2017 Chevrolet Silverado 1500: engine failure

Filed Nov 6, 2026 · Engine · 139,000 miles · FL

The contact owns a 2017 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, there was a loud clunking sound coming from the engine, the vehicle hesitated before accelerating and lost motive power. The check engine warning light was illuminated. The failure was intermittent. The vehicle was taken to a certified mechanic, where diagnostic testing determined that the engine failed and required replacement. The manufacturer was informed of the failure and confirmed that the VIN was not under recall. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 139,000.

Filed Jul 25, 2026 · Electrical, Engine · IL

the federal safety agency Safety Complaint To: the federal safety agency Regarding: Vehicle Safety Hazard / Fraudulent Repairs on 2017 Chevrolet Silverado VIN: [XXX] To Whom It May Concern, I am writing to file an emergency vehicle safety complaint regarding a 2017 Chevrolet Silverado, VIN [XXX], purchased on XXX. Huntley Ford performed unauthorized, fraudulent, and unsafe repairs that resulted in the vehicle being returned to me as an active fire hazard, directly violating federal motor vehicle safety expectations. Huntley Ford forced a salvage engine onto the vehicle, stripped me of my repair rights, and intentionally cleared dashboard error codes to mask severe, systemic mechanical defects. Following an engine replacement, transmission replacement, and catalytic converter replacement, I took the vehicle to Sunrise Chevrolet for inspection. The technician at Sunrise Chevrolet discovered that the vehicle was actively burning fluid onto the alternator. The technician explicitly stated that the vehicle was a fire hazard and that there was an emergency safety brake problem, and brakes. Huntley Ford knowingly delivered a structurally compromised and life-threatening vehicle. I request a full investigation into Huntley Ford’s repair safety practices to protect the public from further hazardous non-compliance. I have a 16 page paper trail Word document letter proving Huntley Ford committed auto fraud, has practiced illegal practices, lied, sold us a truck that they cleared codes, after only a few months full transmission, c. converter replacement, engine, and did not fix the truck properly still, returned it back to us when they knew it was not ok, lied, cleared codes, we brought our own scanner, they lied again, said the codes just needed to be cleared. When we notified [XXX], Huntley Ford's repair manager, he did nothing. Sincerely, [XXX]/[XXX] ________________________________________ INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 3, 2026 · Engine · 156,000 miles · CA

The contact owns a 2017 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, there was an abnormal metal-on-metal sound coming from the engine. No warning lights were illuminated. The contact stated that on a separate occasion, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the engine sounded rough. The vehicle was taken to two different independent mechanics, who diagnosed that the Active Fuel Management (AFM) and Dynamic Fuel Management (DFM) were impacting the lifters, which impacted the camshaft, and scraped the cylinder walls, causing the engine to fail. The vehicle was not repaired. The vehicle was then towed to the dealer, who confirmed the engine failure. The vehicle was not repaired due to the cost. The vehicle was towed to the residence and no longer driven. The failure mileage was approximately 156,000.

Filed Aug 21, 2025 · Engine, Transmission · NH

Premature engine failure specifically the lifters failed and the push rod failed causing the vehicle to become unusable and stranding the operator. Also transmission surges and slips causing unsafe driving conditions

Filed May 6, 2025 · Engine, Transmission · MO

While driving my vehicle, with around 85,000 miles, the engine suddenly began running rough and felt jerky and sluggish. This was concerning and potentially dangerous situation, as the engine failure happened while I was travelling at high speed. A sudden loss of power on the highway put me and other drivers at serious risk. The check engine light came on, so I pulled over as soon as I could safely do so. Shortly after, the light started flashing, so I shut off the engine and contacted the dealership service department. They advised having the vehicle towed in for inspection. Prior to this event, I had not had any issues with the vehicle nor had the check engine light come on. After looking into it, the dealership initially suspected a thrown rod but said they wouldn't know the full extent of the issue until they could tear down the engine. Upon further inspection, they determined that the lifters had failed and would need to be replaced. The dealership has performed all regular maintenance and oil changes on my vehicle. When I asked what could have caused this, they explained that it's a known issue with these lifters and engines - one that Chevrolet has experienced for years, even in models prior to my 2017.

