On 9/20/2026 all of the roof-rail (side-curtain) airbag inflators spontaneously ruptured and deployed with explosive force while the vehicle was stationary. The event was triggered solely by shutting the vehicle's driver’s side door hard. There was absolutely no collision, impact, or external force applied to the vehicle that would justify a normal airbag deployment. The inflator body split tearing through the interior headliner. This identical failure mechanism matches existing GM safety campaigns (such as the federal safety agency Campaign 21V504000) concerning roof-rail airbag inflators suffering from internal manufacturing corrosion and thermal cycling stress. My local Chevrolet/GMC dealership ran my 17-digit VIN and stated that my specific truck is currently omitted from the active recall batches. When the physical rupture was presented to them, the dealership refused to honor a remedy, improperly citing the vehicle's age and mileage. Because this structural manufacturing defect poses an extreme risk of severe injury or shrapnel deployment to occupants in an un-crashed vehicle, I am requesting that the federal safety agency investigate this VIN omission and compel General Motors to expand their recall parameters to cover this vehicle.
The worst 2015 Chevrolet Silverado 2500 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Electrical58
- Brakes37
- Transmission20
- Fuel system19
- Airbags17
- Steering17
- Engine12
- Lights9
- Visibility9
- Seat belts7
- Body6
- Tires4
- Suspension3
- Wheels3
- Acceleration2
- Driver assistance2
- Locks1
Specific symptoms reported on the 2015 Chevrolet Silverado 2500
Loss of power 12Headlights 10Power steering loss 9Check engine light 6Fuel pump 6Stalling 6Won't shift 6Water leak 5
Recalls 6
Air bags: side/window: curtain: inflator
- What is wrong
- General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
- Risk
- A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
- Remedy
- Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1‑888‑988‑7267 or Chevrolet customer service at 1‑800‑222‑1020. This recall supersedes the federal safety agency recall number 20V‑736. GM's number for this recall is N202324251.
Recall number 21V504000 · Recall details
Air bags: side/window: curtain: inflator
- What is wrong
- General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
- Risk
- If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
- Remedy
- GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1‑888‑988‑7267 or Chevrolet customer service at 1‑800‑222‑1020. Note: GM filed a new recall, number 21V‑504 that supersedes this recall. All vehicles previously recalled under 20V‑736 will now be repaired under the new recall number 21V‑504. GM's numbers for this recall are N202309680, N202309681, and N202309682.
Recall number 20V736000 · Recall details
Service brakes, hydraulic: pedals and linkages
- What is wrong
- General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
- Risk
- If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
- Remedy
- GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1‑800‑222‑1020, or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.
Recall number 18V578000 · Recall details
Seat belts: pretensioner
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V‑651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
- Risk
- A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
- Remedy
- GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1‑800‑521‑7300, Cadillac customer service at 1‑800‑458‑8006, Chevrolet customer service at 1‑800‑222‑1020, or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is 17287.
Recall number 17V437000 · Recall details
Seat belts: pretensioner
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
- Risk
- A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
- Remedy
- GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1‑800‑521‑7300, Cadillac customer service at 1‑800‑458‑8006, Chevrolet customer service at 1‑800‑222‑1020, or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is 16007.
Recall number 16V651000 · Recall details
Service brakes, hydraulic: pedals and linkages
- What is wrong
- General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
- Risk
- If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
- Remedy
- GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is 20760.
Recall number 16V069000 · Recall details
See all 6 recalls for the 2015 Chevrolet Silverado 2500
Defect investigations
Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
EA21002
Technical service bulletins for the 2015 Chevrolet Silverado 2500 2,387
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Unknown or other
- This PI provides Diagnostics tips on how the LIN bus works and how to diagnosis it.
- Unknown or other
- This PI provides diagnostic tips for diagnosing electric trailer brakes issues.
- PI to help diagnose A/C concern
- Unknown or other
- Unknown or other
- Unknown or other
- Unknown or other
- This PI Communications information on an alternative product dealers can use to perform 19-NA-255: Wax...
See all 2,387 bulletins for the 2015 Chevrolet Silverado 2500
What 2015 Chevrolet Silverado 2500 owners say
Most recent owner complaints, unedited.
Odometer Fraud. The contact purchased a 2015 Chevrolet Silverado 2500. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of the purchase, the mileage was 55,000. However, a Carfax report later revealed that the mileage had previously been reported at 258,000 and 138,000.
I was pulling in my driveway and lost all steering, the wheel wouldn't turn, truck was still running fine no issues but the steering was out. Within 2 minutes the truck was fully engulfed in flames. With the fire starting from the hydroboost/power steering area.
