2004 Volkswagen Passat problems

What is wrong

Volkswagen is recalling 412,000 my 1999-2005 passat (5th generation) vehicles equipped with automatic transmissions and produced after june 14, 1999. These vehicles may have an underbody heat shield that can become damaged. In addition, affected vehicles with automatic or manual transmissions may have a fuel line (1.8t engines only) or fuel tank ventilation valve (4motion/all wheel drive only) that can leak due to fracture.

Risk

A heat shield that may contact the exhaust system can result in a vehicle fire. In addition, a fuel leak from a fuel line or fuel tank ventilation valve, in the presence of an ignition source, can lead to a vehicle fire.

Remedy

Dealers will install additional underbody heat shields on vehicles with automatic transmissions to cover the possibly damaged areas and flash all 1.8t engines with a precautionary software update. Dealers will also inspect and adjust the fuel line routing on 1.8t vehicles and the fuel tank ventilation valve on 4motion/all wheel drive vehicles, and replace components if necessary free of charge. The recall began on june 13, 2008. Owners may contact volkswagen at 1‑800‑822‑8987.

Recall number 08V156000 · Recall details

What is wrong

On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Risk

The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

Remedy

Dealers will install the newly designed brake light switch free of charge. The recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06v‑183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact vw at 1‑800‑822‑8987.

Recall number 07V063000 · Recall details

What is wrong

On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.

Risk

Fuel leakage in the presence of an ignition source may lead to a fire.

Remedy

Dealers will replace the diesel pump. The recall began on february 8, 2005. Owners should contact volkswagen at 1‑800‑822‑8987.

Recall number 04V586000 · Recall details

In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.

EA11002

Volkswagen (vw) is recalling certain vw passat 4motion and audi a6 quattro and allroad quattro all-wheel drive passenger cars.vw vehicles subject to recall were manufactured from november 22, 2000 through may 31, 2005 and audi vehicles subject to recall were manufactured from june 2, 2001 to june 1, 2005.the federal safety agency recall number for the vw vehicles is 08v‑156 (vw also is correcting defects related to heat shield and fuel line hazards for these vehicles and for 1999-2000 passats in this recall action.)the federal safety agency recall number for the audi vehicles is 08v‑157.since 2006, odi has received 17 complaints of fuel leaking from the subject vehicles' fuel tanks.the 400 complaints shown above may include duplicate reports to odi and the manufacturer. While the consequence (fuel leaks from the top of the tank) is similar for both the passat and audi subject vehicles, differences in design and construction require a different remedy for each vehicle.on the passats, the ventilation line could have been installed improperly with tension and with an incorrectly positioned cable tie.the tension could cause cracked or broken nipples on the fuel tank rollover valve.on the audi vehicles, a material change (effective june 2, 2001) with different aging characteristics used for the rollover valve and the use of an inflexible aluminum ventilation line could cause cracking of the nipple on the rollover valve.vw is recalling all vehicles subject to these defects.it will inspect passats to ensure that the vent line is tension free and correct the installation if tension is found.if a crack or fuel leak is found, vw will replace the fuel tank.audi will repair all subject vehicles by reinforcing the fuel tank rollover valve with an epoxy adhesive.this investigation is closed.

PE08008

The manufacturer notified the federal safety agency on 04-apr-08 that a safety recall action would be initiated to remedy the issue.in june 2008, the manufacturer issued a technical service bulletin (code 26e5/r5) regarding the specific procedures to be employed in this campaign.vehicle owner notification letters were sent beginning approximately june 13, 2008.the campaign was assigned the federal safety agency no. 08v‑156.this recall affects all my 1999-2005, 5th generation gasoline-powered passat sedans and station wagons.approximately 412,000 vehicles are affected.corrective action will consist of installing additional exhaust system heat shielding to mitigate the potential thermal effects of engine ignition problems.based on this action, the subject ea has been closed.

EA07014