2018 Ford Escape: engine overheating

Filed Oct 27, 2026 · Engine · PA

The vehicle is experiencing ongoing coolant loss with no visible external leak. The coolant level drops consistently and requires frequent refilling. The issue began around mid‑mileage and has continued to worsen. The engine sometimes emits a coolant smell, and the temperature gauge rises more quickly than normal. Warning messages about high engine temperature have appeared during driving. The dealer inspected the vehicle but could not find an external leak and stated the condition was normal, even though the coolant continues to disappear. No repairs have resolved the issue. Based on known problems with EcoBoost engines, an internal coolant leak or cylinder head defect is suspected, but the exact cause is UNKNOWN. This creates a safety risk because sudden overheating can occur while driving, which may lead to engine failure, loss of power, or stalling in traffic. The issue is ongoing and the vehicle is available for inspection upon request.

Filed Oct 21, 2026 · Engine, Lights · MO · fire

There have been several issues that cause safety concerns with my 2018 Ford Escape 1.5L Ecoboost. The two most concerning are the headlights and engine failure. Since I drove this vehicle off the lot in 2023 I have had to replace the headlights every 4 to 6 months. I recently learned it is do to an electrical issue and the most recent occurrence caused a small fire under the hood of my vehicle. Sometimes both lights would go out at once without warning. This issue has been reported by numerous consumers and Ford has done nothing. Regarding the engine failure, a coolant leak was reported by two mechanics but the source of the leak couldn't be identified. It was only discovered it was internal when my vehicle just stopped while pulling forward in a drive through. Luckily it wasn't on the highway but if it had been it could've caused an accident, at 70 mph, that likely would've resulted in minor injuries for not only me but other drivers. Ford has been made aware of this issue by owners of 2013-2019 Ford Escape Ecoboost vehicles but still hasn't issued a recall. Ford refuses to do anything about this and has instructed its customer support team to tell consumers they "can't" (won't) do anything outside of warranty. This issue often occurs outside of warranty. Ford still hasn't issued a recall despite numerous lawsuits for this exact problem. All customers can do is file a complaint. There are thousands of these vehicles on the road and if Ford continues to do nothing this could eventually lead to fatalities due to vehicle collisions. Someone needs to do something if Ford won't. Engine failure 10/20/26; electrical fire September 2026; lighting failure 2023-2026. The fact someone was fine selling this vehicle, despite consumer reports, is appalling.

Filed Oct 12, 2026 · Electrical, Engine · TX

On approximately September 28, 2026, the vehicle began sputtering when first turned on. It then progressed to running extremely rough. On September 30, 2026 the Engine Icon lit up first. A few days later, I received an Engine Fault Service Now message. I went to the Auto Zone on October 4, 2026 and they ran a diagnostic check. These are the codes that were found: Check Engine Fail Replace Ignition Coil and Spark Plug #3 P0303 Cylinder 3 misfire detected P0339 Crankshaft Position Sensor A Circuit Intermittent P0300 Random misfire detected Cylinder 3 On October 5, 2026, I took it to my mechanic and he began checking everything. He found oil on and inside the computer. He also found that there was antifreeze residue on the Cylinder and Spark Plugs. He did some research to find out what could cause this to happen. He found the following: 1,134–1,711 engine complaints depending on dataset. Failures typically occur between 50,000 and 100,000 miles. Main Engine Problems 1. Coolant Intrusion (1.5L EcoBoost – Most Common & Severe) Coolant leaks past the block/head sealing surface into cylinders. Not a head gasket failure—requires short-block or long-block replacement. Symptoms: Misfire codes (P0300–P0304) White exhaust smoke Unexplained coolant loss Rough idle, stalling, overheating. 2. Cracked Engine Block Often the end result of prolonged coolant intrusion. Leads to catastrophic engine failure requiring full replacement. On Friday, October 9, 2026, I drove my car to work, approximately 2.5 miles, after the Escape sitting for 3.5 hours, I started it. I immediately received the HIGH ENGINE TEMPERATURE STOP SAFELY, and the engine shut off. On the 3rd try, the Escape stayed running. I could only drive 11 mph. On my final turn onto a busy street, the Escape began sputtering and would not accelerate at all. I was stuck in the middle of the street, putting myself at risk of being hit. I finally made it to a parking lot but had to be pushed home by my son.

Filed Oct 11, 2026 · Engine · NV

VIN:[XXX] Current Mileage: 110,900 I am experiencing coolant intrusion in the engine of my 2018 Ford Escape equipped with the 1.5L EcoBoost engine. The vehicle is losing coolant with no external leak visible. This has led to engine misfires, rough idling, and concerns about potential engine damage or failure. This issue is identical to known coolant intrusion problems documented in other Ford EcoBoost engines of similar model years. Safety Concern: Coolant intrusion can cause sudden engine failure while driving, creating a hazardous situation—especially at highway speeds or in heavy traffic. This poses a significant risk to my safety and the safety of others on the road. Requested Action: I am requesting the federal safety agency review this issue as a potential recurring safety defect affecting the 2018 Ford Escape. Many owners have reported similar coolant intrusion problems, and a recall or investigation may be warranted to prevent engine failure–related accidents. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 2, 2026 · Engine · 94,000 miles · GA

The contact owns a 2018 Ford Escape. The contact stated that while driving 45 MPH, the head gasket of the engine cracked and the vehicle stalled. There was coolant leaking into the engine previously, and the vehicle was repaired. The vehicle was leaking coolant. There was white smoke coming from the tailpipe with a sweet odor during the failure. The vehicle was towed to the residence. The manufacturer was contacted by phone, where a case was opened. The contact was informed that there was no recall or manufacturer warranty on the vehicle. The dealer informed the contact that the engine needed to be replaced. A mobile mechanic diagnosed the vehicle and confirmed that the head gasket was cracked. The approximate failure mileage was 94,000.