Filed Apr 1, 2025 · Engine · CO

Lifters caused engine failure at 114000 miles resulting in needing a new engine

Filed Mar 3, 2025 · Brakes, Tires · VA

The contact owns a 2017 Chevrolet Silverado 1500. The contact stated that the vehicle was pulling to the right and the sensor light was illuminated while purchasing the vehicle. The contact stated that the failures were temporary. The contact stated that while driving at undisclosed speeds and depressing the brake pedal, the vehicle pulled to the right and the rear end of the vehicle felt as though the rear was dragging. The contact stated that there was a metal dragging sound coming from underneath the vehicle. The contact pulled over and inspected the vehicle but found no visible failures. The contact stated that the TPMS warning light was illuminated. The contact stated that smoke was coming from the passenger’s side front wheel. The vehicle was taken to a certified mechanic who diagnosed that the brake caliper had seized, and the brake line had collapsed. The contact was informed that the caliper and three sensors on the wheels needed to be replaced. Additionally, there was also a leak in the oil line. The vehicle was not repaired. The dealer was contacted and confirmed that the repair was not covered under warranty. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was not available.

Filed Feb 24, 2025 · Engine · PA

My truck is a 2017, but only has 46,000 miles on it. The engine light came on and it started banding loudly. I lost power and it would not go over 30 miles per hour. The dealer informed me the lifter failed and destroyed the cam shaft. Upon research, I have discovered this is a problem for many of the 5.3 engines. Many people are stuck now. I realize I have no warrantee, but I take excellent care of the truck and it only has 46,000 miles on it. It should not need a new motor, especially if it is due to a defect from GM. They knew about this issue and are doing nothing. I am now faced with an $11,000 quote for a new engine. This is wrong on so many levels.

Filed Feb 5, 2025 · Engine · OR

The truck suddenly started misfiring, running rough and lost power while driving. All the dash lights illuminated and the check engine light began flashing. We were a couple hours from home so we had to have the truck towed home. This could have been much worse as we were towing a trailer on a busy highway but luckily we were able to pull over to the side of the highway. Upon returning home we had the truck checked at the local Chevrolet dealership service department and were told we needed a whole new engine. After about 5 months after the initial incident we paid to have a new engine installed at the same dealership that inspected it. The truck had not exhibited any signs of any problems prior to the incident.

Filed Jan 23, 2025 · Engine · AR

Engine failure in December, 2024. Lifters, Cam Shaft and Cam Bearings. Working with my dealer now for an engine replacement.

Filed Dec 31, 2024 · Electrical, Engine · KY

2 times total electrical and engine failure while driving.

Filed Aug 12, 2024 · Brakes, Driver assistance · 175,000 miles · MD

The contact owns a 2017 Chevrolet Silverado 1500. The contact stated while driving approximately 45-50 MPH and then attempting to depress the brake pedal, the vehicle started pulling to the left, indicating the passenger’s side brake caliper had seized. The ABS warning light, and Stability Control failure warning light were illuminated. The vehicle was taken to Mavis Tires and Brakes body shop where brake pads and rotors were replaced; however, the failure reoccurred. The vehicle was returned to Mavis Tires and Brakes, and the two calipers, rotors, and brake pads were replaced. The contact stated that the failure recurred while driving approximately 41-60 MPH and hauling a trailer and attempting to stop at a stop light. The contact stated that the brakes failed to stop the vehicle immediately. The contact used an excessive amount of pressure to depress the brake pedal. The vehicle began pulling to the right and eventually coasted to a stop. The contact pulled into a nearby parking space where the brakes began smoking, the vehicle overheated, and the radiator fractured. The contact waited for the brakes to cool down and the smoke to dissipate before slowly driving to the dealer where the vehicle was diagnosed, and it was determined that the water pump had failed. The contact stated that the radiator had fractured, and 8 valves were damaged. The dealer linked the failure to the federal safety agency Campaign Number: 19V761000 (Service Brakes, Hydraulic, Service Brakes, Electronic Stability Control (ESC) however, the VIN was not included. The vehicle had been repaired. The manufacturer had been made aware of the failure where it was confirmed that the VIN was not included in the recall. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 175,000.