2014 Western Star 5700 technical service bulletins
405 technical service bulletins and manufacturer communications cover the 2014 Western Star 5700.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Important Campaign Information letter for DDC D23M3
- Updated Western Star Service Bulletin for HVAC Actuator Replacement
- Important Campaign Information Letter for DDC D21M1 Termination Date Extended
- Western Star Service Bulletin for DEF Connector Reinforcement Caps
- SF626 Western Star Window Replacement Inspection Notification
- Western Star Service Bulletin for Key Fob ID Retention
- Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
- Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown
- DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to...
- DDC Field Service Campaign for GHG14 DETROIT DD13 with One-Box Aftertreatment Software Reprogramming
- Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Revised Western Star Service Bulletin forDT12 PTO Upfit
- Western Star Service Bulletin for Powernet Troubleshooting Guide
- Joyson Safety Systems letter informing DTNA about Hikone Webbing Investigation
- Tech Talk discussion about power steering fluid.
- Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
- Western Star Service Bulletin for Meritor Steer Axle Drum Brake Squeal
- Western Star Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change
- Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility
- Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces
- Western Star Service Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement
- Service Bulletin for Window Regulator Retrofit
- Warranty Information Letter for Warranty Training Online
- Warranty Policy Letter for Handling for Authorized Service Location Part Transfers
- Warranty Policy Letter for Chassis Progressive Damage Policy Change
- Updated DDC Field Service Campaign for GHG14 DETROIT DD13 with Two-Box Aftertreatment Software Reprogramming
- Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program
- Warranty Information Letter for Warranty Long Block Program Change
- Service Bulletin for Lengthening the Backup Light Harness
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Service Solution for Western Star vehicles equipped with Hendrickson AIRTEK Axles experiencing a Harsh Ride.
- Updated Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high...
- Export Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high...
- Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner...
- Tool Letter for updating Cascadia and Western Star 5700 oil-to-air coolers
- Service Bulletin for DT12 Transmission Cooler Retrofit
- Service Bulletin for DT12 PTO Upfit
- Service Bulletin for Equiflo Fuel System Breather Tube Inspection
- Tool Letter for ICC5 Programming Cable
- Tool Letter for New Tool Kit Replacement Components DDE DKICHA018006 Components 1, 2 and 3
- Tool Letter for DT12 Seal Protector Sleeve
- Field Service Campaign for Remanufactured Detroit DT12 Transmissions
- This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting...
- Service Information Bulletin was released, to add new procedures to address diagnostics near the high...
- DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on...
- Updates to troubleshooting guides in Diagnostic Link with newest version
- The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17...
- HDEP GHG17 engines are not equipped with turbo wastegates
- Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
- Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine...
- Service Information Bulletin regarding PTO Dosing
- Service Bulletin provided to customers regarding installation of a new MCM 21-pin jumper harness.
- Service Bulletin sent out to customers regarding ABS solenoids not doing self check
- Service Bulletin sent out to customers to repair damaged MCM 21-pin connector, terminals, and minor wiring.
- Hdep mcm 21
- Sbw0015 Vibration and Harsh Ride Troubleshooting
- Reminder: Paper Service Bulletin Mailings Are Discontinued
- Ss 1034171
- Detroit DT12 Split Rod Bushing Repair letter to customer
- Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
- Service Bulletin Paper Copy Mailings Are Discontinued
- Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
- Service Information Bulletin
- Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
- Sbw0004 Western Star Courtesy Engineering Policy
- Letter to customer on Coverage Extension GHG17 After Treatment
- 18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
- Sbw26005 DT12 PTO Upfit
- Service Bulletin Vibration and Harsh Ride Troubleshooting
- Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
- Service Information Bulletin for Aftertreamtent Failure Guide
- DD13, DD15, DD16
- Service Solution for HVAC Fresh Air Intake Water Leak in certaian Western Star models-4700, 4900, and 5700
- Ts 1033699: DT12
- HVAC Fresh Air Intake Water Leak
- Ts 1033768
- Training Solution for Western Star Front Brake Squeal
- Field Service Campaign: GHG14 Heavy Duty Engine Platform Vocational Application Programming
- Field Service Campaign
- Release of DiagnosticLink® 8.08 Service Pack 1
- Field Service Campaign D18M3 Oil_Suction_Manifold_072718, Owner Notice
- Operating Hours for the Customer Assistance Center
- 0505-18 spn 3563 hdep
- 0503-18
- 0502-18
- Brake Light Pressure switch may not activate the brake lights with a light application of the brake pedal.
