18-NA-383 That is the bulletin number from the federal safety agency in regard to the rear power window leaking even after it was repaired at Koons Chevrolet in White Marsh, MD. Apparently, this is a known problem that Chevy knows about but has not done nothing to fix the problem. Customers pay good money for the trucks and expect the manufacturers to own up to their faults.
The worst 2020 Chevrolet Silverado 2500 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Transmission33
- Brakes20
- Electrical18
- Engine14
- Fuel system11
- Tires10
- Steering9
- Body6
- Acceleration4
- Driver assistance2
- Lights2
- Locks2
- Airbags1
- Seats1
- Suspension1
- Visibility1
- Wheels1
Specific symptoms reported on the 2020 Chevrolet Silverado 2500
Recalls 10
Power train: automatic transmission: fluid/lubricant: valves/valve body
- What is wrong
- General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
- Risk
- Rear wheel lock up increases the risk of a crash.
- Remedy
- Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1‑800‑462‑8782 or Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on on February 12, 2026.
Recall number 26V083000 · Recall details
Power train: automatic transmission: fluid/lubricant: valves/valve body
- What is wrong
- General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
- Risk
- Rear wheel lock-up can increase the risk of a crash.
- Remedy
- Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1‑888‑988‑7267, Cadillac customer service at 1‑800‑458‑8006, GMC customer service at GMC 1‑800‑462‑8782 or Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is N242454440.
Recall number 24V797000 · Recall details
Latches/locks/linkages: tailgate: latch
- What is wrong
- General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.
- Risk
- An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.
- Remedy
- Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or GMC customer service at 1‑800‑462‑8782. GM's number for this recall is N232426400.
Recall number 24V060000 · Recall details
Tires: temporary/emergency spare tire
- What is wrong
- General Motors, LLC. (GM) is recalling certain 2020-2021 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with a 17" spare tire (RPO ZHQ or ZXT) and either the 20" accessory road tire (RPO REM) or the 18" accessory road tire (RPO Q2V). Operating the spare tire with other 20" or 18" tires can prevent the Anti-Lock Braking System (ABS) from engaging.
- Risk
- An ABS system that cannot control the rear wheels independently increases the risk of a crash.
- Remedy
- Dealers will provide the appropriate spare tire and apply a new spare tire information label, free of charge. Owner notification letters were mailed on October 18, 2021. Owners may contact Chevrolet customer service at 1‑800‑222‑1020; GMC customer service at 1‑800‑462‑8782. GM's number for this recall is N212329780.
Recall number 21V578000 · Recall details
Seat belts: critical fasteners
- What is wrong
- General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.
- Risk
- If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.
- Remedy
- GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1‑800‑462‑8782, Chevrolet customer service at 1‑800‑222‑1020. GM's number for this recall is N202314670.
Recall number 20V792000 · Recall details
Power train: driveline: driveshaft
- What is wrong
- General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle is moving.
- Risk
- If the driveshaft separates, there may be a loss of propulsion, increasing the risk of crash.
- Remedy
- GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or GMC customer service at 1‑888‑988‑7267. GM's number for this recall is N202314870.
Recall number 20V650000 · Recall details
Air bags: side/window: curtain: inflator
- What is wrong
- General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag (RRAB) inflator may not have been properly crimped to the inflator and could separate from the inflator during air bag deployment.
- Risk
- If the diffuser separates from the inflator during deployment, RRAB performance may be degraded, increasing the risk of injury in a crash.
- Remedy
- GM will notify owners, and dealers will replace the suspect RRAB modules, free of charge. The recall began September 3, 2020. Owners may contact Chevrolet customer service at 1‑800‑630‑2438, Cadillac customer service at 1‑800‑333‑4223, or Buick customer service at 1‑800‑521‑7300. GM's number for this recall is N202305380.
Recall number 20V446000 · Recall details
Latches/locks/linkages: hood: latch
- What is wrong
- General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles previously recalled under 20V‑142. Some of the vehicles in 20V‑324 were not part of Recall 20V‑142 but received defect parts during another service (typically during collision repair). The hood-latch striker wires on replacement hoods installed for Safety Recall 20V‑142 may not have been heat-treated properly, possibly causing them to fracture.
- Risk
- If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will replace the hood assembly, free of charge. For hoods sold over the counter, dealers will contact customers with instructions for hood replacement. The recall began July 7, 2020. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or GMC customer service at 1‑888‑988‑7267. GM's number for this recall is N202306490.
