2022 Ford Explorer: sudden loss of power

Filed Sep 11, 2026 · Fuel system · 66,000 miles · FL

The contact owns a 2022 Ford Explorer. The contact stated that while his wife was driving 10 MPH with children inside the vehicle, while depressing the accelerator pedal, the vehicle hesitated and loss power. While attempting to restart the vehicle, the vehicle failed to respond. A dealer was contacted. No warning light was illuminated. The vehicle was towed to a dealer where it was diagnosed and determined that the fuel pump needed to be replaced. The vehicle was not repaired. The contact associated the failure with the federal safety agency Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The vehicle was repaired. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure and informed the contact that a representative would return the phone call. The approximate failure mileage was 66,000.

Filed Jun 29, 2026 · Fuel system · VA · 1 injury

On [XXX], at approximately [XXX] PM, my 2022 Ford Explorer suddenly lost power while driving in the left lane of [XXX] in Emporia, VA, at 70 MPH (the posted speed limit), with my [XXX] daughter. My vehicle shuddered and started to decrease in speed. I was able to maneuver safely to the shoulder, and my Explorer became inoperable requiring roadside assistance. My daughter and I remained on [XXX] for several hours due to delayed tow service availability. My Explorer has been at Battlefield Ford in Culpeper, VA since June 19, 2026, and is available for inspection upon request. Battlefield has confirmed the low-pressure fuel pump failure, confirmed this is subject to Safety Recall 25S75 (the federal safety agency Recall 25V455), and there is no remedy available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 29, 2026 · Transmission · GA

Powertrain System Fault will cause the vehicle to lose power possibly leaving the vehicle and passengers in danger if crossing traffic, pulling onto a road, etc.

Filed Feb 15, 2026 · Fuel system · CA

Component/System: Low-pressure fuel pump/fuel delivery system related to Recall 25S75. Vehicle is a 2022 Ford Explorer Hybrid. Description: My vehicle is subject to Recall 25S75 involving the low-pressure fuel pump that can cause loss of fuel pressure and engine stalling. The vehicle has stalled six times between about 15,000 and 35,000 miles. The issue is intermittent but ongoing. The vehicle is available for inspection. What failed or malfunctioned: The fuel delivery system appears to lose pressure consistent with Recall 25S75, leading to engine stalling and temporary inability to restart. Safety risk: One stall occurred while driving on a highway on 9/30/23 at about 15,000 miles. The engine lost power without warning and I had to coast to a gas station. Sudden loss of propulsion in traffic creates a serious crash risk. Other stalls happened in driveways or parking lots after the vehicle had been running. In several cases the vehicle would not restart for 20–60 minutes, which could be dangerous if it occurred in traffic or an unsafe location. Reproduction or dealer confirmation: Two incidents required towing to Ford dealerships. The vehicle has been taken to Ford dealers multiple times. Earlier incidents were not linked to a recall at the time. Now that Recall 25S75 has been issued, the symptoms match. Ford has not repaired it because the remedy is still under development and parts are unavailable. Inspections: The vehicle has been inspected by Ford dealerships and towed twice by AAA for diagnosis. No permanent fix has been made because the recall remedy is not yet available. Warnings or symptoms: Stalls often occurred after the vehicle had been running. The vehicle then would not restart for 20–60 minutes. In one event there were dashboard errors. There was not always a clear warning before a stall. Reason for complaint: The recall has been open since July 2025 with no remedy available. The vehicle continues to stall. I do not feel it is safe to operate.

Filed Nov 11, 2025 · Engine, Fuel system · TX

Ford Explorer Recall – Ongoing Safety Hazard In July 2025, Ford issued a recall notice for my vehicle. Shortly after, the check engine light came on. Starting October 15, 2025, my vehicle began failing to start after refueling—making noise and taking multiple attempts to start. The same issue occurred repeatedly on October 23 and October 30, worsening each time. On November 3, we brought the car to a Ford dealership. They confirmed there is no available fix for the recall and said there’s “nothing they can do.” I explained this was a safety issue since I drive my son with a disability to therapy daily. They told me I would have to pay out of pocket for repairs even though the problem is linked to the recall. On November 8, while driving in Arizona, my vehicle again failed to start after refueling. Later that day, it lost power on the road, the speed dropped suddenly, and it would not accelerate. The same stalling and jerking occurred again on November 10 while my husband was driving. We contacted Ford Corporate and the federal safety agency, but both said nothing could be done because the recall label says the car is “still drivable.” This is inaccurate and dangerous. The car stalls and loses acceleration randomly, creating a serious risk of an accident. On November 21, the car again failed to start after refueling. This has happened multiple times each week, and Ford continues to delay a fix. My vehicle is unsafe to drive, and this unresolved recall poses an ongoing safety hazard to my family and others on the road.

