2020 Chevrolet Silverado 1500: engine failure

Filed Oct 12, 2026 · Engine · IN

I was driving the vehicle at around 50MPH after leaving a set of traffic lights when the engine lost all power and a series of warning lights came on. I pulled over safely to the side of the road and had the vehicle towed to a local vehicle mechanic shop. On investigation the engine had seized and a number of internal components had failed. The engine/vehicle I have owned since new and had approximately 103000 miles on it at the time of the incident.

Filed Oct 5, 2026 · Electrical, Engine · 73,000 miles · FL

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving, the vehicle was shuddering. The vehicle was taken to the dealer and was diagnosed with transmission failure. The contact was informed that the torque converter and transmission needed to be flushed. While driving approximately 30 MPH, the vehicle was shuddering and the transmission seized, with the check engine warning light illuminated. The failure had occurred briefly, and the failure was self-corrected, and the contact continued driving. The failure reoccurred approximately 2 - 3 times. The vehicle was returned to the dealer, and the transmission was replaced. The failure persisted, and the vehicle was returned to the dealer, and the transmission was replaced a second time. The vehicle was returned to the dealer, who was unable to diagnose or repair the vehicle. The contact drove the vehicle an additional 20,000 miles before the vehicle received additional repairs. The manufacturer was informed of the issue several times. The failure mileage was approximately 73,000.

Filed Oct 2, 2026 · Engine · OH

I was driving down the highway doing 70mph when my check engine light started flashing. I had to pull over and turn off my truck and turn it back on in order for it to go away. I brought it to the dealership and they explained that I had a misfire on the entire driver side of the engine and I would need to replace it. I have kept up on all of my vehicle maintenance but it still requires a new engine, costing $11,000 if not covered under warranty. This is a known problem with the Chevrolet 6.2L V8 engine and is now a class action lawsuit with the company.

Filed Aug 28, 2026 · Electrical, Engine · 10,000 miles · FL

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that the infotainment center intermittently went black, and there was water leaking into the vehicle through the top and lower center of the front windshield and the rear windshield. The vehicle was taken to a dealer, where the rear windshield was replaced without a diagnostic being performed; however, the failures persisted. Additionally, the side view mirrors intermittently failed to unfold when starting the vehicle. The contact stated that while driving approximately 40 MPH, white smoke emitted from the exhaust, the vehicle hesitated, and it lost power. The Check Engine warning light illuminated, along with "Service Electronic Stability Control", "Trailer Brake System", "Steering Assist Reduced", "Service Brake Assist", and "Brake System Failure" messages, and the vehicle failed to exceed 40 MPH. The vehicle was towed to a second dealer, Arcadia Chevrolet Buick (210 S Brevard Ave, Arcadia, FL 34266), where it was diagnosed that the lifter and torque converter had failed. The lifter and torque converter were replaced, and the system was flushed. Approximately 800 miles later, the engine failed again. The vehicle was towed to an independent mechanic, who diagnosed that the torque converter and transmission had fractured. The torque converter and transmission were replaced; however, the warning lights and messages illuminated again, and the vehicle continued to hesitate when driven over 42 MPH. After being parked for a few days, the warning lights were no longer illuminated and the mirrors opened, but the engine hesitation persisted. The vehicle was not further diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 10,000.

Filed Aug 21, 2026 · Engine · MI

Engine failure from bearings and lower rod from lifters. This is the second engine failure in vehicle for the same exact reason per dealership report. Entire engine replacement both times and all lights on dash were on.

Filed Jul 10, 2026 · Engine · TX

Dear Sir or Madam, I am submitting this complaint to request that the Federal Trade Commission investigate General Motors (Chevrolet) regarding what appears to be a known engine defect affecting the 2020 Chevrolet Silverado and the company's handling of this issue. I own a 2020 Chevrolet Silverado. In September 2025, when my truck had only 45,494 miles, I experienced an engine misfire consistent with a defect that has been widely reported by other owners. Through my research, I discovered that General Motors was aware of this issue and, rather than correcting the underlying mechanical defect, reportedly issued a Technical Service Bulletin (TSB) instructing dealerships to reprogram the Engine Control Module (ECM) to reduce or mask the symptoms instead of permanently repairing the root cause. Now, less than one year later, my truck is experiencing the same engine problems again. Although my vehicle has relatively low mileage, it is no longer covered under the factory warranty because of its age rather than its mileage. When I contacted Chevrolet Customer Assistance, I was advised to work with my local dealership to determine whether I might qualify for a "goodwill" repair. I do not believe it is fair for consumers to rely on discretionary goodwill assistance when the manufacturer was allegedly aware of a design defect before or during the time these vehicles were sold. Based on my research, properly repairing the underlying cause of this engine failure can cost as much as $15,000. Consumers should not be expected to bear the financial burden of repairing a defect that the manufacturer allegedly knew existed but failed to adequately correct. I respectfully request that the FTC investigate whether General Motors engaged in unfair or deceptive business practices by: Continuing to market and sell vehicles with a known engine defect. Addressing customer complaints with software reprogramming rather than permanently correcting the underlying mechanical issue. Failing

