2018 Ford Escape: fuel pump failure

Filed Oct 9, 2026 · Transmission · OR

At 56000 miles have had dealer replace transmission now dealer wants to replace the fuel pump even though the code reader says po0087 , a sensor this is the 2nd time this vehicle has had to be towed to the dealer. Now the dealer says he will just put the fuel pump back in not replacing it. Help !! They have had this vehicle to repair for approximatly 30 days

Filed Jul 24, 2025 · Fuel system · NC

Frequently (not all the time) the motor would shake after filling with the gas in tank when I start the engine and it stops pumping. So It needs to be turned back on and have to use the gas pedal to keep it running during neutral mode. Something is not right. It has to do with fuel pump system issue and engine light would be on when the problem comes.

Filed Jun 17, 2025 · Engine, Fuel system · 116,147 miles · AZ

The contact's daughter owns a 2018 Ford Escape. The contact stated that while her daughter was driving 60 MPH, the vehicle hesitated and shuddered. The vehicle failed to exceed 60 MPH. The check engine warning light was illuminated and flashing. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The vehicle was taken to an independent mechanic who determined that the failure was due to the fuel pump and fuel lines. The vehicle was repaired but the failure recurred. The vehicle was taken to the local dealer, who confirmed there was no recall coverage on the VIN. The vehicle was not diagnosed or repaired. The manufacturer was contacted and transferred the contact to the federal safety agency Hotline. The approximate failure mileage was 116,147.

Filed May 9, 2025 · Engine · 78,090 miles · IA

The contact's mother-in-law owns a 2018 Ford Escape. The contact stated that her mother-in-law had experienced a loss of motive power while driving at various speeds. The contact was informed that the check engine warning light was illuminated. The contact's mother-in-law had taken the vehicle to an independent mechanic who replaced the spark plugs, ignition coils, and fuel pump. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same mechanic who was able to diagnose that there was coolant intrusion into the engine. The mechanic referred the owner to a dealer for assistance. The dealer diagnosed the vehicle and confirmed that coolant had entered the cylinders and determined that the engine needed to be replaced. The vehicle was not repaired. The contact had researched online and related the failure to a known failure of the 2.0 liter engines. The manufacturer was informed of the failure. The failure mileage was 78,090.

Filed Apr 2, 2025 · Engine, Fuel system · 69,000 miles · MI

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and was unable to accelerate above 40 MPH. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the high-pressure fuel pump, resulting in damages to the camshaft. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the federal safety agency Hotline for assistance. The failure mileage was 69,000.

Filed Feb 28, 2025 · Engine · TX

I first started showing a check engine light for cylinder 2 misfire, and believed it was my spark plugs. Then, one singular day after the initial code, the car refused to start, took it to a local mechanic (as close as I could possibly tow it) and they replaced my fuel pump thinking that was the issue. They did not offer the service to repair a blown head gasket, but told me the white smoke coming from my exhaust indicated I might have a blown head gasket. Took it to another local mechanic who is a Marine motor transport mechanic (it was a friend so this was a free visit), changed my spark plugs hoping to repair the reoccurring cylinder 2 misfire, checked my exhaust and it is in fact a blown head gasket minimum due to the coolant coming completely out of my exhaust along with oil. This was all in the course of less than 150 miles and 7 days total including the three that my car was in the shop for the fuel pump. I have now taken it to the Ford service shop to get diagnosed, and through research, there has been a class-action lawsuit already launched for issues with this engine and the head gasket being blown time and time again under 100 thousand miles. My car has never overheated, but this issue can cause total engine failure, fires, and more. It's dangerous. It is a design flaw with the engine. The lawsuit is Miller et al. vs. Ford Motor Company. This is in regard to the 1.5 L Ecoboost (which is what I have). Alongside this, I'm a teacher, and I know multiple coworkers who have experienced the same exact issue. This is an extremely expensive and dangerous design flaw. If I had waited on it, the best case is the car dies, worse it catches fire and explodes on me.

