The right rear passenger door of my 2021 Ford Explorer ST repeatedly becomes unlatched and physically opens while the vehicle is in motion, including at highway speeds of approximately 72 mph. This occurs almost every time the vehicle is driven and creates a serious safety hazard. The door visibly separates from the vehicle’s body, which I can see in the passenger-side mirror. When this occurs, the dashboard displays a door-ajar warning, the interior lights illuminate, and wind can be heard entering through the opening. This is not simply a faulty warning indicator. The door is physically opening while the vehicle is moving. I am extremely concerned about the risk of the door opening farther and potentially causing a passenger, particularly a child seated in the rear, to be seriously injured or ejected from the vehicle. This defect was present before the vehicle was taken to Tipton Ford in April 2026. I also recall that that when I originally purchased the vehicle, the child safety lock was engaged on the right rear passenger door only. I found this unusual at the time, and given the ongoing malfunction involving that same door, I am concerned the issue may have existed before my purchase. Tipton retained the vehicle for approximately one month and completed repairs on May 8, 2026. However, the repair documentation indicates that the LEFT rear door latch assembly was replaced, while the RIGHT rear passenger door has consistently been the door physically opening. The dealership documented reproducing an intermittent door-ajar warning and replacing the left rear latch assembly. However, the original right rear door malfunction remains unresolved. The cause of the right rear door malfunction remains unknown. The vehicle is available for inspection. I am requesting an investigation into this potentially dangerous door-latching defect before it results in serious injury or death.
Ford Explorer door locks problems
353 of the 34,647 owner complaints about the Ford Explorer describe doors won't lock, open or latch, most of them for the 1998 model year.
- owner complaints
- 353
- worst model year
- 1998
- typical repair cost reported
- $500
- typical mileage
- 78,000
By model year
Often reported together
Key fob 10Fire or smoke 9Wipers 7Airbag light 7Seat belt 4Headlights 4Coil spring 4Stalling 3
What owners say
the rear passenger door flew open while I was driving on a public road, with absolutely no warning or dashboard alert to indicate it was unlatched
The contact owns a 2019 Ford Explorer. The contact stated that while the vehicle was parked, the message "Right Rear Door Ajar" was displayed. The contact moved the rear passenger’s side door latch several times and was able to fix the failure. However, the failure recurred. The contact was concerned that the failure would drain the battery.
The chrome overlay on the driver side interior door handle is chipping and caused an injury to my finger. The chipped chrome broke off and became wedged in my skin and also resulted in a 0.5in scratch. The injury was extremely painful and required medical attention to remove the broken chrome chip that was lodged in my finger.
The driver side door latch is defective. I’ve often been locked in or out of my vehicle. Obviously the main door on the vehicle. Many times i have to climb over the center console to exit my vehicle. What if I’m in an accident or my car catches fire, I can’t get out. Leaving me trapped. Or if I’m in danger and need to get in my car but I’m locked out. Often since latch doesn’t function it doesn’t shut my automatic lights off potentially wearing down the battery. Pretty sure my insurance company would not be happy that they are insuring a vehicle with these dangers and potential for someone to enter my vehicle when it decides to not lock. I’ve been told the vehicle is not part of a recall and the vehicle part is on a national backorder with no ETA. Dealership contacted me recently stating part was in, lost a whole day of work to find out they ordered the wrong part and the part is still not available. I bought this vehicle used off of a lease program only a year ago with 42,000 miles and have only put less that 10,000 miles on it. Transmission issues but dealership says they can’t find anything wrong. Car jerks and makes wining grinding noises when first taking off. I find it hard to believe ford does not think this is s safety issue with driver being trapped in or locked out of vehicle.
The contact owns a 2016 Ford Explorer. The contact stated that while the vehicle was parked and occupied, while attempting to open the driver’s side door with the door handle, the door failed to respond as needed. However, when the button was pushed to unlock the vehicle, the door responded as intended. The contact stated that the driver’s side window failed to operate as needed. Neither an independent mechanic nor a dealer was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 98,331.
The drivers side door latch mechanism malfunctions and causes the door to unlatch or does not allow the door to latch. This is a safety hazard. I know two other ford owners with vehicles after 2021 that is having this same issue. This calls for a recall!
Interior driver door handle - coating is metal, it partially peeled off. Several times it has cut my finger when I open the door (paper type cut). Due to fast paced life, I forget to open door is a way to avoid the metal flake and tend to always cut my finger which is scary if I touched it when vehicle was in motion, there is a quick second of shock/pain from cut. Ford has this common problem as we had the window openers replaced when it was warrantied, same issue. I think it's a safety issue and should be replaced by Ford. They want to charge me over $300 for the repair, I'm not going to give them the satisfaction. Driver side is more affected because it is used 3x as much and other doors.
I was pulling into my apartment division I heard a loud pop and the vehicle then died. I tried starting it back up and it then caught on fire. My door locks were stuck in the locked position and I could not get them to unlock. Within a few seconds (which felt like several minutes) the doors did unlock and I was able to get out. There were no warning lights or messages prior to this. Fire department did arrive and put out the fire. The car was a total loss. Report has been filed with insurance company. I purchased this car from BX Fort Myers LLC. I just purchased this vehicle from them and had for a total of 32 days. I did purchase the 12 month/12,000 mile extended warranty. I also purchased Gap insurance and informed them of what had happened. The one GM gave me a loaner for a week, got in trouble for giving me one and got demoted. the new GM said "definitely not" will not give me a loaner. I drive over an hour daily for my job and do need a vehicle.
Door handle chrome plating is peeling off. Finger cut when opening the car door. Chrome tips on window buttons had already been recalled for the same reason, but the door handles were not included in this recall. Attached picture of finger was 7 days later.
Related recalls
Latches/locks/linkages
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2013 Ford Explorer, Taurus, and Lincoln MKS vehicles manufactured November 29, 2012, through December 12, 2012. In the affected vehicles, with sufficient door openings and closings, the child safety locks may change from an activated position to a deactivated position without notice.
- Risk
- If the child lock is deactivated, the door could be unlocked and opened from the inside which could lead to personal injury to an unrestrained child.
- Remedy
- Ford will notify owners, and dealers will test the safety locks. If necessary, the locks will be replaced free of charge. The recall began on August 2, 2013. Ford's recall number is 13S07. Owners may contact the Ford customer relationship center at 1‑866‑436‑7332.
Recall number 13V270000 · Recall details
Latches/locks/linkages: hood: latch
- What is wrong
- Vehicle description: sport utility vehicles. The secondary hood latch may corrode at the latch pivot and stick in the open position.
- Risk
- If this occurs and the primary hood latch is either not engaged or is released, a hood fly-up could occur.
- Remedy
- Dealers will install a secondary hood latch with components that are coated prior to assembly for improved latch pivot corrosion protection.
Recall number 99V164000 · Recall details
Latches/locks/linkages: doors: latch
- What is wrong
- When in the secondary latched position, the driver door latches may open when subjected to transverse loads less than that specified in fmvss no. 206, "door locks and door retention components."
- Risk
- The driver's door, when closed only to the secondary latched position, may not sustain a 1,000 pound transverse load.
- Remedy
- Dealers will inspect and, if necessary, replace the driver door latch.
Recall number 96V070000 · Recall details
Questions about the Ford Explorer door locks
Which Ford Explorer years have doors won't lock, open or latch problems?
The model years with the most reports are 1998 (41 complaints), 2013 (38 complaints) and 1996 (35 complaints).
How much does it cost to fix doors won't lock, open or latch on the Ford Explorer?
Owners who mentioned a price put the repair at about $500 (median of 19 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history