1997 Volkswagen Passat problems

Filed May 7, 2012 · Electrical · 200,000 miles · CA · fire

Tl* the contact owns a 1997 volkswagen passat tdi. The contact stated that a fire erupted spontaneously inside the dashboard which caused all of the wires to melt and the windshield to fracture. The fire department was contacted who determined that the fire started in the area where the ignition was located. No injuries were reported. The vehicle was not taken to the dealer. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure and current mileage was 200,000. Updated 6/12/12 *cn the consumer stated the fire occurred in the area of the ignition and locking components were service, replaced and removed 15 days before the fire. The fire dept determined the fire started in the ignition.

Filed Sep 2, 2008 · Electrical, Visibility · 60,000 miles · CA

Tl*the contact owns a 1997 volkswagen passat. Whenever the contact attempted to activate the windshield wipers or headlights, they failed to turn on. The vehicle has not been diagnosed by the dealer. There were no warnings prior to the failures. The current mileage was 62,000 and failure mileage was 60,000.

Filed Jun 9, 2008 · Visibility · 157,000 miles · VA

Tl*the contact owns a 1997 volkswagen passat. While parking the vehicle, the contact heard an unfamiliar noise and the air conditioning began to blow hot air. He exited the vehicle and discovered water leaking from the undercarriage. He believes that the heater core may have failed. The current and failure mileages were 157,000.

Filed Feb 27, 2008 · Engine · 38,000 miles · PA

Tl*the contact owns a 1997 volkswagen passat. The contact has taken his vehicle to the garage and the dealer eight times. The engine head was replaced at 42,000 miles and the turbo charge is currently failing. The contact stated that the repairs cost more than the actual price of the vehicle. The dealer stated that the computer needed to be replaced in order to correct the turbo charge. The replacement would cost $1,000. The VIN was verified, but appears to be invalid. The current mileage was 46,000 and failure mileage was 38,000. Updated 03/18/08. *lj updated 03/18/08

Filed Oct 2, 2007 · Visibility · 115,500 miles · DC · 1 injury

On sunday, august 5th, 2007, while driving the car with my 7 year old son in the back seat, dense, noxious 'steam'/smoke began to come out of all vents and around the dash area in my well-maintained volkswagen. Hot coolant also leaked into the passenger compartment of my passat on the driver's side. Note that this occurred while air conditioning (A/C) was on & continued to pour out of vents without A/C on. My 'low coolant' indicator light (red LED in instrument cluster) also began flashing. Fortunately, I was able to get the car (and my son) home without overheating after stopping on the side of a busy washington dc thoroughfare (wisconsin avenue), opening the fogged-up windows, cleaning the interior of the front windshield, and refilling the coolant reservoir/'overflow' tank with antifreeze purchased nearby. Since the 'steam' smelled like coolant/antifreeze, I immediately suspected that this was due to a failure of my car's heater core. I subsequently confirmed this diagnosis after dropping off the passat at my long-time, certified, mechanic, beahm's auto service of silver spring maryland. Beahm's diagnosed, but did not replace my heater core on tuesday, august 7th, 2007 (the heater core has been temporarily bypassed so that the car could be driven without additional coolant loss or of the car's windows/interior). My passat is otherwise in excellent, well-maintained condition with only 116,000 miles, no accidents, and it passed washington dc safety and emissions inspection in august, 2007.

Filed Sep 17, 2007 · Electrical · 86,000 miles · MN

Vehicle volkswagen 1997 passat glx - v6 engine. Full instrument cluster - speedometer, tachometer, fuel gauge, digital clock... Everything on it, does not operate when outside temperature is below 50 degrees. Car must be driven for 10min., or about 8-12 miles, before instrument cluster returns to normal fuction. Car is being driven without functioning speedometer, and it is difficult to estimate my speed and does not feel safe. There were no significant events leading up to the failure, except instrument cluster would make a buzzing noise when car started and trip mileage would reset. This started a few months before complete failure began. This problem gets worse as time passes, as the instrument cluster problem occurs in warmer weather now. Problem used to occur when temperature was below 35 degrees. Now happens at 50 degrees.

Filed Jun 7, 2007 · Visibility · 125,952 miles · IL

Heater core failed- clouding the window to a degree that we nearly had an accident before we could get the car pulled over.

Filed Oct 18, 2006 · Electrical · 100,600 miles · NY

Various electronic components failed while driving--windshield wipers, lights, defrost motor--on a very dark, rainy morning, causing a dangerous situation and a near-accident. Manufacturer previously warned of 'ignition switch failure', but would only repair after failure and before 10 yrs or 100,000 miles. My car has 100,600 miles. Manufacturer refuses to bear the repair cost for this known defect that could have caused a serious accident.

Filed Aug 15, 2006 · Electrical · 85,100 miles · OH

Ignition switch failure while vehicle operational. Same condition was covered under recall on 1996 vw passat models, manufacturer is not offering coverage on same body style under 1997 and 1995 designation. Impacted vehicle is a 1997 vw passat wagon.

Filed May 26, 2006 · Visibility · 132,000 miles · CA

Hot coolant suddenly started coming out of the vents and caused all the windows to fog over. Had to pull of freeway and get a tow. No indication of a problem prior to the failure. Problem turns out to be a bad heater core. Had heater core bypassed because of the cost of the repair.