2017 Ram 1500: fuel pump failure

Filed Aug 10, 2026 · Fuel system · TX

while driving on the highway at 75mph, the pickup engine completely lost power and died. we could not restart the engine. Eventually we were able to put it in neutral and pull it off of the highway with another pickup. The Z46 recall for the high-pressure fuel pump was replaced the prior month. the dealer diagnosis is faulty fuel injectors now

Filed Mar 20, 2026 · Fuel system, Steering · MN

1Rear end shifted to passenger side 3 in 2. The intermittent shaft made the steering wheel over turn over half a turn. 3 manifold bolts replaced but snapped again. Fuel pump went out. Tailgate has opened multiple times. 120 k seems unfit to drive wheel studs drivers rear broke off 1 by 1 till there were 2 left

Filed Jan 8, 2026 · Fuel system · NC

In November 2025, while traveling at highway speeds, the High-Pressure Fuel Pump (HPFP)—the very component installed to satisfy the Z46 recall—suffered a catastrophic failure. This resulted in an immediate loss of fuel pressure, smoke, and a total engine stall. The failure caused a loss of power steering and braking assistance, creating a severe safety hazard on an active interstate.The vehicle has been at the RAM dealership for over one month waiting on parts for repair.

Filed Aug 20, 2025 · Driver assistance, Engine · NE

Unknown. We have owned this vehicle for almost 3 years now and we have had to replace 2 sensors, the cruise control will intermittently no disengage when buttons are pushed or brake pushed, replaced the full pump, sometimes it will lose all power going down the road, HD to replace the fuse box because it was getting and started to melt, it will try to start and will just keep cranking until you slam on the gas, and the rear window leaks every time it rains. We have paid for everything out of pocket and we are still having all these problems and the mechanics can not figure out the problem,but are guessing it the fuel pump or fuel injectors.

Filed Jul 8, 2024 · Fuel system · TX

I was driving my truck and out of no where started to lose speed, pulled over immediately and lost all power. I didn’t drive my truck anymore because I noticed a knocking noise when I was able to get it back on. I contacted mopar and was advised to take in my truck for open recalls because of the High pressure fuel pump seemed to be exactly what happened to my ram. I took in my truck for the recalls, was called three days later and told I needed to replace all 6 fuel injectors costing me $5000.00, recall states high pressure fuel pump has to be replaced along with any damaged fuel components. Dealer tells me high pressure fuel pump was not broken. I know it was failing because of what happened to my ram.

Filed Mar 14, 2024 · Engine, Fuel system · 55,000 miles · ID

The contact owns a 2017 Ram 1500. The contact received notification of the federal safety agency Campaign Number: 22V406000 (Fuel System, Diesel) and the federal safety agency Campaign Number: 23V411000 (Engine and Engine Cooling) however, the parts to do the repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving at approximately 75 MPH, the vehicle stalled. The contact stated that the "engine" symbol illuminated, and the vehicle was able to coast to the side of the road. The contact was unable to restart the vehicle after numerous attempts and had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the High-Pressure Fuel Pump had failed, but the dealer did not have the parts available to repair the vehicle. The vehicle was not repaired. The failure mileage was approximately 55,000. Parts distribution disconnect.

Filed Mar 12, 2024 · Fuel system · FL

A recall was received in June, 2022, regarding High Pressure Fuel Pump failing prematurely. “Fuel starvation may result in an unexpected loss of motive power, which can cause a vehicle to crash without prior warning.”No remedy was available. Today I received another recall notice for the same issue which said to schedule my free repair. I called my dealership at Winter Haven Dodge and was told they were only allowed to order 1 part per month and they had 15 vehicles ahead of me and he will schedule my repair on my turn. I feel that15 months is an unreasonable length of time to wait since I have been waiting for resolution of this matter since June, 2022.

Filed Dec 1, 2023 · Fuel system · CO

The fuel pump quit working, which immediately made the engine die. I was on a two lane road and there was no place to get off the road. There was no prior warning of the issue and there apparently have been no recalls, even though, Ram is very aware of the problem and and in some cases the engines have been damaged due to pieces of metal from the fuel pump getting into the engine. I know of other people who have had the same issue with gas powered Ram trucks and there is a lot of information on the internet. In addition to the safety issues that this creates, I had to pay to a portion of the cost to replace the pump. Part of the expense was covered by an extended warrantee. The truck only had about 47,000 miles on it when the pump failed and apparently that is about average for the failure. Ram should have to recall these units and foot the expense to avoid having dead vehicles in traffic lanes

Filed Aug 29, 2023 · Acceleration, Brakes · CA

Driving approx. 45 mph when truck lost acceleration. Truck began making clanking sound and check engine light came on and electronic throttle control light. Almost got into an accident due to someone almost rear ending me and then had to coast into a parking lot when I lost total control of all steering and almost hit a parked car. Truck would not restart, had to call for a tow back home that was 150+ miles because no dealerships close by would accept vehicle or had availability. Truck taken to local Dodge dealership and diagnosed with high pressure fuel pump failure and the eta for parts for a fix are unknown at the time. Have been without a truck or car for 2 weeks now, have 4 kids and both me and my wife work full time and now only have 1 car to get around in because the truck had to be diagnosed first before a rental could be granted, if they even give me one. Still waiting to hear back about getting a rental and been 2 weeks without a truck.

Filed Aug 6, 2023 · Fuel system · PA

RE: FCA Recall #Z46; the federal safety agency #22V‑406 Premature High Pressure Fuel Pump (HPFP) failure recall. It's been approximately 14 months since FCA issued its notice for a voluntary safety recall on inspection/replacement of the HPFP for my vehicle and no action has been taken by the manufacturer as of this date. The dealership still indicates that no repair parts are available.

Filed Jul 17, 2023 · Engine · NY

Noticeable engine noise experienced with my Ram 1500 Eco diesel. My local dealer diagnosed the noise to be coming from the high pressure fuel pump that there is an open recall on for over a year. Dealer cannot make repairs without the parts available. Looks to be they are now. Recall this is referenced too: 22V‑406

Filed Jun 21, 2023 · Fuel system · WI

My truck has the Z46 manufacturer recall and the NHTS 22v-406 recall for "High Pressure Fuel Pump failure". No parts are available for repair. the recall states " A HPFP failure may introduce internally failed component debris into the fuel system potentially causing fuel starvation. Fuel starvation may result in an unexpected loss of motive power, which can cause a vehicle to crash without prior warning." I pull my camper to remote parts of the country. my fuel pump, at time to time would make "noises" that had me concerned. I found a reputable Diesel repair shop that had a OEM part that would solve the recall. For reimbursment I needed 1)parts 2)Labor3)taxes4)related costs5)contact info. I submitted all this info to [email protected] on June 5. June 7 I was denied due to "out of warranty" proved I was not. On June 7 I was denied because parts were not covered, I showed them that they were OEM. On June 12 I was again denied this time because they did not like the way the clerk wrote the repair order diagnosis. I told them the dignosis was Z46 NHTS22-v406. They refused compenstion and anymore appeal. I followed all the rules, repaired my truck so it would not be a significant road hazard to me or others and expect compensation of $2210.75. Please help me, and others get compensation for doing the right thing while Stellantis nad FCA "wait for parts"