 miles **PURCHASE DATE:** October 2020 **COMPONENT:** Automatic Transmission (Power Train) **PROBLEM DESCRIPTION:** On XXX, I took my 2020 Toyota RAV4 LE to a transmission specialty shop (TJ'S Transmission Service Inc., Bedford, PA) because the automatic transmission was slipping while driving. The professional diagnosis (Invoice #XXX) confirmed the following stored fault codes: P2681, P2816, P08BA, P2713 The technician also confirmed that the transmission fluid was black and contained metal debris, indicating significant internal wear of clutch/band components. While researching these codes, I found that Toyota previously issued Technical Service Bulletin (TSB) T-SB-0160-18, titled "Transaxle Whine Noise, Harsh Shift, MIL ON, or Reduced Power," which acknowledges these SAME fault codes (P2816, P08BA, P2713, among others) as a known problem in the 8-speed automatic transmission (UA80/UB80 family, manufactured by Aisin). This TSB was officially issued only for the 2017-2018 Highlander and Sienna models, but the 2019 and later RAV4 uses the same transmission family (UB80E/UB80F) for the 2.5L engine, suggesting this is the same design or manufacturing defect that has not been officially acknowledged for this model. This issue represents a safety risk, as unexpected loss of power or transmission slippage while driving (for example, when merging onto a highway or passing) can create a dangerous situation for the driver and other vehicles on the road. I am requesting that the federal safety agency investigate whether a similar failure pattern exists in other 2019-2021 RAV4 vehicles equipped with this transmission, and that consideration be given to whether Toyota should extend coverage of TSB T-SB-0160-18 (or issue a specific one) to include the RAV4. No repair was performed at this time due to the high estimated cost without warranty coverage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 25, 2026 · Electrical, Steering · FL

When trying to start my vehicle this morning, the car was having a noticeable issue the minute I turned on the vehicle. It was making some weird noises under the hood, and it was starting to lose power. Then the engine would cut out and a warning would appear on my dash that read, "Engine Stopped, Steering Power Low" Thank God this happened while I was at home. What if this had happened while I was driving down the road, at a red light. I would have been a sitting duck in the middle of the road and would not want to put my kids or I in jeopardy of being hit.

Filed Jun 8, 2025 · Engine, Transmission · FL

My vehicle Toyota RAV4 Hybrid 2020 began lost power and jerk on highway driving and then following messages appeared: Hybrid System Malfunction, A malfunction in electronic control of engine, throttle or automatic transmission has been detected and check engine light. This happened in September 2024. Toyota dealership replaced the low fuel pressure sensor A after my complaint and vehicle diagnostic, but it did not help. I recently had the same problem while driving on the highway for a long distance.

Filed Dec 20, 2024 · Acceleration, Electrical · MI

Wire harness failure according to the Toyota dealership representative I spoke with after inspection on 12/18/24. Rep said this is a known issue with certain years and they will cover cost of replacement. Previously, I had received a message stating, "Hybrid System Malfunction, Visit your Dealer" but could not get an appointment until 12/18. The dealer rep said they needed to order parts to fix the wire harness issue and that I would be okay taking the car and bringing it back when parts were in. The day after the inspection (12/19) I was in a Walmart parking lot and my car started but I could not get it to drive or reverse. A message stated "Vehicle not ready to drive" and "No power to rear brakes". If I put the car into drive or reverse and stepped on the gas, the car interior lit up and the dinging sound (usually associated with unbuckled safety belt) was heard. I had my safety belt fastened. My car could be put into neutral and had to be towed to the dealership. After looking into the issue, I found out that the car could had died while I was driving it resulting in loss of power brakes, etc. I live in a more rural area and could have been stuck with out cell reception, etc. This should be a RECALL and they never should have let me leave the dealership in my car. Note: As of today (12/20) the dealer rep stated they will cover all towing costs and cover a loaner vehicle for me. My dealership is very helpful BUT this could be a serious issue for someone else. Google "Rav 4 Cablegate" for more information.

Filed Jul 27, 2024 · Steering · TX

While I was driving the power steering light came on and lost power. A message came on the vehicle history alert. After driving slowly for 2 miles it when away and got power back on the steering

Filed Feb 14, 2024 · Acceleration, Fuel system · FL

Vehicle was taken in for a oil change. At check-in I was told that I would be given a rental vehicle due to the overhead rails recall, leaking inside the vehicles at that time I advised of a gas smell which I have been smelling for several years and it was getting stronger. I was told that there was something wrong with the fuel pump and it would need to be replaced and they would also be replacing rails from the top of my vehicle because there was water leaks inside my car, I advised that water has been leaking in my car for several years and clips were already placedbout two years ago. Several days later I received a phone call that my vehicle was ready to pick up when I got there i was informed that the fuel pump assembly was replaced and intake. Manifest gasket , throttle gasket , fuel pump gasket replaced EGR valve replaced EGR inlet gasket replaced EGR valve. ad gasket replaced EGR cooler gasket replaced. I was also told that my air filters would need to be changed and I did consent to my air filters, the air element and a brake system flush as recommended after picking up my vehicle which had 34033 miles on it on 1/24/24. On 2/10 I was driving and a warning flashed on my car and spoke to me it said that there was a malfunction detected in the engine, transmission or throttle of the vehicle and I need to contact Toyota. I was two miles away and drove directly to them. They took the vehicle for several hours. I was told it was the alternator because my lights have been going dim and very bright. I advised that I have issues with the windows closing since the most recent repair as well and the vehicle is losing power. After almost 4 hours I was informed it a thermostat. Everyone had gone home and they could not give me a give me a rental so I had to drive this vehicle until Monday afternoon. The thermostat and gasket were replaced and I was charged because they used insurance without telling me. I believe this is a malfunction in their system related to origina

Filed Sep 16, 2022 · Engine · TX

I was driving down the hwy doing 75mph, herd a loud bang and vehical lost all power, was passing an exit right at the moment this happened and immediately pulled out and was able to coast to a stop. The exhaust smoked for a while and it left a huge puddle of what looked like motor oil where it stoped and never started back up again. Ended up having to have it towed to a dealership where im told it threw a rod and being as how there is already a recall on this engine for possible cracks im thinking this model probably need to be added to the recall list. The car has been sitting at the dealership where the tow truck left it. There is a recall involving the possibility that cracks could form in the engine, leading to coolant or oil leaks and stalling, overheating, or engine fires. If I hadnt had both my hands on the wheel I could have lost control and killed myself or worst off if there had been cars around me I could have caused a fatal accident. In this case the problem cant be reproduced as the engine is ruined but would be happy to offer to have it inspected. I have kept up with all the manufacturers maintenance request and there were no signs of a problem prior.

Filed Sep 2, 2022 · Steering · 43,000 miles · TX

The contact owns a 2020 Toyota Rav4. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The dealer was made aware of the failure; however, the vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure. The contact related the failure to the federal safety agency Campaign Number: 20V373000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 43,000.