within the first minute of engine start there is a high-voltage buzzing sound following with a minor smoke smell coming either from the engine bay or back of the car. You could hear this sound from outside, especially my neighbors witnessed the sound from the sidewalk. when it happens it suddenly loses power and control of the vehicle. I reported this issue to Ford helpdesk but they mentioned there was no recall for my VIN. It almost feels like it would electrocute someone.
The worst 2021 Ford Escape Hybrid problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Engine36
- Body32
- Electrical23
- Transmission14
- Fuel system12
- Brakes7
- Acceleration6
- Driver assistance3
- Seat belts3
- Airbags1
- Seats1
- Visibility1
- Wheels1
Specific symptoms reported on the 2021 Ford Escape Hybrid
Recalls 1
Engine and engine cooling: engine: hard parts internal/mechanical
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2021 Escape Hybrid vehicles. The engine crankshaft may have been manufactured incorrectly, which can result in engine damage.
- Risk
- Engine damage can cause a vehicle stall or fire, increasing the risk of a crash or injury.
- Remedy
- Dealers will inspect the crankshaft and replace the engine, as necessary, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed March 2, 2022. Owner notification letters were mailed on March 21, 2022. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 22S10.
Recall number 22V109000 · Recall details
See all 1 recalls for the 2021 Ford Escape Hybrid
Defect investigations
Failed Door Check Arm Attachment Point
On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupantsâ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Fordâs testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Fordâs customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
PE23013
Pedestrian alert sounds
the federal safety agency received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, the federal safety agency opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified the federal safety agency he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by the federal safety agency regarding the subject matter of the petition.
DP22005
Technical service bulletins for the 2021 Ford Escape Hybrid 23
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Some 2020-2026 Escape and 2022-2026 Maverick 2.5L Duratec hybrid vehicles may require various repairs on...
- Certain 2020-2024 Model Year Escape and 2021-2024 Model Year Corsair Plug-in Hybrid Electric Vehicles...
- This article supersedes TSB 23-2244 to add 2024 model year
- 2020-2023
- Condition where the 12V battery voltage is low or discharged with diagnostic trouble code (DTC) U3003:62...
- Chatter/shudder during low speed turning events
- Condition where the 12V battery voltage is low or discharged with diagnostic trouble code (DTC) U3003:62...
- Grinding or rubbing noise while braking at or below 10 mph (16 km/h) from the front of the vehicle
- The Service Awareness Newsletter is an informal communication that contains information that may not be...
- Condition where the 12V battery voltage is low or discharged with diagnostic trouble code (DTC) U3003:62...
What 2021 Ford Escape Hybrid owners say
Most recent owner complaints, unedited.
The ABS system fails to engage If the vehicle is coming to a stop and there is even the slightest bump on the road. ABS disengages the brakes which follows with a rapid acceleration of the vehicle instead of slowing down. Issue occurs even If one of the rear tires feels a slight bump. This issue occurs even on dry and hot conditions unrelated to slippery conditions. I am worried in slippery conditions it gets worse.
On Saturday at approximately 8:25 p.m., my 2021 Ford Escape Hybrid SEL abruptly entered limp mode while traveling on a major highway. The vehicle's speed rapidly dropped from approximately 60-65mph to 20 mph in heavy, high-speed (many driving over 70mph)traffic. I immediately activated my hazard lights and exited the highway at the first opportunity, narrowly avoiding a serious fatal collision. Today, Crossroads Ford in Apex, North Carolina, informed me that the issue was caused by a faulty engine sensor. Given the severe safety hazard this created and the existing recalls associated with this vehicle model, I am requesting that this matter be fully addressed. I am currently being told that I will be required to pay for these repairs out of pocket, which I do not believe is appropriate for a critical safety failure. Thank you for your prompt attention to this urgent matter. I look forward to your response regarding how this issue will be resolved.
The fuel door actuator malfunctioned, rendering the emergency release ineffective. This necessitated a replacement at 30,000 miles or four years from the manufacturing date. We believe that an inoperable fuel door presents a significant safety concern.
The contact owns a 2021 Ford Escape. The contact stated that while driving approximately 45 MPH, the vehicle suddenly decelerated and failed to properly accelerate while depressing the accelerator pedal. The vehicle was parked on the side of the road and was later towed to the local dealer. The vehicle was serviced by the dealer. No further information was available. The contact stated that after retrieving the vehicle, the vehicle unintendedly accelerated and erroneously accelerated into an intersection. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 50,000.
Seatbelt locks in position on the passenger side. Must stop car let seatbelt retract all the way and reattach seatbelt. Dealer wanted $225 to diagnose problem if they could not find and/or duplicate issue.
