2018 Ford Escape: engine stalls while driving

Filed Oct 27, 2026 · Engine · PA

The vehicle is experiencing ongoing coolant loss with no visible external leak. The coolant level drops consistently and requires frequent refilling. The issue began around mid‑mileage and has continued to worsen. The engine sometimes emits a coolant smell, and the temperature gauge rises more quickly than normal. Warning messages about high engine temperature have appeared during driving. The dealer inspected the vehicle but could not find an external leak and stated the condition was normal, even though the coolant continues to disappear. No repairs have resolved the issue. Based on known problems with EcoBoost engines, an internal coolant leak or cylinder head defect is suspected, but the exact cause is UNKNOWN. This creates a safety risk because sudden overheating can occur while driving, which may lead to engine failure, loss of power, or stalling in traffic. The issue is ongoing and the vehicle is available for inspection upon request.

Filed Oct 12, 2026 · Electrical, Engine · TX

On approximately September 28, 2026, the vehicle began sputtering when first turned on. It then progressed to running extremely rough. On September 30, 2026 the Engine Icon lit up first. A few days later, I received an Engine Fault Service Now message. I went to the Auto Zone on October 4, 2026 and they ran a diagnostic check. These are the codes that were found: Check Engine Fail Replace Ignition Coil and Spark Plug #3 P0303 Cylinder 3 misfire detected P0339 Crankshaft Position Sensor A Circuit Intermittent P0300 Random misfire detected Cylinder 3 On October 5, 2026, I took it to my mechanic and he began checking everything. He found oil on and inside the computer. He also found that there was antifreeze residue on the Cylinder and Spark Plugs. He did some research to find out what could cause this to happen. He found the following: 1,134–1,711 engine complaints depending on dataset. Failures typically occur between 50,000 and 100,000 miles. Main Engine Problems 1. Coolant Intrusion (1.5L EcoBoost – Most Common & Severe) Coolant leaks past the block/head sealing surface into cylinders. Not a head gasket failure—requires short-block or long-block replacement. Symptoms: Misfire codes (P0300–P0304) White exhaust smoke Unexplained coolant loss Rough idle, stalling, overheating. 2. Cracked Engine Block Often the end result of prolonged coolant intrusion. Leads to catastrophic engine failure requiring full replacement. On Friday, October 9, 2026, I drove my car to work, approximately 2.5 miles, after the Escape sitting for 3.5 hours, I started it. I immediately received the HIGH ENGINE TEMPERATURE STOP SAFELY, and the engine shut off. On the 3rd try, the Escape stayed running. I could only drive 11 mph. On my final turn onto a busy street, the Escape began sputtering and would not accelerate at all. I was stuck in the middle of the street, putting myself at risk of being hit. I finally made it to a parking lot but had to be pushed home by my son.

Filed Oct 9, 2026 · Engine, Fuel system · KY

Failed Component/System: The engine assembly/engine cooling system. The internal structural failure of the cylinder block (open-deck design defect) allowing engine coolant intrusion into combustion chambers, cylinders 2/3. Safety: The vehicle is experiencing severe engine stalling, immediate loss of motive power on active roadways, dense white smoke from exhaust which blinds trailing traffic. This causes immediate risk for rear-end collision, leaves others with the possibility to be stranded on dangerous traffic situations. The vehicle leaks hot fluids into the combustions system putting everyone at risk for under hood fires. Has the Problem been confirmed: Yes, my vehicle is currently at the Pennyrile Ford Dealership, they performed a cooling system pressure test and borescope inspection, and confirmed internal coolant intrusion requiring a total engine replacement. They have even confirmed and acknowledged that this is an on going issue! Dealer inspection: Yes Warning Lamps/Messages: Check engine soon light, raised engine levels, rapidly depleting coolant within days of refill, rough idling, cold start rumblings, sweet chemical smell and thick white smoke coming from tailpipe. Ford has already admitted this is an ongoing issue with these systems, I currently have a 2.0 engine but the recall is for the 1.0/1.5.

Filed Oct 3, 2026 · Acceleration, Electrical · PA · crash

On September 4, 2026, at approximately 6:00 PM, I was driving my 2018 Ford Escape SE (1.5L EcoBoost) and executing a left-hand turn across an intersection. Mid-turn, the vehicle suddenly lost all power, an "Engine Fault" warning message illuminated on the dashboard, and the engine completely stalled out. Because the vehicle died directly in the path of oncoming traffic, I was forced to steer the coasting vehicle out of harm's way to avoid an imminent side-impact collision. This emergency maneuver caused the vehicle to scrape a curb—damaging the right tire rim—and collide with a utility pole. Fortunately, no injuries occurred. I managed to bring the vehicle to a stop on a side street. Once stopped, the vehicle exhibited a total "no crank, no start" condition and completely refused to turn over or restart. The vehicle had to be towed to a repair facility. Upon professional diagnostic inspection, the technician discovered extensive engine oil intrusion within the main engine wiring harness. Engine oil had dynamically wicked through the harness directly into the Powertrain Control Module (PCM), completely compromising and shorting out the primary computer. This electronic failure is what triggered the sudden, catastrophic engine shutdown mid-traffic. This vehicle has a chronic history of severe electrical, powertrain, and "no-start" defects at only 56,000 miles, despite being meticulously maintained with routine synthetic oil changes as required. This is the second time I have experienced a life-threatening loss of engine power while actively driving, and I am fortunate to have narrowly avoided a major, high-speed collision on both occasions. In July 2025, the throttle body failed and initiated a dangerous Limp Mode mid-traffic, forcing a tow for replacement. In July 2026, a starter failure resulted in another total "no crank, no start" condition during the holiday weekend, requiring an emergency mobile mechanic. Following this my car has sat for a month.

