2000 Jeep Grand Cherokee problems

What is wrong

On certain sport utility vehicles, the plastic blades of the electric motor driven cooling fan may separate and penetrate the shroud.

Risk

If this occurs while the hood is open, a person in the vicinity of the engine could be struck by the blade and injured.

Remedy

Dealers will replace the electric cooling fan modules free of charge. The recall began on september 4, 2006. Owners may contact daimlerchrysler at 1‑800‑853‑1403.

Recall number 06V199000 · Recall details

What is wrong

On certain sport utility vehicles equipped with a 4.0l engine only, the design of the intake and exhaust manifolds could allow debris to accumulate at the #3 cylinder location.

Risk

This could result in a vehicle fire.

Remedy

Dealers will install a manifold shield to modify the air flow characteristics and to prevent the accumulation of debris in the area of the #3 cylinder. Owner notification began may 13, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1‑800‑853‑1403.

Recall number 02V104000 · Recall details

What is wrong

Vehicle description: sport utility vehicles. Some of these vehicles may have been built with fuel tanks with suspect vent tube welds.

Risk

Separation of the vent tube weld could result in a fuel leak. Fuel leakage in the presence of an ignition source could result in a fire.

Remedy

Dealers will replace any fuel tanks built in the suspect time period. The vehicle will be inspected and if the bar code on the fuel tank indicates that the tank was built during the suspect period, it will be replaced.

Recall number 00V195000 · Recall details

What is wrong

Vehicle description: passenger vehicles. The seat belt shoulder height adjustable turning loop (atl) top mounting bolt was inadequately manufactured.

Risk

The affected mounting bolts may not withstand sufficient force to function properly in certain impact situations, increasing the risk of injury to a belted occupant.

Remedy

Dealers will replace the shoulder belt height adjuster mounting bolts.

Recall number 00V034000 · Recall details

What is wrong

Vehicle description: passenger and sport utility vehicles. The passenger air bag inflator assembly contains an incorrect inflator charge amount.

Risk

This condition could increase the risk of a passenger occupant injury under certain accident conditions.

Remedy

Dealers will replace the air bag module with a correct module.

Recall number 99V343000 · Recall details

What is wrong

Vehicle description: sport utility vehicles. Some steering gear units were assembled with internal end-of-travel-stops that missed the heat treat process, resulting in soft internal travel stops.

Risk

This could result in sticking, binding, or seizing of the steering gear.

Remedy

Dealers will replace the steering gear on involved vehicles.

Recall number 99V312000 · Recall details

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise the federal safety agency might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V‑252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.the federal safety agency's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

EA12005

the federal safety agency has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. the federal safety agency's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.the federal safety agency has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.the federal safety agency.dot.gov/owners/Searchreference under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

PE10031

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned the federal safety agency to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from the federal safety agency's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

DP09005

Daimlerchrysler corporation (dcc) has notified the agency that it will conduct a safety recall (06v199) of certain jeep grand cherokee vehicles to replace the engine's electric motor driven cooling fan. The 182,875 vehicles included in the recall are model year (my) 2002 equipped with 4.0 liter (six cylinder) engines manufactured from february 4, 2002 through june 17, 2002; and my 2000 equipped with either the 4.0 liter (six cylinder) or the 4.7 liter (eight cylinder) engine manufactured from january 31, 2000 through june 12, 2000.dcc noted that their analysis of failed parts showed evidence of brittle fracture of the fan blade.dcc further stated, poor bonding between the resin material and the glass fibers was observed, which may be attributed to the injection molding process. Since the root cause of fan failure could not be conclusively identified dcc decided the recall scope would be determined by the build date range of the complaint vehicles.there were 48 reports for my 2000, and 196 for my 2002.odi will continue to monitor this issue for reports on vehicles outside of the recall scope.

EA05020

Daimlerchrysler has recalled the zj models to incorporate a secondary detent spring into the shifter.even though the wj 6 cyl. Vehicles use the same manual detent lever that as the vehicles in the recall population, odi believes that the wj redesigned shifter, which improves floor shifter functionality and ergonomics, helps to provide feedback to the driver to indicate whether ?park? Has or has not been achieved.although the investigator was able to induce a ?false park? In the wj platform for 6 cyl. Vehicles, the level of difficulty was greater than that required for all zj models, and the complaint rate was significantly lower than the recalled zj population.further, the odi investigator was also able to create a ?false park? In peer vehicles with the same level of difficulty and frequency as the subject vehicle wj platform.the wj complaint rate was inflated due to national exposure through the press. The complaint rate prier to the july 5, 2001 media coverage for the wj vehicles is similar to the peer vehicle incident rate.based on the above, a safety-related defect trend has not been identified at this time in the wj population.accordingly, this investigation is closed with a safety recal for the zj platform only.

EA01017