2020 Toyota Highlander: grinding or squealing brakes

Filed Oct 19, 2026 · Brakes, Driver assistance · CA

Thanks for your service, which is much appreciated. I had a terrifying experience with my 2020 Toyota Hylander Hybrid on XXX. I was traveling slowly on the right Eastbound lane of [XXX] trying to exit onto [XXX], when a car suddey merged from my left, near my front bumper. I put on my brakes with enough room to spare to avoid a collision, however the Hylander overrode my controls, slammed on the brakes with a squeal of my tires, stopped my car completely, started doing a slow, repeating beep, and wouldn't move, though the engine was running. This left my husband and I in an active freeway lane with cars traveling in front of us, to the side of us, and coming up behind us, at 65-70 mph., unable to move our vehicle. I had to turn off the engine off and on again, while in the active freeway lane, to get the Hylander to stop beeping and get it to move again so I could drive off the freeway. I was terrified we'd be rear-ended and possibly be killed, since some automated system in the Hylander would not allow the car to move after it took over and slammed on the brakes. I contacted Stevens Creek Toyota in [XXX] soon afterwards hoping to speak with a service manager about what happened. [XXX] I was told that no one was available when I described my issue to a phone receptionist there. She sent me to a manager's voicemail, where I left a detailed message about what happened. I asked that I be called back as soon as possible, to disable whatever feature caused the car to react in such a dangerous way. No one from the dealer ever called me back or offered a solution. I have no idea what to do or where to go, to get this feature disabled, or if it can hopefully be disabled. Please investigate why 2020 Toyota Hylander Hybrids have a feature that takes over the controls, slams on the brakes, then doesn't allow the car to move again until the car is completely turned off and on again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 5, 2026 · Transmission · TN

Vehicle jerked and then a metal grinding sound. Vehicle would then not even roll in neutral on an incline. Had to be towed to dealer. Transmission has a crack in the case. Need a whole new transmission. I was left on the road. No warning whatsoever.

Filed Feb 20, 2026 · Acceleration, Transmission · ME

At approximately 120,000 miles, the vehicle began exhibiting a pronounced shudder or vibration between 40–50 mph under light acceleration or steady cruising. The condition progressed to delayed shifting and intermittent loss of acceleration response. The most concerning issue is hesitation and reduced acceleration when attempting to merge into traffic or increase speed. On multiple occasions, the vehicle failed to respond promptly to throttle input, creating a potential safety hazard due to loss of propulsion. The vehicle was evaluated at two authorized Toyota dealerships. Both indicated that the condition is consistent with torque converter or transmission failure. Full transmission replacement was recommended at an estimated cost of approximately $9,000. No whining or grinding noises are present; symptoms primarily involve shuddering and hesitation. The vehicle has not been driven since October 21, 2025, due to safety concerns and to prevent further damage. The vehicle has been regularly maintained at Toyota dealerships and has not been used for towing. This complaint concerns loss of acceleration, transmission shudder, and potential premature failure of the 8-speed automatic transmission.

Filed Dec 29, 2025 · Transmission · TX

My 2020 Highlander developed a whining or grinding noise consistent with the Technical Service Bulletin. I took it to a Toyota Dealership for diagnostic and they confirmed the whining and hissing sound. They said it would cost $9,000 to repair. I called Toyota to request a goodwill repair and they denied me. Toyota case number: 251229000423. The car does not feel safe to drive. We worry that at any moment the car could break down with our children inside. The problem was reproduced at a dealer and inspected. There were no warning lamps or messages, just the obvious sound coming from the transmission.

Filed Mar 12, 2025 · Transmission · 98,000 miles · MS

The contact owns a 2020 Toyota Highlander. The contact stated that while depressing the accelerator pedal, the vehicle was making an abnormal whining sound. The contact stated that the failure occurred at various speeds. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Technical Service Bulletin: T-SB-0008-21 Whine Or Grind Noise from Transmission (Power Train). The manufacturer was not informed of the failure. The failure mileage was approximately 98,000.