- The automatic connector terminal removal tool is part of tool kit DDE KI0CHA17001.
- If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label
- In some operating conditions, water may leak into the cab onto the passenger floor through the HVAC fresh...
- With the start of production on March 6, 2018, the fasteners used to attach the slide- and plate-mount...
- 18SP734 18SP734?GHG14 DD15AT Turbocharger
- GHG14-18R3 bulletin-07-MAY-2018a-Emission Recall D18R3
- Owner18R3 Emission Recall D18R3
- Ss - 1033273: wst 5700XE
- Ss 1033315 - wst 5700
- SS1033446
- Ss 1033462 - wst
- Ss: 1033464 - wst 5700XE
- FL756 Brake Light Pressure Switches
- ICI18-016 FL756 ? Automotive Connector Terminal Removal Tool
- Sbw31013 Fifth Wheel Outboard Angle Mount Fastener Change
- Wp00002 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
- GHG14_18R3_bulletin_07-MAY-2018a Emission Recall D18R3
- Ss 1033403 - wst
- Vehicles with Meritor drivelines bene from a softer durometer center bearing support
- ICI18-014
- 0405-18
- 0402-18 spn 625 (CPC) (GHG14)
- 0401-18 spn 1231 (MCM) (EPA10 GHG14)
- 0312-18
- 0311-18
- MY18M1a_05-MAR-2018_Vocational
- Aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
- SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
- MY18M1a 05-MAR-2018 Vocational
- Fsbw42009 Diagnostic de fuite d'air
- Fsbw42010 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
- Fsbw49019 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du...
- Ssbw42010 Inspección de fugas de aire del transportista concesionario
- Ssbw49019 Manguera de presión del líquido de escape diésel (DEF) desconectada en la conexión del dosificador
- SS 1033304 -Western Star 5700 Side Window Defrost Performance
- 17TL26
- 17TL27
- 17TL28
- 17TL25
- Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
- Installation of the Transmission
- Removal of the Transmission
- Exhaust and Exhaust Gas Recirculation
- Power Take-Off
- EPA10, GHG14 and GHG17 Diesel Particulate Filters
- Spn 520960 (TCM)
- Spn 157 (MCM) (GHG17)
- 14CSA23 csc
- Instructions for CSC Diagnostic Support
- New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
- ICU4Me Low Air Pressure Warning Change
- Towing Procedures
- Meritor Wabco Bench Programming Kit DWA4008509600
- Engine Manufacturer Diagnostics
- Spn 3556 (ACM) (GHG14)
- Fuel Level Sending Unit Retrofit
- Technical Publications Ordering
- Spn 3226 (ACM) (GHG17)
- Diagnostic tests
- Spn 96 (MCM) (GHG17)
- Spn 712 (CPC) (GHG17)
- Fuel System Integrity Check Routine
- Cylinder Liner
- Spn 3464 (MCM) (GHG14)
- Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
- Heavy Duty Engine Wastegate Repair Kit DKI470E16019
- Detroit? DT12? Transmission Proper Moving Procedure
- Magnetized Fill Neck for Six-Gallon DEF Tanks
- Spn 3556 fmi 0, 1, 18
- Detroit? DT12? Split Rod Bushing Repair
- Spn 1663 (CPC) (EPA07 10 GHG14 GHG17)
- Fmi 2
- Spn 521221 (TCM)
- Spn 521222 (TCM)
- Spn 4765 fmi 0
- GHG14
- GHG14 Intake Manifold Pressure Too Low
- Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines
- (CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
- HVAC Fresh Air Intake Water Leak, 4700 and 5700
- 0301-17
- FL721 Interim Recall Ending ? Final Recall to Begin
- 0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
- FL725 Western Star Seat Belt Anchor Plates
- FL721 cng
- 0137-17 spn 3361 fmi 5 (ACM) (GHG17) spn 3361 fmi 5 (ACM) (GHG14)
- 0130-17 spn 520211 (IPPC) (GHG14) spn 520211 (IPPC) (GHG17)
- 0127-17 spn 1077 fmi 14 (GHG14) (GHG17) (MCM)
- 0120-17
- 0115-17 spn 3226 (ACM) (EPA10;GHG14)
- 0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
- 1213-16 spn 3480 (MCM) (EPA07;EPA10 GHG14)
- 1207-16 spn 4363 (ACM) (EPA10 GHG14)
- ICI16-027 FL725 ? Interim Recall Notice
- Paint Peeling, Hood.