Recall number 20V324000 · Recall details
Latches/locks/linkages: hood: latch
- What is wrong
- General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The hood-latch striker wires may not have been heat-treated properly, possibly causing them to fracture.
- Risk
- If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.
- Remedy
- GM will notify owners, and dealers will replace the hood assembly, free of charge. The recall began April 13, 2020. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or GMC customer service at 1‑888‑988‑7267. GM's number for this recall is N192284960.
Recall number 20V142000 · Recall details
Seat belts: pretensioner
- What is wrong
- General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.
- Risk
- A vehicle fire could result if materials ignite inside the vehicle.
- Remedy
- GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1‑800‑222‑1020 or GMC customer service at 1‑888‑988‑7267. GM's number for this recall is N192270600.
Recall number 19V814000 · Recall details
See all 10 recalls for the 2020 Chevrolet Silverado 2500
Defect investigations
Air Bag Malfunction
On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models), XT4 and MY 2021 Escalade, Suburban, Tahoe, Yukon SUVs.Technical Service Bulletin (TSB) 21-NA-005, issued in March 2021, addresses air bag MIL illumination with diagnostic trouble codes (DTCs) B0001-1B or B0012-0D. It cites rust particles in the connection terminal interface of the driver air bag inflator housing as the cause of the air bag MIL illumination. Illumination of the air bag MIL under these circumstances may result in a non-deployment of the frontal driver air bag during a frontal collision and increased risk of injury to the driver.GM stated a correlation exists between production delays due to the pandemic shutdown and premature corrosion initiation on the surface of the air bag inflator housing, which, in some cases, caused rust development during a seven (7) month period of vehicle production. In the rare instance when a rust particle dislodges from the driver air bag inflator housing and enters the air bag connector prior to assembly, an intermittent resistance spike at the air bag connector may result. The condition generates excessive resistance in the air bag electrical system when the steering wheel horn cover is manipulated or the steering wheel is turned. This excessive resistance is momentary. A crash commanding air bag deployment would need to occur exactly when the momentary excessive resistance occurs. Thus, there is a very low likelihood the hazard will present a risk during a crash of sufficient severity to warrant a commanded deployment. This failure mechanism occurs early in life and results in an air bag MIL illumination that corresponds to a DTC warning the driver that the vehicle requires service. The vehicle's air bag remains functional while the MIL is illuminated, and the DTC is present.Once the connection of the driver air bag module to the clockspring is made at the plant, or at the dealership for service, there is no longer an opportunity for rust migration into the connection point. The connector is sealed and has gold terminals, eliminating the expectation of fretting corrosion. All subject vehicles passed standard corrosion validation testing for extensive corrosion with no issue of air bag non-deployment.There is a low rate of occurrence: 1.41 incidents per thousand vehicles (IPTV) for all related occurrences, and 0.04 IPTV for occurrences with a mention of visible rust and/or corrosion on the air bag inflator housing. The average occurrence mileage for the subject vehicles is approximately 2,100. Every occurrence related to the alleged defect experienced an air bag MIL illumination and there are no verified allegations of air bag non-deployment within all data sources.To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate, and the nature of early-life failure, the high detectability of failures, and low potential hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at under the following identification numbers: 11537927, 11528888, 11525020, 11521401, 11506057, 11493107, 11486767, 11441525, 11433146, 11425658, 11423440, 11385267, 11376429, 11373466, 11366995.
PE21010
Technical service bulletins for the 2020 Chevrolet Silverado 2500 1,402
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- This service bulletin provides information about GM Accessories
- Unknown or other
- Unknown or other
- Unknown or other
- This PI communicates information that Engineering has released an updated Trailer Lighting Control Module...
- • Improvements to OnStar functionality.
- This PI provides Diagnostics tips on how the LIN bus works and how to diagnosis it.
- Unknown or other
- This document assists GM dealer technicians with diagnosing torque converter concerns to ensure torque...
- Unknown or other
See all 1,402 bulletins for the 2020 Chevrolet Silverado 2500
What 2020 Chevrolet Silverado 2500 owners say
Most recent owner complaints, unedited.
Trailer brakes keep disconnecting and connecting . Warning pops up on dash to check trailer connections. I may not happen for a hundred miles or does it 10 or 12 times in just a few miles.I've seen several complaints from on line reports but no solutions from GM yet. Very frustrating when trying to pull a trailer.