Filed Dec 16, 2024 · Engine · MO

I bought the car in June of 2023 and 2 months later started having issues. Replaced the fuel pump, replaced the PTU, camshaft and now the engine needs replaced. Ford is aware of the engine issue but didn’t issue a recall only an extended warranty for 7 years/84,000 miles. I was not made aware of this problem at the time of purchase or receive any letter stating that. Had I known about the problem with those engines I never would have purchased the car.

Filed Jul 1, 2024 · Engine · NM

Vehicle ENGINE AND COOLING SYSTEM completely blown due to Coolant system flooding engine cylinders, from ZERO fault of the original vehicle owner, due to complete malfunction of the cooling system leaking into the engine components, requiring FULL COMPLETE engine /cooling system replacement at full cost to owner of CASH TOTAL : $12527.59. VIN : [XXX] [XXX] CUSTOMER STATES CEL IS PRESENT, WHILE DRIVING VEHICLE FELS Operation Tech units COMPLETELY OKAY 0.0 194 24.0 Amount 0.00 0.00 Amount 0.00 4656.00 51-1 LONG BLOCK + FLEXPLATE AND BOLTS + TURBO STUDS, NUTS AND THE GASKET+TURBO OIL SUPPLY TUBE ASSEMBLY +TURBO OIL RETURN TUBE AND GASKET THERMOSTAT HOUSING O-RING SEAL + OIL COOLER AND RETAINER+ FUEL INJECTOR ORING KIT + HIGH-PRESSURE FUEL PUMP O-RING SEAL +HIGH-PRESSURE FUEL TUBE+INTAKE MANIFOLD GASKET 51-2 TURBOCHARGER COOLANT TUBE ORRENG SEALS REGAE VACUUM PUMP GASKET+COOLANT OUTLET O-RING SEAL+. INSPECT VERIFIED CONCERN ECOTEST INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 17, 2024 · Engine · 48,000 miles · TN

The contact owns a 2018 Ford Escape. The contact stated while driving 30-70 MPH, the vehicle lost motive power while driving uphill. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who informed the contact that the fuel pump needed to be replaced. The vehicle was repaired, but the failure recurred. The mechanic informed the contact that the cam shaft and engine needed to be replaced. The contact called an unknown local dealer. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred to the federal safety agency Hotline, but no assistance was provided. The failure mileage was approximately 48,000.

Filed Apr 9, 2023 · Acceleration, Engine · WI

I had my adaptive cruise control on while driving on a highway and suddenly lost power/acceleration. I was able to limp the car back home and the check engine light came on. I took it in to get the error code read, which prompted that there was an issue with the high pressure fuel pump. I got that replaced by our normal service provider and picked up my vehicle. While driving the vehicle again (with adaptive cruise on), I lost acceleration/power. Since I wasn't in the area, I had the vehicle towed back to the service provider where the replaced fuel pump had "collapsed onto itself and broke", which luckily didn't cause serious injury. In this state, the service provider told me it was unsafe to drive. With the newest fuel pump, everything seemed fine for a few days in my daily travels. We were on our way to a vacation stay (highway speeds, adaptive cruise, driving for 2+ hours, etc.) when the issue presented itself again. This time when we returned to the service center, they stated that the engine had sludge which was causing the damage to the fuel pump and we would need to replace the engine. Since owning this vehicle, I have had it serviced as stated in the Ford service schedule (90,000 mile service, oil changes, etc.) and have always kept an eye on the temperature gauge. The fact that I have maintained this vehicle well and the engine now needs replacing doesn't seem to add up. I feel like there is a serious flaw with these engines and luckily, they didn't cause any accidents or harm in this instance.

Filed Feb 6, 2020 · Acceleration, Engine · 62,000 miles · OH

I had noticed coolant depleting finally got recall. Dealer reprograms now engine is just revving and looses all power to powertrain in multiple situation-3 from stop, 4 while going highway speed with constant speed prior each time the engine rev's up while giving no power. Then will spontaneously resolve within about 50ft then seems fine. I have video of the car doing this while I was attempting to get on the highway. We looked at oil and there is milk looking residue. The loosing power has only happened since reprogram for recall and now the cam shaft & high pressure fuel pump are destroyed per dealer this is my issue not recall related. Again these problems have only started within a week of the recall reprogramming of the vehicle