- 16TL20 heavy duty engine valve stem seal installing drift and sleeve
- 1021-16 spn 110 (MCM)(EPA07EPA07;GHG14), spn 110 (CPC)(GHG14)
- 1018-16 symptom diagnostics - noise
- 1017-16 engine model and serial number designation
- 16TL17 label update for GHG14 test aftertreatment control module (ACM)
- 18SP713REV 18SP713 EPA10 DD13 three-filter fuel system to two-filter KM59 GEN1 fuel system conversion...
- FL718 front axle hub rating
- SBW0004 western star courtesy engineering policy
- 16-032_DETROIT standard diagnostic time for GHG14 aftertreatment device checklist updated
- 16TS18 EPA10 and later dd auto-elevate feature
- 0909-16 excessive oil consumption
- 0906-16 low pressure fuel pump
- 0902-16 symptom diagnostics - belt coming off, shredding or misalignment
- 0809-16 symptom diagnostics : noisy 1- box aftertreatment
- 16TS14 EPA10 and GHG14 service replacement 1-BOX doc inlet change
- SBW5455 virtual technician retrofit
- 0612-16 spn 175 (MCM) (GHG17) and spn 175 (MCM); ( EPA07;EPA10;GHG14) diagnostic procedure
- 0611-16 spn 110 (MCM) (GHG17) and spn 110 (MCM); (EPA07;EPA10;GHG14) diagnostic procedure
- 0610-16 spn 111 (CPC) (GHG17) and spn 111 (CPC); (EPA07;EPA10;GHG14) diagnostic procedure
- 0609-16 spn 174 (MCM) (GHG17), spn 174 (MCM) (EPA07), spn 174; (MCM) (EPA10), and spn 174 diagnostic procedure
- 0608-16 spn 715 (CPC) (EPA07;EPA10); spn 715 (CPC) (GHG14); spn 715 (CPC) (GHG17) diagnostic procedure
- New detroit diesel exhaust fluid awning standard repair time
- 0605-16 spn 625 (CPC)(GHG17) and spn 625 (CPC) (EPA10;GHG14) diagnostic procedure
- 0601-16 spn 103 (MCM) (GHG17) and spn 103 (MCM); (EPA07;EPA10;GHG14) diagnostic procedure
- Been incorrectly shimmed at the factory, and may lean slightly to the right or left
- 18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
- Inspection of the DD13 Turbocharger
- Spn 3226 (ACM) (EPA10;GHG14)
- SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
- Fmi 2, 3, 4
- Fmi 2 cpc
- Fmi 3,4,5
- Fmi 3,4,5
- Fmi 3,4,5
- FMI 3 Engine Oil Pressure Sensor Circuit Failed High
- FMI 5 Oil Pressure Sensor Stuck High
- Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
- 15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
- 16TS9 dd
- 16TL4 doc
- 16TS8 DD13
- 16TL5 dd
- Warranty Recognition Program Suspension
- 16-011
- 16TS7 Reman Diesel Particulate Filter Serial Number
- 16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
- New Detroit Bearing Failure Analysis Standard Diagnostic Time
- 16-009R_OWL Enhancements
- 16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
- 0308-16 TCM
- Canadian Warranty Parts Return Address Change
- 0307-16 spn 723 (MCM)
- 16TS5 Release of the DD Platform Bearing Failure Guide
- 0306-16 TCM spn 520970 fmi 7
- 0305-16 TCM spn 520999 fmi 7
- 0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
- Contaminated Fluids
- Hydrocarbon Doser Coolant Lines
- 0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
- 1210-14
- 1207-15
- 1205-15
- 15TS4_Rev2_ EPA07 DD15 Piston Kits
- 15TL24 otc 1750
- 1202-15
- 15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
- 1201-15
- 14TS16REV excessive overhead engine noise on GHG14 dd platform engines
- 18SP718 EPA07 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service kit
- 18SP720 EPA10 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service...