Filed Jun 20, 2026 · Engine · CA

I am filing this complaint regarding a major engine failure in my 2020 Chevrolet Silverado 1500 equipped with the 5.3L V8 engine. At approximately 56,000 miles, my vehicle experienced a failed valve lifter, resulting in loud engine ticking, a check engine light, loss of power, and unsafe driving conditions. The vehicle was no longer operating properly and required immediate repair. Although the vehicle had been regularly maintained and had relatively low mileage for such a significant engine issue, I was informed that the failed lifter damaged the camshaft and related engine components, requiring extensive repairs. The total cost of the repair was $6,180, which I paid out of pocket. My Silverado was just outside Chevrolet's 5-year/60,000-mile powertrain warranty period by time, despite having only 56,000 miles. A major internal engine failure should not occur on a well-maintained vehicle with such low mileage. After researching this issue, I discovered that lifter failures involving the Active Fuel Management (AFM) and Dynamic Fuel Management (DFM) systems in GM's 5.3L engines have been widely reported by other Chevrolet Silverado owners. This indicates a potential design or manufacturing defect rather than normal wear and tear. I am requesting that General Motors provide reimbursement or goodwill assistance for all or a substantial portion of the $6,180 repair cost. I believe customers should not be responsible for paying thousands of dollars to repair a known issue on a low-mileage vehicle. I respectfully request that this matter be reviewed and resolved promptly.

Filed Jun 1, 2026 · Electrical, Engine · 97,000 miles · IL

The contact owns a 2020 Chevrolet Silverado. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed, however the vehicle failed to accelrate as intended. The vehicle was taken to the dealer, howeve the failure was not duplicated. The failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed with a failed wiring harness and a failed coolant oump. The contact was informed that the wirng harness and the coolant pump needed to be replaced. The vehicle was repaired. The contact stated thirteen days later the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed with a failed transmission and failed coolant pump. The contact was informed that the transmission and the coolant pumo needed to be replaced. The vehicle was repaired. The failure reoccurred three days later. The vehicle was not diagnosed or repaired by an indpendent mechanic or dealer. The failure reoccurred. The failure was persistent. The contact stated tht within a year, the vehicle was taken to the dealer for ellectrical , transmission and engine failures. The contact stated that the wiring harness, transmission and coolant pump were replaced. In addition, the coolant ump was repalced two times. The vehicle was . The manufacturer was not made aware of the failure. The failure mileage was approximately 97,000.

Filed Jun 1, 2026 · Engine · NH

My 2020 Chevy TrailBoss 6.2L V8 L87, same engine that has been recalled for 2021-2024 literally went dead in the middle of rush hour traffic. The engine has been deemed dead due to the exact current recall reasons. Seeing that was traffic was flowing at 45mph that was not a good scene as the vehicle " locked" itself into park originally so I was stuck in the middle of traffic. The vehicle has been confirmed seized uo by the Portsmouth NH Chevy dealer which is the Key Auto Group. Warranty adjusters representatives from a third party, not GM, will be assessing it this week. I purchased an after market warranty not by GM. I had no warning lights leading into the failure.

Filed May 18, 2026 · Engine · OK

I was driving on I-35 in Norman, Oklahoma, shortly after 7 am, when my 2020 Chevy Trail Boss with the 6.2 engine stopped running. I was in moderate traffic and shifted the gear shifter to neutral, and the motor would not restart, leaving me in traffic. I was able to slowly get on teh shoulder to avoid a collision, and the engine would not restart. I had teh vehicle towed to Ammco in Norman, Oklahoma, where it was determined that a catastrophic engine failure occurred. This is teh same problems that are associated with recalls on the 2021 and up 6.2 GM engine. luckly i was able to get to a safe place and avoid a collision.

Filed May 14, 2026 · Engine · MI

While returning from a camping trip my engine lost power. luckily I was close to an exit and managed to get it off the expressway and to a parking lot. I was able to leave the camper in the lot and have the truck towed to a dealer 30 miles away. I was informed by the dealer that the engine had sustained major berring failure. I was over 500 miles from home and I had 2 options, wait 2 weeks for a new engine to be installed or trade it in for a new truck. I opted for the trade in because I didn't want to wait 2 weeks. I figure I lost $7000 in trade in value and had to spend $2000 to have my new truck fitted for a 5th wheel hitch.

Filed Apr 20, 2026 · Engine · FL

-My 2020 Trail-boss 6.2 Engine broke and stopped producing power and shut off, it is available for inspection and has been inspected by my local Chevy Dealer Tom Gibbs Chevrolet. -My son was crossing a railroad track and it shut off as he topped the tracks it shutoff at the tracks and he was able to coast down out of the way. If it shut off a second earlier he would have been stuck on the tracks and there is a list of what if's. My grandson in the car seat, my son gets out breaks his ankle and can't get my grandson out there is so many things that could have happened. -The dealer stated the 6.2 engine is known to have mechanical failures -The local dealer stated valve cover was removed and no movement in valve train needs new engine at a cost of $21,343.24 They realized that the original $250 rubber serpentine belt outlasted the engine with 123K miles on it -No warning lights, no rough running, no sounds just shut off no power.