As I was backing my 2013 Ford Explorer Base model out of my garage I heard a pop and then my steering started making a grinding/dragging noise. When I pulled onto the street I noticed that my steering wheel would "stick". I went a short distance further down the road and it seemed to stop sticking. When I went around a curve towards the left, my steering stuck again and it was harder to get it to "unstick". I returned it back to my home and parked it back in the garage. I see that there is a recall for the steering on the 2013 models, but my VIN is NOT included in this recall. This is a huge safety hazard and could put me out of work, as I care for and transport autistic individuals. This vehicle and my job are my livelihood and this needs to be corrected/recall issued on all of the 2013 models since they all seem to be having similar steering issues. Vehicle has not yet been inspected. Vehicle is available for inspection on request.
Ford Explorer steering noise problems
169 of the 34,654 owner complaints about the Ford Explorer describe clunking or noise when steering, most of them for the 2016 model year.
- owner complaints
- 169
- worst model year
- 2016
- typical repair cost reported
- $2,500
- typical mileage
- 59,900
By model year
Often reported together
Grinding brakes 37Power steering loss 23Harsh shifting 20Steering lock-up 12Loss of power 11Jerking 9Knocking 9Ball joint 8
What owners say
Steering is difficult and makes noises when turning
1. What component or system failed or malfunctioned, and is it available for inspection upon request? The Electronic Steering Gear failed causing the steering to "stick" at certain points of steering, and causing a loud rubbing noise. The steering is also more "loose" and feels insecure. Yes it is available for inspection. 2. How was your safety or the safety of others put at risk? The failure of the electronic steering gear can cause unexpected failure of steering ability while operating the vehicle. This could cause a severe accident going any speed, but especially if I were on the highway. A crash due to loss of steering ability could kill me, my family, and others on the road. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, my local Ford dealership has confirmed the issue and stated that they won't repair it because it isn't part of any open recall, even though there was a major recall (14S06/the federal safety agency 14V‑286) opened for the prior model year of my vehicle. Ford should have included 2014 in that recall since the issues persists in 2014 models and is evident by the other 200+ Technical Service Bulletins posted by Ford. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It's been inspected by my local Ford dealership. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lamps or messages. I noticed the issue after picking the vehicle up from the Ford dealership. They didn't notice the issue until I reported it to them, meaning they missed it during their maintenance inspections and check-up. I noticed the issue on September 21, 2025.
Clunking noise coming from rear possible tow link, clicking noise coming from steering even when vehicle not moving
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, while attempting to make a left or right turn, there was a popping sound coming from the steering wheel. Additionally, while driving on the highway at 70 MPH, the vehicle failed to exceed 70 MPH. The contact stated that there was an abnormal burning odor entering the cabin of the vehicle with the TPMS warning light illuminated. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 121,000.
The contact owns a 2017 Ford Explorer. The contact stated that the passenger’s side the A-pillar applique trim had a split in the middle causing rainwater and dirt to enter the vehicle. As a result of the failure, the sunroof motor was damaged and then failed to operate. The local dealer was called, and the contact was made aware of the federal safety agency Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not available. On another occasion, while driving at various speeds, while making a left or right turn there was an abnormal clicking sound coming from the steering. The contact stated that the failure progressively worsened when turning to the right. The vehicle was taken back to the same dealer where it was diagnosed that the A-pillar applique trim was not likely the reason for the failure of the sunroof motor and that a 2-hour diagnostic test needed to be completed to determine the cause of the failure; however, the repair would be paid out of pocket. The contact was reminded that the A- Pillar applique trim part was still not available. The contact was informed that the clock spring had failed and needed to be immediately replaced. The vehicle was not repaired and remained with the dealer. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
Steering noise. Steering will randomly lock up or extremely difficult to gain control. My car is a 2014 Ford Explorer bought new. 2011-13 & 2015-16 have recalls for steering issues realted to same symptoms and safety risk. Ford will not recall or procide cistomer care for this known safety risk for 2014 models.
The electric powered steering was making scraping-clicking noise when turning to the right. The steering rack over-extension stop came apart inside the rack enclosure. This can result in a tire scraping on metal parts inside the fender enclosure. I have 46,000 miles on this Explorer and I drive conservatively. I have learned that Ford vehicles have issues with these steering units and this part including labor is extremely expensive. Due to the safety factors I believe a recall repair or replacement for this part is in order.
I had just pulled out of my driveway when I heard a "clunk" and the power steering seized up. Dash lights indicated "Steering Asist Fault Service Required" and "Service Advance Trac". I had to drive around the block (pulling very hard on steering wheel) to get it back in my driveway. It was frightening not having full control of the car. There is a Recall for Ford Explorer Steering Issues (the federal safety agency CAMPAIGN NUMBER: 14V286000 and the federal safety agency CAMPAIGN# 21V537000) "Cross axis ball joint to seize" but my VIN is not in the recall but should be. This is a SERIOUS SAFETY ISSUE that needs to be addressed by Ford Manufacturing.
Steering wheel stated making weird noise when turning. Got harder to steer and started jerking while driving. The explorer jerked from side to side and almost caused me multiple wrecks. I took it to the shop and it was my steering rack and pinion that needed replacing and may also have to be reprogrammed, which is an extra $600.00. I have had several cars and never had an issue like this! Not to mention it was almost $3000.00 fix. There were no warning lights for this and this is very dangerous especially since it happens so fast and could be deadly on the interstate! This needs to be recalled, there are many owners I read have had this problem. It is unacceptable and deadly! Not safe!
Related recalls
Steering
- What is wrong
- Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.
- Risk
- If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.
- Remedy
- Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1‑866‑436‑7332. Ford's number for this recall is 17S23.
Recall number 17V530000 · Recall details
Steering: electric power assist system
- What is wrong
- Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
- Risk
- If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
- Remedy
- Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1‑800‑392‑3673. Ford's number for this recall is 14S06.
Recall number 14V286000 · Recall details
Steering
- What is wrong
- On certain sport utility vehicles, the two bolts that attach the steering gear assembly to the frame may have been over-tightened. This condition could result in one or both of the bolts fracturing, causing the steering gear to become loose.
- Risk
- This condition could cause "clunking" noise when steering as well as decreased steering effectiveness potentially resulting in a crash.
- Remedy
- Dealers will replace both the steering gear assembly mounting bolts and nuts free of charge. The recall began on april 27, 2007. Owners may contact ford at 1‑800‑392‑3673.
Recall number 07V181000 · Recall details
Steering: linkages: tie rod assembly
- What is wrong
- The inner tie rod assemblies were improperly manufactured and can fracture causing shaking or shimmy at low speeds.
- Risk
- This condition can cause the wheel on the side with the broken tie rod to tuck inward or outward and slide resulting in an increased potential for a vehicle accident.
- Remedy
- Dealers will inspect the inner tie rods and replace the suspect tie rods.
Recall number 95V053000 · Recall details
Questions about the Ford Explorer steering noise
Which Ford Explorer years have clunking or noise when steering problems?
The model years with the most reports are 2016 (55 complaints), 2015 (36 complaints) and 2013 (21 complaints).
How much does it cost to fix clunking or noise when steering on the Ford Explorer?
Owners who mentioned a price put the repair at about $2,500 (median of 24 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ford Explorer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history