The contact owns a 2015 Chevrolet Silverado 2500. The contact stated that while inspecting the vehicle, the contact became aware that the front driver’s side wheel stud was fractured and the lug nuts on all four wheels were mismatched. Additionally, the front end wobbled while driving over cracks on the roadway. The vehicle was taken to the dealer, who determined that the front driver’s side wheel stud and lug nuts needed to be replaced and scheduled an upcoming appointment for repair. The failure mileage was approximately 180,000.
LT265/60R20 121S E Yokohama Geolander AT4, manufacturer date of 2924. While driving south on Interstate 95, the driver’s side rear tire sidewall blew out, inside sidewall. The tires have approximately 14000 miles on them. There were no sidewall defects noticed approximately 4000 miles prior during a tire rotation. Nothing was hit in the roadway and proper pressure is maintained in all tires. There was no indication, tpms warning, that the tire was losing pressure prior to the blow out. There does not appear to be any damage to the tread area of the tire. Control of the vehicle was maintained to a stop in the breakdown lane. There were no injuries.
Odometer Fraud. The contact purchased a 2015 Chevrolet Silverado 2500 from an auction. It was later discovered that there was a mileage discrepancy. At the time of the purchase, the vehicle mileage was 73,672. At the time of the vehicle registration, it was discovered that the mileage was 239,567.
What component or system failed or malfunctioned, and is it available for inspection upon request? Truck caught fire in driveway about 5 minutes after parking truck and turning off engine. Truck is still in spot it burned and available for inspection. How was your safety or the safety of others put at risk? If I had been in truck when it caught fire, I could have burned. Has the problem been reproduced or confirmed by a dealer or independent service center? NA Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No
The contact owns a 2015 Chevrolet Silverado 2500. The contact stated that while driving approximately 65 MPH with the rear defroster activated, there was an electrical burning odor inside the cabin of the vehicle before the rear window cracked and then shattered. The cause of the failure was not yet determined. The local dealer and the manufacturer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in the Extended Warranty Coverage related to the failure. The rear window was replaced by the local glass repair shop. The contact stated that the failure reoccurred while driving, and the rear window shattered while a grandson was seated in the rear seat. During the failure, there was no injury sustained. The cause of the failure was not yet determined. The failure mileage was approximately 85,000.
The contact owns a 2015 Chevrolet Silverado 2500. The contact stated that while driving approximately 50 MPH, the vehicle started to vibrate and shudder abnormally. There was no warning illuminated. The contact continued driving at approximately 30 MPH. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact had another 2015 Chevrolet Silverado 2500 in 2025, and the vehicle experienced similar symptoms before the transmission failed. The contact stated that the vehicle was towed to a dealer, who advised that this was a known failure with the 6-speed transmission. The contact was informed by the dealer that the torque converters were too small for the transmission. The manufacturer was not informed of the failure. The failure mileage was approximately 109,000.
My pickup truck has a Duramax diesel engine with a CP4 diesel injection pump. That pump has not failed yet in my truck. However it has been known to fail in numerous other GM vehicles with Duramax engines and when it does fail the engine comes to a complete stop and cannot be restarted. This is a potentially hazardous even fatal situation. Repair if the pump fails is very expensive - $12,000 to $14,000 in some cases. I would like GM to replace the injection pump at my dealership to ensure this known failure does not occur. My pickup truck is otherwise in excellent condition.
Compare the 2015 Chevrolet Silverado 2500
Silverado 2500 vs Ford F-250 SDSilverado 2500 vs Ram 2500Silverado 2500 vs GMC Sierra 2500
Other model years
199419951996199719981999200020012002200320042005200620072008200920102011201220132014201520162017201820192020202120222023202420252026
Questions about the 2015 Chevrolet Silverado 2500
Is the 2015 Chevrolet Silverado 2500 reliable?
Owners have filed 179 complaints about the 2015 Chevrolet Silverado 2500, 1.7 times a typical Silverado 2500 model year.
What is the 2015 Chevrolet Silverado 2500 year score?
The 2015 Chevrolet Silverado 2500 scores 51 out of 100 (below average). The score compares it with the other model years of the Chevrolet Silverado 2500: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2015 Chevrolet Silverado 2500?
Electrical system, with 58 complaints, typically around 4,406 miles. Next is brakes (37).
How many recalls does the 2015 Chevrolet Silverado 2500 have?
6 recalls, covering air bags, service brakes, hydraulic and seat belts.
What year does the Chevrolet Silverado 2500 have the most electrical problems?
The Chevrolet Silverado 2500 model years with the most electrical complaints are 2004 (105 complaints), 2005 (98 complaints) and 2003 (86 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Chevrolet Silverado 2500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history