Filed Oct 2, 2026 · Engine · 94,000 miles · GA

The contact owns a 2018 Ford Escape. The contact stated that while driving 45 MPH, the head gasket of the engine cracked and the vehicle stalled. There was coolant leaking into the engine previously, and the vehicle was repaired. The vehicle was leaking coolant. There was white smoke coming from the tailpipe with a sweet odor during the failure. The vehicle was towed to the residence. The manufacturer was contacted by phone, where a case was opened. The contact was informed that there was no recall or manufacturer warranty on the vehicle. The dealer informed the contact that the engine needed to be replaced. A mobile mechanic diagnosed the vehicle and confirmed that the head gasket was cracked. The approximate failure mileage was 94,000.

Filed Sep 24, 2026 · Transmission · CT

Transmission suddenly failed causing vehicle to violently vibrate and stall. No warning lamp or check engine light. Vehicle has been repaired by independent repair shop by installing remanufactured transmission.

Filed Sep 14, 2026 · Engine · NC

My 2018 Ford Escape SE 1.5L EcoBoost is actively suffering from the manufacturer defect outlined in Ford TSB 19-2375 (coolant intrusion into the engine cylinders). The vehicle shakes violently on startup, emits heavy white smoke from the tailpipe, and displays an 'Engine Fault Service Now' warning. Because it is burning through coolant, this vehicle poses an immediate safety risk of sudden power loss, highway stalling, or catastrophic engine failure while driving. My job requires me to transport vulnerable medical patients, and this severe defect makes the vehicle entirely unsafe to operate on public roads.

Filed Sep 1, 2026 · Engine · IL

Engine light and cylinder four misfire code happened on Easter Sunday 4/5/26 while warming up in the driveway shuddered and stalled. I did not drive had vehicle towed to my mechanic the following day. Had vehicle towed 8/27 to the dealership where it was purchased (brand new 4/5/2019) at the recommendation of our mechanic due to the coolant intrusion and known defect. Was informed by the dealer today that i will need a new engine block with only 35,000 miles driven.

Filed Aug 24, 2026 · Engine · MI

I purchased my vehicle [XXX] from Suburban Chevrolet Cadillac in Ann Arbor, MI. Less than two weeks after purchasing the vehicle, my vehicle information screen informed me that the engine was overheating. My mechanic was able to replicate the issue and informed me I was the victim of a common issue with the 1.5L Ford EcoBoost Ford Escape engine that caused a coolant intrusion. I learned that Ford extended the factory warranty on the vehicle because of this issue, so they are clearly aware of it, but my vehicle was not under warranty when I purchased it used. The dealership told me they were unable to help me because I did not buy an extended warranty from them. Continuing to drive without repairing this issue could have resulted in severe engine damage, stalling, or complete mechanical failure, potentially endangering lives if it occurred while on the road. Because Ford has not issued a recall for this issue, I had to pay I had to pay $5,765.39 to replace the engine short block, inclusive of parts and labor, on top of what I paid for the car. The work was completed 11/23/2023. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 13, 2026 · Engine, Transmission · KY

Check engine light would come on vehicle was not running well, seemed to stall. When I turned off the car I could hear liquid moving around from inside the vehicle. I am a Mom so I am driving with my 2 small children constantly and worried about their safety. The problem was confirmed by the dealership as well as an independent service center.

Filed Aug 7, 2026 · Engine · MI

2018 Ford Escape equipped with EcoBoost engine suffering catastrophic engine failure due to the manufacturing defect known as open-deck coolant intrusion into the engine cylinders (per Ford TSB 22-2322). The vehicle has only 25,233 miles. This defect causes loss of power while operating the vehicle, creating an immediate traffic hazard and risk of a collision. The manufacturing flaw allows coolant to breach the cylinders, creating a stalling safety risk. Engine light is on. Ford dealer assessed and a new engine is recommended.

Filed Aug 7, 2026 · Engine · IL

Vehicle developed a pattern of misfires (cylinders 1, 2, and random/multiple) beginning within the last month. On 8/7/2026, a dealer inspection confirmed coolant intrusion into cylinders 1 and 2 via overnight pressure test, with block deformation. This is the identical defect addressed by Ford Customer Satisfaction Program 21N12. Prerequisite service 19B37 (PCM reprogram) was completed 2/8/2020. Misfires and coolant intrusion of this type present a risk of sudden power loss or stalling while driving.