2019 Toyota Highlander: misfire or rough idle

Filed Jul 11, 2026 · Engine · MA

The car is was a 2019 Toyota Highlander with approximately 125,000 miles. White Smoke started appearing in the exhaust. Quickly after that, the check engine light appeared and started blinking, meaning the engine was misfiring. We brought to the dealership, and they found that cylinder 4 of the engine was damaged (scoring on the inside of the cylinder wall). The engine was releasing metal particles in the oil. Further, the cylinder would not hold oil or coolant pressure, and was burning both oil and coolant. The only fix was to replace or rebuild the engine.

Filed Jul 29, 2025 · Transmission · WA

I’m reporting a drivetrain and engine performance issue affecting my 2019 Toyota Highlander, which I believe is related to Toyota's T-SB-0160-18, T-SB-0008-21, and Customer Support Program ZJC (CSP ZJC). My vehicle is exhibiting the same symptoms like: 1. Intermittent engine misfires (no consistent CEL, but noticeable during driving) 2. Hesitation and shuddering during light or moderate acceleration 3. Unintended surging/lunging — the vehicle will randomly jerk forward without throttle input 4. Whining noise under acceleration, which appears to come from the engine bay These symptoms negatively affect vehicle control and driver confidence, especially when merging, passing, or driving in traffic. The behavior is unpredictable and poses a potential safety hazard. After researching, I found that Toyota issued T-SB-0160-18 and T-SB-0008-21 for this engine, acknowledging similar performance issues due to valve train irregularities and ECM programming. Toyota also released Customer Support Program ZJC, offering limited support to some VINs. However, despite my vehicle showing the same symptoms, it is not included in the CSP, and Toyota has not offered assistance without out-of-pocket costs. This issue appears to be more widespread than Toyota’s internal VIN list suggests. Many Highlander owners have reported the same issues online, and I believe Toyota should take responsibility for correcting these performance defects under a recall, not a limited CSP. I respectfully request that the federal safety agency investigate the scope and validity of Toyota's CSP ZJC and TSBs related to the 2GR-FKS engine and push Toyota to expand CSP ZJC or issue a formal recall to cover all affected vehicles based on symptoms, not just VINs

Filed Feb 19, 2025 · Electrical, Engine · MO

[XXX] Dear staff there are other people complaining of ENGINE MISFIRE also [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 17, 2025 · Acceleration, Engine · MO

ENGINE CHECK LIGHT coming on constantly Cylinder 3 misfire reported under DIAGNOSTICS of ADVANCE AUTOPARTS 500 Rte 291, Lee's Summit, MO 64063 another workshop said NO MISFIRE however now it says Engine Misfire 1, 3, 5, 6 4 cylinders misfiring as per diagnostic on 02/15/2025

Filed Aug 21, 2022 · Electrical, Fuel system · VI

I have had my vehicle for a little over 3 years, with about 35K miles on it. At first, I realized my vehicle jerked a bit, but I dismissed it because it never stopped. However, I did notice that my battery was dying quickly. I was changed once by the dealership because they said the battery was defective. After they changed that battery, the next battery also went bad. While driving with my children and mother, my vehicle began sputtering and a message that said, "Check Engine Reduced engine power" came on along with "Traction Control turned off" and my engine light. My vehicle barely accelerated as I was trying to cross the intersection thankfully I managed to get out of the way of oncoming vehicles. Somehow, the vehicle ran smoothly after I turned it off and turned it back. After that issue, I then experienced an error message in reference to the Start/Stop system along with the check engine light. That issue also cleared when I turned my vehicle on and off. I then experienced another power loss issue, at which time I traveled to my local Toyota dealership but they were unable to help me then due to a battery issue. The issue then cleared itself somehow again; however, the issue came back the next day. I managed to get my vehicle to the side of the roadway at which time the vehicle stalled. I tried starting the vehicle again; however, it would not turn over. After being on the roadside for about 2 to 3 hours, I tried starting my vehicle again, and it drove fine until I reached the dealership. My vehicle was placed on a machine where they received the code for a fuel rail issue along with a misfire. I was then advised that this issue is not covered under warranty. I was also told that the problem would cost me over 4K for the part which does not include labor. I have been doing my research since and I now find that there is a recall on my vehicle.