After picking my vehicle up from a day and a half of recall repairs, I immediately experienced a rubbing sound and a shuddering when I turned my wheels to the right and moved forward as I attempted to drive away from the parking space. There were no issues when turning the wheels to the left to back out of the parking space. I immediately pulled into the service bay to report the problem. A maintenance tech came out and asked to drive it. When the vehicle was returned, I was told they felt it was the rear differential but would need to schedule another appointment so they could listen to it more, at a cost of $130 to diagnose. I researched this issue and found out that a recall has been issued for a different lot of VINs for 2021 Ford Escapes for this same issue due to installation errors or incorrect lubrication.
Subject: Formal Complaint – Recall 23B56 & 23S27 + Rental Car Reimbursement Demand – McCombs Ford (7111 NW Loop 410) To Whom It May Concern, I am writing to file a formal complaint regarding the unacceptable service I experienced at McCombs Ford West, located at 7111 NW Loop 410, San Antonio, TX, concerning two open safety recalls on my 2021 Ford Escape, VIN: [XXX] and to formally request reimbursement for out-of-pocket expenses caused directly by the dealership's failure to prepare for my scheduled appointment. I scheduled a service appointment in February 2026 to address two outstanding safety recalls: •Recall 23B56 – Inspect front door check-arm reinforcement spot welds •Recall 23S27 – Underhood fire risk After waiting nearly five months, I was given an appointment on July 7, 2026. I dropped off my 2021 Ford Escape on July 7, 2026 as scheduled. At drop-off, I was informed the repairs would take multiple days, and I was told no loaner vehicle would be provided. Based on that, I rented a vehicle at my own expense to cover my transportation needs. The following day, I received a call from the service department informing me: 1.Recall 23B56 (Door Reinforcement): The dealership was unable to perform the repair because they had never ordered the required replacement door — despite having five months' notice from my original February 2026 booking. They stated they would "order it now." This is entirely unacceptable and reflects a clear failure of basic service planning. 2.Recall 23S27 (Underhood Fire): The dealership refused to perform Supporting documents attached : McCombs Ford service reference document & rental car invoice ($43.92) Reference details /dealership : MCCOMBS. 7111 N.W. LOOP 410 SAN ANTONIO, TEXAS 78238 (210) 509-1000 VIN: [XXX] 23S27 UNDER HOOD FIRE 26S14 FRONT WIPER MOTOR REPAIR 23E09 REPROGRAM POWERTRAIN CONTROL MODULE 23B56 INSPECT FRONT DOOR CHECK-ARM REINFORCEMENT SPOT WELDS 23N06 LONG BLOCK REPLACEMENT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.
While driving the vehicle it lost power and all the check lights came on. Had to have it towed to a dealership where they stated it needed a new motor and new high voltage battery. The car has only 116000 miles on it. There should be a total recall for this type of vehicle if I would have been at a higher speed I would have injured myself or others. This car is riddled with problems and has over 19 recalls as of date.
While vehicle is set on cruise control , set at 70 MPH , ( or set to any other speed) , anytime the speed limit changes to 80 MPH (or other change) Car accelerates and cruise control is set to 100 MPH . It also accelerates and resets to 90 -100 MPH at random . It is frightening and dangerous to have my car randomly accelerate. I have attempted to pass a vehicle, when my car randomly accelerates to 100 MPH . This is very dangerous and can happen at any random time . The lane assist is also dangerous when car can not see lines separating lanes . I have had my car jerk the wheel when I was detoured through construction. I am very concerned with my car accelerating. Not only does it leave me vulnerable to receiving a speeding ticket , it also increases the likelihood of hitting an object or having an accident.
Compare the 2021 Ford Escape Hybrid
Other model years
200520062007200820092010201120122013202020212022202320242025
Questions about the 2021 Ford Escape Hybrid
Is the 2021 Ford Escape Hybrid reliable?
Owners have filed 124 complaints about the 2021 Ford Escape Hybrid, close to a typical Escape Hybrid model year.
What is the 2021 Ford Escape Hybrid year score?
The 2021 Ford Escape Hybrid scores 75 out of 100 (average). The score compares it with the other model years of the Ford Escape Hybrid: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2021 Ford Escape Hybrid?
Engine and cooling, with 36 complaints. Next is body (32).
How many recalls does the 2021 Ford Escape Hybrid have?
1 recall, covering engine and engine cooling.
Was there a recall on the 2021 Ford Escape Hybrid engine?
Yes, 1 recall: 22V109000. Check your VIN to see if your car still needs the free repair.
What year does the Ford Escape Hybrid have bad engine?
The Ford Escape Hybrid model years with the most engine complaints are 2008 (111 complaints), 2020 (65 complaints) and 2006 (55 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Ford Escape Hybrid?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history