Filed Oct 2, 2026 · Engine · AK

Engine has been diagnosed with coolant intrusion (very common ford ecoboost engine problem) where due to a manufacturing defect the engine has grooves in cylinder that allow coolant to enter combustion chamber. This causes coolant loss, engine mis fires, lots of white smoke upon starting and extremely rough idle. car has 120000 miles and the cost to repair is over 10,000 dollars. The vehicle and remainder of loan is a total loss because the common problem has made the trade in value around $6000 even if repaired. With out use of vehicle and remainder of loan and repairs I will be around 16000 in the hole and have to sell as salvage. FORD needs to recall this 2.0 ecoboost engine.

Filed Sep 26, 2026 · Engine · TX

2018 Ford Escape Mileage 74,920. Catastrophic unrepairable engine failure due to coolant leaking into engine on 09/21/26. Ford Motor Company knew of this design flaw as early as 2010 but continued manufacturing and selling the cars with this flaw. Engine light came on but only after the engine was already compromised. Car was towed to Clay Cooley Ford Dealer in Arlington Texas on 09/23/26 who confirmed this diagnosis. My safety and safety of others was at risk because the car stopped running while I was in traffic with no warning, and it could have caused a fire.

Filed Sep 23, 2026 · TX

Coolant reservoir emptying due to design flaws. Rough idle,white smoke from exhaust. Engine light constantly on. No Coolant or wet spots on the ground. Coolant leaking into the cylinders. Not good.

Filed Sep 15, 2026 · Engine · NY

My 2018 Ford Escape SEL with the 1.5L EcoBoost engine has only 12,770 miles. The vehicle experienced a misfire and coolant-related issue resulting in loss of engine power and a dashboard warning stating, “High Engine Temperature – Stop Safely.” Fortunately, this occurred as I was driving out of my driveway rather than at highway speed. The vehicle would not drive and had to be towed to my independent mechanic, where it remains. On May 22, 2026, the check engine light appeared. I brought the vehicle to my mechanic, but no problem was identified. When the light reappeared, I returned on July 9, 2026. The ignition coil and spark plugs were replaced. On July 27, 2026, the “High Engine Temperature – Stop Safely” warning appeared and the vehicle lost power. My mechanic subsequently identified a misfire and coolant-related issue. Importantly, on February 5, 2020, at only 4,259 miles, Levittown Ford performed Ford Customer Satisfaction Program 19B37 on this vehicle.(See attached) CSP 19B37 addressed the potential for coolant intrusion into the cylinder bores of certain vehicles equipped with the 1.5L EcoBoost engine. I recently learned that Ford subsequently established CSP 21N12, “Short Block Replacement After Coolant Intrusion,” for certain vehicles that previously received 19B37 and later experienced coolant intrusion. This expired in 2022. I am concerned that my vehicle, despite having only 12,770 miles and previously receiving CSP 19B37, is now experiencing a misfire, coolant-related problem, overheating warning, and loss of engine power. Had this occurred at highway speed rather than while leaving my driveway, it could have created a serious safety hazard.

Filed Sep 9, 2026 · Engine · CA

The engine is having issues. There is coolant leaking into the engine. Causing for the engine to shake upon starting the car. Issues that can come from operating the vehicle are overheating, fire and explosion of engine. I took the car for diagnostics at a Ford dealership and they confirmed that it is a fault with the engine that Ford is aware about but issued no recall. The check engine light first appeared on Saturday 9/05/2026 and that same day upon igniting the engine that was the first time that the engine rattled when starting the vehicle.

Filed Sep 4, 2026 · Engine · NH

There is coolant intrusion into the engine. My car became overheated and undriveable while I was driving. Ford knows about this issue, but is no longer addressing the issue.

Filed Sep 2, 2026 · Engine · IL

I have a 2018 Ford Escape with the 1.5L engine with 108k miles purchased new in 2018. Noticed the car recently stuttered at times upon vehicle start up and then would smooth out shortly after starting. Check engine light came on, checked the code and it indicated P0301 which is a misfire on cylinder 1. Since it would run I thought it was probably a spark plug misfire so I made an appointment with a dealer to change the plugs. While traveling to the dealer the car quickly overheated and issued a warning to turn the car off. Luckily I was only a half mile from home and not on the main highway yet so I did not have to deal with safety in traffic. Had the car towed to the dealer and they diagnosed coolant intrusion into cylinder 3 and that a new engine would be required to fix the car. Cost will be about $11k they quoted. I am recently retired so coming up with that amount of money is a big hit on our retirement savings. After consulting with my wife we decided we really did not have much choice but to replace the engine, given the cost of new vehicles and being on a fixed income to not create a car payment (this car was paid off two years ago). I did notice about a week before this incident happened that the car was low on coolant in the reservoir so I took it to the place I have the car serviced to top off the coolant. When they opened the reservoir the coolant returned to the bottle and showed full. I did not want to overfill it so I thought since it showed full, it must be normal on these newer engines. This had to be the beginning of the problem, wish Ford would have said something earlier so would have known what to watch out for. At any rate, I will be out of $11k to fix this problem that I am finding out Ford knew about. Ford should step up and take care of this since it apparently has been a problem for several years. We have been a Ford family for 40 years but not sure I can recommend them moving forward. Truly disappointed.