I was driving and the airbag light randomly came on out of the blue. While trying to parallel park I noticed my steering wheel clicking. We ran codes on the car and we are confident that the clock spring failed. My horn and cruise control also no longer work.
Volkswagen Passat coil spring problems
69 of the 7,709 owner complaints about the Volkswagen Passat describe broken coil spring, most of them for the 2013 model year.
- owner complaints
- 69
- worst model year
- 2013
- typical repair cost reported
- $672
- typical mileage
- 68,000
Is there a fix? There is 1 recall for this area of the car. See below
By model year
Often reported together
Airbag light 19Check engine light 4Steering noise 3Loss of power 3Stalling 2Hesitation 2Door locks 2Won't start 1
What owners say
The contact owns a 2016 Volkswagen Passat. The contact stated that on seven occasions, the clock spring failed while driving at various speeds. The contact stated that there was an abnormal clicking sound coming from the vehicle with the air bag warning light illuminated on the instrument panel. The contact stated that the clock spring was replaced under warranty; however, the failure returned soon after repair. The manufacturer was notified of the failure, and a Corporate Representative was sent to the dealer to test the repair. The representative test driving the vehicle also experienced with failure, and the clock spring fractured while operating the vehicle. The vehicle was not yet repaired. The failure mileage was approximately 27,000.
The contact owns a 2013 Volkswagen Passat. The contact stated that while driving approximately 40-60 MPH and driving over the roadway, the rear coil spring fractured. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, and it was confirmed that the VIN was not under recall. The approximate failure mileage was 177,000.
The contact owns a 2013 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, the contact noticed that the instrument panel became inoperable. The contact stated the multiple warning lights would inadvertently illuminate with no warning light illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the clock spring failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 80,000.
While making a U turn the clock spring broke, the air bag light came on and the steering wheel controls no longer function. This is the third time it has broken in this vehicle.
Clock spring has failed 5 times within a year. The first clock spring replacement failed two weeks after the repair. I the. took it to a different dealership to be repaired. The second clock spring broke about 6 months later. The third clock spring broke two weeks after the repair. The fourth clock spring broke two months later and I am about to have it repaired within the next week. Due to the faulty clock spring, the driver side air bag will not deploy in the event of an accident and I have no use of the horn - both of which are necessary when living in South Florida. There are only two dealerships within reasonable driving distance to have the repair done (while the part is under warranty). It takes at least a week, if not more, to get an appointment at the dealership to ensure they have the part at the time of the repair. During which time, I have no choice but to drive the vehicle without the use of the air bag. Even though I can tell when the clock spring is likely about to break, I cannot take it to the dealership for repair until it has actually broken. This is not only extremely inconvenient, but hazardous as I’d be without safety mechanisms in the event of an accident. This should not be a reoccurring issue with the vehicle. The dealership has gone as far as contacting VW support to ensure the correct part is replaced and repaired properly, yet it continues to happen. It is unrelated to my driving or the way the part has been repaired. It is simply faulty parts being supplied.
Day of purchase (Feb2020)Nox sensor went out on way home. Check engine light came on took back to VW dealership they fixed for free. Next component to go bad or become faulty was and still is the fuel door actuator when raining or washing off the car will get wet and fuel door will not open. Reported it to VW dealer after the issue arose at which time I was told it was not covered under the emissions warranty even though it’s listed. Next issue was clock spring broke and had to have VW repair the clock spring. This they did free of charge. Then issues arose with first blinkers bulbs blowing and randomly ceasing to work. It has progressed from blinkers ,to back up lights and tag lights. Recently the OBD displayed a Adblu Error 200 miles to no engine restart. Then it dropped to 50 miles. Then zero at which time the OBD flashed red and car would not start. Filled adblu waited few hours car started up no codes showing on dash. Get on interstate and with little time it flashes the same messages Adblu Error 200 miles to no engine restart. Then to 50 miles down to 10 miles turning red at 0 miles No engine Start. As of 6 days ago I have recently learned of a recall made by VW regarding the Approved Emissions Modification being faulty leading to the exact symptoms the car displays regarding the adblu(DEF system). VW dealer refuses to acknowledge that the recall fix needs fixing since they reported to have fixed it already. All of the issues that we have had with the NOx sensor, clock spring, exterior lighting , fuel door actuator, and the def system corrected approved modification, has been part of a recall that was supposedly already performed prior to the purchase. Now the def system is not working properly due to the malfunctioning of the AEM software. Def injector have clogged due to crystallization of adblu , a affect of inadequate injection from the faulty AEM. Emission mod decals under hood are not in proper locations nor properly filled.
Rear coil spring is broken. Normal driving conditions and we noticed a significant vibration. Upon inspection of rear suspension we found a broken rear coil spring. I researched this issue and found that VW recalled several other 2015 models for rear coil springs breaking. This is a major safety issue. Currently we cannot use the car due to this safety issue.
The clock spring broke again only four years from being repaired with the last recall.
steering wheel clock spring failed
Related recalls
Suspension: front
- What is wrong
- Lock nuts used to hold the left and right front axles to the suspension struts may not have been properly manufactured. The lock nuts may break and cause separation of the axle from the suspension struts.
- Risk
- Separation of the axle can cause the vehicle to pull tothe side of the separation and result in loss of vehicle control and anaccident.
- Remedy
- Replace the lock nuts.
Recall number 93V118000 · Recall details
Questions about the Volkswagen Passat coil spring
Which Volkswagen Passat years have broken coil spring problems?
The model years with the most reports are 2013 (16 complaints), 2012 (15 complaints) and 2015 (14 complaints).
How much does it cost to fix broken coil spring on the Volkswagen Passat?
Owners who mentioned a price put the repair at about $672 (median of 5 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Volkswagen Passat?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history