Filed Apr 22, 2025 · Steering · CO

Driver assist warning light comes on and I lose power steering on my ford. I took the vehicle in last month for repair. Dealer said it was a software issue. Rest the software. This did not fix issue. I was driving on highway at 65 miles when steering assist message popped up and I lost my power steering. This a major safety issue. I checked on line and other drivers had reported the same issue. Please advise.

Filed Nov 8, 2024 · Engine · 177,175 miles · CA

On 10/28/2024 at approximately 0515 I was traveling at 51 MPH when my 2022 Ford Explorer King Ranch edition with ~25k miles experienced catastrophic engine failure. The vehicle had no prior indication of failure. No engine light, no warning lights, etc. The vehicle started shaking violently and lost all power. I was able to safely pull to the shoulder of a two-lane road. The vehicle was completely dead and would not start. I am not sure if there was oil or anything leaking as it was dark outside. I called a tow truck and had the car taken to the Ford dealership. After initial inspection, the dealership moved the car to the "heavy maintenance" part of the service department. After a few days, I called to find out what they found and was informed the engine had "thrown a rod" and the entire engine would have to be replaced. After a week and a half, I called back and was told they are still disassembling the engine and their next step will be to submit a "cost cap" to Ford for permission to replace the engine. After researching the issue online, I came across the Safety recall 24V‑598 on engine failures in the 3.3L size engine, typically only on police interceptor versions of the Ford Explorer. The information in the recall sounded exactly like what happened to my explorer but was told by the dealer the 3.0L engines were not affected and they had never seen one fail like this. I truly believe the 3.0L engine sizes are affected and the recall should be expanded to include this version of the explorer. I was lucky that I was able to safely drift to the side of the road, however, others may not be that lucky.

Filed Apr 12, 2024 · Engine · FL

I was driving down the highway and my vehicle suddenly lost power and the motor blew up.

Filed Sep 6, 2023 · Driver assistance, Electrical · CA

While merging on to the freeway, while trying to achieve freeway speed, the Explorer lost all power for about 10 seconds. During that time, multiple error messages appeared on my dashboard. The messages included "Pre-Collision Assist Not Available" and "See Manual". Several Error message were sent to my FordPass app. The messages include: 1."Service Engine Soon Warning - The powertrain control system speed sensors have detected the transmission did not achieve the gear expected and may be slipping internally..." 2."Service Engine Soon Warning - The powertrain control system has detected an internal PCM communication error. The PCM will invoked failure mode effects management (FMEM) operating strategy that maintains limited vehicle function..." 3."Pre- Collision Assist Not Available - The collision warning system has detected either a fault or an obstructed radar sensor". 4. "Powertrain Malfunction/Reduced Power - Illuminates when the system has detected a powertrain or a four-wheel drive fault. I was almost rear ended because I could not achieve freeway speed while merging onto the freeway. The vehicle has been at the dealership for 3 days. I am still waiting to find out what the diagnosis is.

Filed Aug 3, 2023 · Wheels · IL

Vehicle rear axles click when you place vehicle in reverse and drive this is the cv axles breaking eventually leading to power loss.

Filed Jun 14, 2023 · Transmission · 26,000 miles · OR

The contact owns a 2022 Ford Explorer. The contact stated while driving approximately 55 MPH and ascending an incline, the transmission slipped out of gear, and the vehicle started to lose motive power. The contact stated that the “Pre-Collision Assist Unavailable” and “Powertrain Malfunction/Reduced Power” warning lights were illuminated. The contact stated that the vehicle would rev when the accelerator pedal was depressed; however, the vehicle failed to respond. The contact was able to return to the original destination however, the vehicle had to be restarted for the vehicle to operate as needed. The contact had not taken the vehicle to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 26,000.

Filed Jan 7, 2023 · Transmission · AZ

While driving uphill on freeway the Ford Explorer lost all power going about 60mph. The warning of a wrench symbol came on indicating power train malfunction. Our mileage was at only 665 and after 10pm. Thankfully there was an adequate shoulder to pull off the road. It was not duplicated in the dealership. Turning off the power reset everything but now the dealership is replacing the entire transmission per Ford motor company. There was a burning smell but wasn’t positive it was coming from the Explorer or a fire nearby.