While driving on the highway our transmission cooling line completely separated at rubber hose to metal line crimp. This cause transmission fluid to burst out all over the vehicle including the windshield and trailer. Vehicle immediately stopped pulling and we barely were able to get to the side of the road. This also caused a catastrophic transmission failure costing approximately $10,000 to repair. GM covered some of the transmission cost but still left us with $5000 bill for a transmission line defect on a vehicle under 100,000 miles. This created a unsafe condition with the trans fluid on the windshield and immediate loss of drive. All maintenance was performed per manufacturers specifications and no warning signs/lights/leaks provided prior to the failure. I do have pictures of the failed transmission cooling line.
The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving 20 MPH and depressing the brake pedal, the vehicle was making a squealing noise. The failure was a recurring failure. The contact associated the failure with Technical Service Bulletin: 20-NA-020. The dealer was contacted and replaced the brake pads to fix the vehicle; however, the failure persisted. The manufacturer was contacted by phone and was made aware of the failure. The failure mileage was approximately 12,000.
The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that the transmission shuddered and hesitated while driving 55 MPH or at higher speed. The vehicle was taken to the dealer; however, the dealer was no longer in business. While driving at various speeds, the lifters were squeaking. The vehicle was taken to a dealer and was diagnosed with lifters failure. The contact decided not to repair the vehicle. The manufacturer was informed of the failure. The failure mileage was approximately 170,000.
My vehicle was taken to Legacy Chevrolet of Waxahachie where a routine recall notice was addressed. During the process they technician broke my battery terminal. Upon my discovery the dealership claimed the broken terminal must have just broke on its own during the time it was at their dealership in spite of the ECM module update requiring the technician to specifically remove the battery cable from that specific terminal. Legacy has refused to address this issue and charged me for the new batteries as well as for the tow that was required. The damage was caused by their technician and all of the costs incurred should have been absorbed by the dealership.
2 of the 4 Balance weights from Front Axle Propeller Shaft have become detached from their welds. Found on chassis during routine maintenance and visual inspection. Truck was just outside window of recall N202314870, Contacted GM Customer care to confirm no recall work was preformed and vehicle is outside of window of the referenced recall. Vehicle scheduled for evaluation/repair by GM Dealer 9/14/26 approx. 84000miles
The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the transmission was slipping and shifting hard. The contact associated the failure with the federal safety agency Campaign Number: 26V083000 (Power Train); however, the VIN was not included. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 120,000.
The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the tailgate independently opened. The contact associated the failure with the federal safety agency Campaign Number: 24V060000 (Latches/Locks/Linkages); however, the VIN was not included in the recall. The dealer was contacted, but the vehicle was not diagnosed or repaired because the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 118,000.
The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at undisclosed speeds and towing a trailer, the message "Trailer Brake Disconnected" was displayed with an audible chime. The vehicle was inspected by the dealer, but no fault was found with the vehicle. Upon investigation, the contact discovered Service Update Program: N232414840; and associated the failure with the service update. The dealer and the manufacturer confirmed that the vehicle was not included in the program. The vehicle was not repaired. The failure mileage was approximately 126,000.
Compare the 2020 Chevrolet Silverado 2500
Silverado 2500 vs Ford F-250 SDSilverado 2500 vs Ram 2500Silverado 2500 vs GMC Sierra 2500
Other model years
199419951996199719981999200020012002200320042005200620072008200920102011201220132014201520162017201820192020202120222023202420252026
Questions about the 2020 Chevrolet Silverado 2500
Is the 2020 Chevrolet Silverado 2500 reliable?
Owners have filed 110 complaints about the 2020 Chevrolet Silverado 2500, close to a typical Silverado 2500 model year.
What is the 2020 Chevrolet Silverado 2500 year score?
The 2020 Chevrolet Silverado 2500 scores 67 out of 100 (average). The score compares it with the other model years of the Chevrolet Silverado 2500: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2020 Chevrolet Silverado 2500?
Transmission and drivetrain, with 33 complaints, typically around 81,381 miles. Next is brakes (20).
How many recalls does the 2020 Chevrolet Silverado 2500 have?
10 recalls, covering power train, latches/locks/linkages and tires.
Was there a recall on the 2020 Chevrolet Silverado 2500 transmission?
Yes, 3 recalls: 26V083000, 24V797000, 20V650000. Check your VIN to see if your car still needs the free repair.
What year does the Chevrolet Silverado 2500 have bad transmission?
The Chevrolet Silverado 2500 model years with the most transmission complaints are 2024 (36 complaints), 2020 (33 complaints) and 2006 (32 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Chevrolet Silverado 2500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history