- 18SP720 EPA10 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service kit
- 18SP722 DD13 KM59 GEN1 bus two-filter system amplifier, needle and plv return fuel line clearance package...
- AEO15M1 GHG14 dd platform software reprogramming for auto elevate
- FINAL_15M1_BULLETIN GHG14 dd platform software reprogramming for auto elevate
- 15TL21 GHG17
- _Warranty Recognition Program
- 15-028
- GHG14 EGR
- 901-15
- 805-15 fmi 0
- 803-15
- 802-15 spn 520970 fmi 7 (TCM)
- Sbw8325 Side Window Defroster and Cooling Improvement Retrofit
- Sbw5401 Turn Signal and Brake Override Circuit
- 801-15 spn 520999 fmi 7 (TCM)
- 15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
- 711-15
- 15TS14 GHG14 dd
- 708-15
- 706-15 spn 1323 (MCM) (GHG14) spn 1324 (MCM) (GHG14) spn 1325
- 703-15 GHG14 DD15 at
- 702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
- Sbw5463 Nexiq USB-Link Upgrade and Diagnostic Connector
- Sbw5457 Powernet Troubleshooting Guide: Batteries, Path, Alternator
- 704-15 spn 4364 (ACM)(EPA10)
- 15-017
- 15-015
- 15-016-DLR
- FL680 Kidde Fire Extinguishers
- 18SP716
- 15CSA9
- 15CSA10
- 15CSA4
- 15TS10Rev DD Engine Platform Coolant Filter
- 14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
- 15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
- 15-010-DLR
- 15-009
- 15-009_Detroit_New_SDTs
- 15TL5 davco
- 15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
- Sbw0116 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
- 98-1
- 14TL8 TorcUP? Non-Impacting Torque Tool.
- 14-038
- 14-039
- 14-040
- 14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
- 14-039_additional_SDTs New Detroit Standard Diagnostic Times
- 14-038_New_SRTs Additional Detroit Standard Repair Times.
- 14CSA22 dtna
- 14WO-9_Warranty_Access Detroit New User Warranty Access Request
- 14TL9 Special Tool Warranty Program.
- 14TL7 dd
- 14CSA21
- 14CSA20 EGR
- 1010-14 spn 2623 (CPC) (GHG14)
- 1009-14 spn 5016 (ACM) (GHG14)
- 1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
- 1007-14 spn 5016/fmi 3, 4 (ACM) (EPA10)
- 1006-14 spn 4374 (ACM) (GHG14)
- 1005-14
- 1003-14
- Sb2080 Australian CST M1400 Isolated Radiator Retrofit
- 18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
- 18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
- 14-017R
- 14-029
- 18SP703 18SP703 - GHG14 KM63 GEN2
- 14TL2 dd
- 14TL5 ABS
- 14-028
- 14TS19 dd
- 14-027
- 14-026-DLR
- 715-14
- 14-022
- 14-023
- 14-024-DLR dtna & jad
- 714-14
- 713-14
- 712-14
- Detroit approved priming tools for the KM63 GEN2 fuel systemdetroit approved priming
- 0228-14
- 0224-14 spn 1590 fmi 9 - cpc
- 0219-14
- 14-005
- 0215-14
- 14-006
- 0202-14
- 0237-14
- 0233-14 spn 51 fmi 2
- 0229-14
- 0238-14
- 0239-14
- 12-039-DLR owl
- 12-040-DLR
- 12-043-DLR
- 12-038-DLR
- 12-027-DLR
- 12-022-DLR
- Automatic slack adjuster adjustment caution
VIN decoder
See the problems and recalls for an exact car
Buying a used 2014 Western Star 5700?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history