Unknown Cause, Engine Failure, Replaced at Bob Utter Ford In [XXX]. Invoice #XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The worst 2022 Ford E-450 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Steering9
- Brakes7
- Engine3
- Airbags2
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Steering9
- Brakes7
- Engine3
- Airbags2
Recalls 3
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.
- Risk
- A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
- Remedy
- Dealers will replace the power steering pressure line and the hydroboost jumper line, free of charge. Vehicles in this recall were previously recalled under 22V‑089 and owners will need to have the new remedy completed even if their vehicle was remedied under the prior recall. Owner notification letters were mailed on June 21, 2024. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 24S07.
Recall number 24V097000 · Recall details
Fuel system, gasoline: storage: tank assembly
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2022-2023 E-350, E-450, and 2021-2022 F-59 vehicles. The paint along the weld seam of the fuel tank may peel and lead to corrosion of the exposed metal, which can result in a fuel leak.
- Risk
- A fuel leak in the presence of an ignition source increases the risk of a fire.
- Remedy
- Dealers will inspect the fuel tank and replace, if necessary, free of charge. Owner notification letters were mailed on April 14, 2023. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 22S76.
Recall number 22V925000 · Recall details
Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittings
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.
- Risk
- A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
- Remedy
- Dealers will inspect the connection between the power steering lines and the Hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed on March 18, 2022. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 22S08.
Recall number 22V089000 · Recall details
See all 3 recalls for the 2022 Ford E-450
Defect investigations
Loss of Power Brake/Steering Assist Post Recall 22V089 Inspection.
The Office of Defects Investigation (ODI) opened Recall Query (RQ) 24003 on February 27, 2024, to evaluate the scope and remedy effectiveness of the federal safety agency recall 24V097. On February 16, 2022, Ford Motor Company (Ford) issued a safety recall, the federal safety agency recall 22V089, for certain 2021-2022 Ford E-350 and E-450 vehicles equipped with dual rear wheels. According to the filing, specific hydraulic lines could leak resulting in a sudden loss of power steering and power brake assist, increasing the risk of a crash. The remedy involved a dealer inspection of the lines and their replacement as necessary. Only vehicles that failed the inspection received updated parts. On February 9, 2024, Ford issued a new recall, the federal safety agency recall 24V097, to replace the specific hydraulic lines on any vehicle that had not yet been inspected and on any vehicle which had passed inspection within the previous twelve months. However, vehicles which had passed the inspection more than twelve months ago would not be included within the scope of the new recall, as Ford deemed them to have a low likelihood of failure. ODI opened this RQ to better understand Ford's scoping of recall 24V097, specifically concerning the inspected-only vehicles not included in the new recall filing. ODI sent Ford an information request letter on April 18, 2024. Ford responded, in full, on May 31, 2024. ODI reviewed Ford's data which showed that the vehicles not included in the new recall had a predicted failure rate of less than 0.25% within 10 years from the date of inspection. By comparison, the vehicles included in the new filing have had a failure rate of approximately 2% prior to being recalled again. ODI analysis of complaint and warranty data further supports Ford's assessment that vehicles that passed inspection more than twelve months prior to recall 24V097 are unlikely to experience the defect condition. ODI is closing this RQ without a manufacturer action. The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to
RQ24003
Technical service bulletins for the 2022 Ford E-450 34
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This article supersedes TSB 25-2572 to update the Parts List to correct the part number LC3Z-6006-L to...
- Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless...
- This article supersedes TSB 25-2322 to update the Service Procedure, Labor Operations and Parts List
- Rattle/scraping noise from the bellhousing area on start-up. Workshop Manual (WSM), Section 303-00 Engine...
- Rattle/scraping noise upon startup that may remain after the engine is running
- Incorrectly illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0420 and/or...
- This article supersedes TSB 25-2200 to update the parts list to add the new camshaft and tappet service...
- Some 2021-2024 Edge/Nautilus, 2021-2025 Bronco/Bronco...
- Upper engine ticking or tapping noise at idle
- Some 2020 Continental, 2020-2024 Edge/Nautilus, 2020-2025 Explorer/Aviator/Escape/Corsair/F-150/F-Super...
What 2022 Ford E-450 owners say
Most recent owner complaints, unedited.
Air bag cover separating
Airbag cover is separating
The contact owns a 2022 Ford E-450. The contact received notification of Customer Satisfaction Program: 24N03 (Hydro boost or Hydro max Power Steering Pressure and Jumper Line Replacement). The contact stated that while driving 70 MPH, the brake pedal was depressed but the vehicle failed to stop immediately. The contact downshifted the transmission from fifth to first gear to stop the vehicle. Additionally, the vehicle experienced a loss of power steering assist while turning. There was no warning light illuminated. The vehicle was towed to the dealer, where it was determined that the hydro boost power steering pressure and jumper line needed to be replaced. The vehicle was not repaired. The contact related the failure to the federal safety agency Campaign Number: 24V097000 (Steering, Service Brakes, Hydraulic); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 12,750.
