2018 Ford Escape: grinding or squealing brakes

Filed Feb 24, 2026 · Engine · MI

After realizing that my issue is not isolated; I decided to report it. I have a 2018 Ford Escape SE with a 1.5L ecoboost engine. From day one, the car had a "ticking" sound - which we were told was normal. Originally, it was leased. Due to Pandemic, there was a shortage of cars. Lease was extended 4 months x 2. Repair facilities not open during most of Pandemic/ we were not working/ so the car was driven about 5 miles/ week. Maintenance has always been kept up/ oil checked. Normal use pattern/ at/ less than 10 - 15 miles per day. Repeated problems with the engine light on. Immediate service. Each time, blame placed on a sensor or valve (more than once)/ hundreds of dollars in repairs. 8/2025 in for another engine light. Mileage 34,976. Code PO496 showed second failure/ purge valve and replaced again. 11/2025, same engine light issue. Mileage 41121 miles. FIRST TIME, the oil was found to be a bit low. VVT Selenoid tests/ negative. Codes indicated problem with the engine's variable valve timing, which can be caused by a faulty VVT solenoid or actuator, worn timing chain/ belt or a bad camshaft position sensor. The OBD-II code P0012 indicated that the intake camshaft position was 'overretarded' for bank 1. Alternator drive belt was replaced/ notes showing that this included R&I of engine mount, replacement Serpentine and V-belt/ belts. On 2/16/26 noticed the "ticking" sound had become louder. The engine light NOT on. Self oil check showed no loss/confirmed. Mileage 41851. Mechanic unable to diagnose noise source. 2/19, mechanic decided valve cover should be removed/interior examined. 2/20/26, Found "worn out cam bearing cap and worn out cam metal on metal grinding due to oil starvation. Recommend replacing engine." Told that the engine had been faulty all along. Ford Motor company will not discuss repair/ engine replacement. (estimate:10K+) After reading that this is a widespread problem for consumers; I felt that a report should be filed.

Filed Jun 26, 2025 · Engine · PA

My 2018 Ford Escape made a loud squeak / whistle sound while driving approx 40 mph. Immediately after, the vehicle began to smoke from the exhaust so much that I could not see , nor could many of the cars behind me. The check engine light came on and another light that said pull over. I brought the vehicle to my local Ford Dealer who said the engine has coolant intrusion in cylinder 2 and 3 , and requires a new engine block to be installed. Apparently, Ford is aware of this problem and had a customer satisfaction program to replace the faulty engine blocks, but it expired in 2022. I just purchased this vehicle from a Ford dealer 10 months ago , and now I am basically stuck with a repair that will cost me more than the vehicle is worth. I contacted Ford Motor Company and they will not help me.

Filed Mar 7, 2025 · Transmission · 80,000 miles · DC

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed and attempting the accelerate, the RPM increased quickly but the vehicle failed to accelerate as needed. The contact then heard an abnormal grinding noise coming from the engine compartment and the vehicle started to lose motive power, with the transmission slipping. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 22V413000 (Power Train), but the VIN was not included. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 80,000.

Filed Sep 30, 2024 · Transmission · 82,000 miles · FL

The contact owns a 2018 Ford Escape. The contact stated while driving approximately 65 MPH, the vehicle started losing motive power. The contact depressed the accelerator pedal; however, the vehicle failed to respond as needed. There was no warning light illuminated. The contact pulled over and turned off and restarted the vehicle, and the vehicle functioned normally. The contact stated that the failure had reoccurred. Additionally, the contact stated that the transmission was hesitating while shifting to the next gear, and occasionally slipped out of the intended gear while driving at various speeds. The contact stated there was an abnormal grinding sound coming from under the vehicle whenever the transmission slipped out of gear. There was no warning light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the coil packs and spark plugs needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken back to the same dealer however, the dealer was unable to repair the vehicle. The manufacturer was notified of the failure. The failure mileage was approximately 82,000.

Filed Sep 25, 2024 · Transmission · 37,800 miles · FL

The contact owns a 2018 Ford Escape. The contact stated while driving 20-30 MPH and depressing the accelerator pedal, the vehicle hesitated to respond, shuddered, and made an abnormal grinding sound. There was no warning light illuminated. The contact stated that the failure had been recurring while driving and exceeding 30 MPH. The contact related the failure to the federal safety agency Campaign Number: 22V413000 (Power Train). The recall repair was previously performed. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The dealer was notified of the failure and provided the contact with the cost for a diagnostic test. The vehicle was not diagnosed or repaired. The failure mileage was approximately 37,800.

Filed Jun 13, 2023 · Driver assistance, Transmission · PA

While driving at night at a speed of approximately 45 mph, the car started grinding and there was a smell of metallic material burning and it was difficult to accelerate. Within seconds the automobile came to a complete stop in the middle of a moderately traveled road in the left hand turning lane. There were no messages or warning lamps that would indicate that there was a problem prior to this complete stoppage. The safety of the driver as well as others is put at risk due to the fact that there were no prior indications or symptoms to this malfunction. Had this happened on a high traffic area while traveling at higher speed, there would have indeed been numerous accidents given the sudden stoppage without any safety lamps or alerts being exhibited on the dashboard that would alert the driver to get to a safer location or pull over. Waiting for a tow at night is dangerous and the safety of a lone driver is at stake. After three days at the dealer, we were advised that the vehicle has complete Transmission Failure. There is a safety recall (22S43) the federal safety agency 22V413 that deals with a transmission issue. The vehicle now needs a whole new transmission and is only 5 years old. Perhaps this initial recall may eventually lead to complete transmission failure. It was not described as what exactly the failure of the transmission.

Filed Apr 5, 2023 · Engine · 58,200 miles · WA

The contact owns a 2018 Ford Escape. The contact stated while driving approximately 60 MPH, the vehicle made a loud knocking sound. The vehicle was restarted, and the check engine warning light illuminated. Additionally, whenever the A/C was activated, there was a squealing sound coming from the vehicle. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer informed the contact that the warranty had expired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 58,200.

Filed Aug 3, 2020 · 42,000 miles · NM

Most of the time that I start the vehicle it makes a squealing sound, it only lasts as long as I am in park or if I am in reverse. Once I put the vehicle into drive the sound stops. I have taken the vehicle into the dealership on more than one occasion and I have even recorded the sound but I have been told that there is no noise. Another issue that I have had is a foul odor coming from the vents. It originally started during the winter months, then continued through the summer. This happens every time that I turn on the heater and sometimes when I turn on the AC. I have taken it to the dealership and one mechanic did smell it but they couldn't find anything wrong with it so they put a cherry scent in it and gave it back to me. If I need the heater on I have to drive around with a window open to keep from smelling the bad odor of burnt hair/harsh chemical. Both of these happen while the vehicle is stationary and in motion. I dropped my car off on 2/20/20