2025 Chevrolet Equinox problems

Filed Nov 9, 2026 · Electrical, Engine · OH

My 2025 Chevrolet Equinox AWD would not start, and the wheels were locked, preventing the vehicle from being moved normally. Message on HUB screen stated "System Error. See dealership to restore operating system." The vehicle had a little over 14,000 miles at the time. Had to be towed in. When the vehicle first went to the dealership, they found that the battery had critically low voltage. After consulting with GM Technical Assistance, the dealership replaced the battery. Even with the new battery, the vehicle still would not start and the wheels remained locked. The dealership then replaced the brake control module per TAC guidance. The dealership told me the vehicle started after the module was replaced and the locked wheel issue was resolved. The vehicle was at the dealership for more than 30 days. In a separate earlier incident, while I was driving on the freeway at approximately 75mph with my young child in the vehicle, the Equinox downshifted extremely hard and lost all electronic functions. This incident happened twice in one trip. I am including this incident as a prior safety history. I am asking the federal safety agency to review the no-start and locked wheel incident and the dealership's repair findings for a possible safety defect.

Filed Nov 6, 2026 · Acceleration, Driver assistance · WI

when using adaptive cruse control the car senses a car coming at me and breaks. there was nothing ahead of me nor any oncoming traffic in the other lane. It was a straight road with clear and open lanes. this has happened two times. it takes the car down from 55 to 40 right now. Lucky there wasn't anyone behind me. My second issue the car breaks when backing out of the garage with no obstructions. no safety issue but frustrating.

Filed Nov 5, 2026 · Driver assistance, Electrical · NY

Blindspot warning indicator (driver's side) sporadically lights up any where from a blink to approx. 10seconds along with corresponding seat vibrations. Also, forward obstruction light and seat vibration will also activate with nothing in sight. All occur while driving. Which can lead to anxiety about human error. I've had my vehicle to Auburn Chevrolet 4 times for this problem. They tell me that both modules connected to this problem have been replaced. And all software is up to date. Chevy admits this is a problem and states that they are working on a solution. When I asked the service manager if any other equinox's have this problem he stated that they did...but not as consistently as my vehicle.

Filed Oct 27, 2026 · Steering · CO

Steering wheel oscillates at higher speeds, most notably around 64 mph. This has been confirmed on roads of various types (concrete, asphalt, etc) by GM dealers. Manufacturer, so far, is not taking responsibility for this issue impacting numerous Equinox EVs.

Filed Oct 27, 2026 · Electrical · AZ

Vehicle has been presented for service multiple times for a recurring P050D – Cold Start Rough Idle condition. Due to the repeat nature of the repair, Fleet is requesting that the concern be treated as an unresolved/repeat repair and that the underlying cause be fully diagnosed rather than clearing the code or repeatedly addressing symptoms. Please review prior repair history and document previous repairs, current diagnostic findings, root cause, corrective action, and cold-start verification before returning the vehicle to service. Repaired on 10/23/2026 at Chapman Chevy - Recall Campaign N262547330-02 Telematic Control Module Reprogramming

Filed Oct 24, 2026 · OR

My 2025 Chevrolet Equinox EV has a recurring rodent intrusion problem in the HVAC system. I first noticed a persistent foul odor from the vents. When I inspected the cabin air filter, I found evidence of mice. I replaced the filter, but the odor continued, and I later found fresh mouse droppings on the new filter. Live mice were also found in the system, and the HVAC blower fan has since become very noisy. A service technician at CARR Cheverolet in Oregon told me this is a known issue with this vehicle: the cabin air intake has no screen or mesh, which lets rodents reach the cabin air filter and HVAC housing. If accurate, this suggests a design issue that may affect other Equinox EV owners, not an isolated event. This creates a health risk for vehicle occupants. Rodent droppings and urine can carry hantavirus and other pathogens, which can become airborne and be blown into the cabin when the HVAC fan runs. I regularly drive my three children in this vehicle. Avoiding the HVAC system is not a practical solution, since the defroster is needed for safe visibility. I am asking the federal safety agency to review whether the cabin air intake design on the Chevrolet Equinox EV allows rodent entry into the HVAC system, and whether other owners have reported the same problem.

Filed Oct 23, 2026 · Engine · ME

Roughly 6 months ago, the check engine light came on in my 2025 Chevrolet Equinox RS, which had under 20,000 miles on it at the time. I purchased an OBD scanner to run a diagnostic test, which came back with error code P04FB (Crankcase Ventilation Hose Connection Pressure Sensor Issue). I called the dealership that sold me the vehicle, and they ran their own diagnostics. They encountered the same error code, and ended up replacing the "faulty" crankcase ventilation pressure sensor, which was covered under warranty. Less than a week after they replaced the sensor, the check engine light came back on. I re-ran my OBD scanner, and it showed the same exact error code as before. Basically, the sensor was replaced, but the issue has not been resolved. I've been keeping tabs on GM's bulletin regarding this issue (which is apparently a known issue), and I'm concerned about the fact that there haven't been any recent updates regarding a fix. GM's own recommendation to dealerships is to simply clear the error code and return the vehicle to the customer... I can clear the code myself, but that certainly does not prevent it from coming back. At this point, the error code has been cleared at least 10 times, and it always comes back within a few days of clearing. This becomes a safety issue because we are quickly approaching the Winter months again, and the temperatures get very cold where I live. When the check engine light is on, my car fully prevents me from using the remote-start feature. I'm unable to remotely start the car from both my key FOB, and from the MyChevrolet app. Thank you for your attention to this matter. My hope is that GM's engineers find a real solution to this problem, and quickly! Because, as I said before, this has been an ongoing issue for many months, and I've yet to see any meaningful movement from GM on this issue.

Filed Oct 23, 2026 · Fuel system · AZ

Evap switch / fuel system. Vehicle slowed in heavy traffic. The issue was diagnosed and repaired at the dealership. There were no warning lights prior to the issue.

Filed Oct 19, 2026 · Body · CA

The door handles are hidden/flush into the door when driving or locked. They pop out electronically when the car unlocked. However, my door handle is faulty and they do not pop out anymore. There is no way to grab the handle and open the door. This is a safety hazard. In a fire or other emergency, there is no immediate way to grab the door handle and open the door. From my dialogue with other Equinox EV car owners, many have the same defect. Over time, more and more of these door handles will malfunction. This should be made into an immediate and permanent recall.

Filed Oct 19, 2026 · Wheels · NJ

The factory wheels on my 2025 Chevrolet Equinox EV suffer from a recurring structural defect. Within just over a year of ownership, two separate factory wheels have cracked under normal driving conditions on standard highway imperfections without hitting major potholes. The local dealership refused to cover the issue under warranty, claiming wheels are excluded. This poses a serious safety hazard due to unexpected structural failures on standard equipment.