See attached document for complaint.
We operate numerous 7.3L Ford engine equipped vehicles in our fleet of ambulances. Over the past year we have experienced 4 engine failures of this 7.3L engine in vehicles ranging form around 60,000 to 90,000 after exceeding the service recommendations stated from the manufacturer. I have contacted the Ford Pro Fleet experts and have asked repeatedly about what could be causing the failures, trying to figure out if we are doing something wrong in our maintenance or operation. They assure us we are not doing anything wrong, however we continue to lose engines. Each time the repair bill is around $12,000. We have been lucky that Ford has offered financial assistance, but now that has gone away. At first, we were told that we were the only ones experiencing these failures, but now I am hearing from other operators of similar vehicles that they are experiencing the same concern. We cannot afford to keep replacing engines in relatively new vehicles, especially when there is an apparent defect in parts or standard operation. Symptoms we experience that lead to engine replacement are loss of power while driving caused my multiple cylinder misfires. Loss of power while running an emergency call pose a significant safety risk to operators and patients.
The contact owns a 2022 Ford E-450. The contact had received notification of the federal safety agency Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic) and the vehicle was taken to the dealer to be repaired under the recall. The contact stated that the recall repair was not performed; however, the dealer inspected the vehicle and informed the contact that the recall repair was not needed, and that the vehicle was good to be driven. The contact stated that while driving at an undisclosed speed, the power steering and the service brakes were inoperable. The contact stated that the steering failed to function as intended. Additionally, the contact stated that while depressing the brake pedal, the brakes failed to respond as needed. The contact was able to stop the vehicle. The vehicle was towed to Castle Ford in Michigan City. The vehicle was diagnosed with failed power steering connection line and a failed brake hydro boost unit. The vehicle was then repaired under the federal safety agency Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The contact stated that the failure occurred thirty days after the vehicle was serviced at the dealer and the dealer declined to complete the recall repair. The contact stated that the failure occurred while out of town. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 4,000.
I am a mechanic at Huron Valley Ambulance. Ford has a recall that covers some of our Ambulances. Recall NO: 22S08 for the power steering lines coming apart. I have been having issues with the hoses coming apart even after the recall has been performed. The Ford dealer will not cover this repair after the recall has been done. This is a safety issue as both the steering and braking are effected. It is also time consuming and expensive to repair. I feel this recall is not correcting this problem and needs to be addressed.
The tire pressure monitoring system fails frequently while being driven. The first few times I pulled off the road and checked the pressures, and they were normal. I had the system checked at a Ford dealership and they couldn't find any problem. It failed again. I returned to the dealership and they said they couldn't find a problem and there is nothing they could do for me. So I drive away from the dealership and the same thing happens. Believing that they can't do anything I keep driving and manually checking pressures. Problem returns. I went to a different Ford dealership and they said they found a faulty sensor and replaced it. The same problem came back after less than a few miles. I needed gas so I filled up and realized that after turning the ignition off and restarting, the light on the dash and the warning went away. I returned to that dealership and they said after hearing my explanation. They couldn't do anything unless the fault was active at the time I brought it to them. So I was told to drive it until I got the safety warning and to not shut it off until I got to a Ford dealership. Really!!! Not all Ford dealerships will service the E450s with RVs built on the chassis. Reasonable? No way! There is a problem with the system that Ford should be able to correct. I don't feel safe having to pull over and check tire pressures on a busy highway. And it's not necessary if they address the problem and fix it
The contact owns a 2022 Ford E-450. The contact stated while driving 60 MPH, the steering wheel felt loose, and the vehicle was difficult to control. The check engine warning light was illuminated. The vehicle was taken to the dealer and the dealer stated no failure was found, but the failure persisted. The vehicle was taken back to the dealer and the vehicle was repaired. The contact was unsure what was repairs were made or what parts were replaced. The failure persisted. The manufacturer was not contacted. The failure mileage was 3,000.
Compare the 2022 Ford E-450
Other model years
1993199619971998199920002001200220032004200520062007200820092010201120122013201420152016201720182019202120222023202420252026
Questions about the 2022 Ford E-450
Is the 2022 Ford E-450 reliable?
Owners have filed 14 complaints about the 2022 Ford E-450, 1.2 times a typical E-450 model year.
What is the 2022 Ford E-450 year score?
The 2022 Ford E-450 scores 68 out of 100 (average). The score compares it with the other model years of the Ford E-450: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2022 Ford E-450?
Steering, with 9 complaints, typically around 4,000 miles. Next is brakes (7).
How many recalls does the 2022 Ford E-450 have?
3 recalls, covering service brakes, hydraulic and fuel system, gasoline.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Ford E-450?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history