2018 Chrysler Pacifica: engine overheating

Filed Nov 2, 2026 · Electrical, Engine · PA

I originally took my car to Reedman toll in 2021 due to frequent issues with the batteries needing to be replaced and the car not starting. At the time I was told it was related to a recall, and they fixed it. However, over the last year I have continued to have various problems with the car. The batteries were replaced numerous times. The check engine light and stop start unavailable light going on randomly. The car also started having electrical issues like the radio would just turn off on its own, or the automatic car doors would not open. The car also started feeling jumpy and shaky upon starting, and when the car is off there is a thumping noise. This thumping noise is still heard when the car has been off and parked for hours. The car will be off and I will get in it and hear the thumping before the car starts. Over the summer the problems became more frequent, and on August 31st it would not start, and I had to have it towed to Reedman. Reedman said my started was bad and also the fuse box shorted. They had my car for 10 days, and during this time I paid $500 out of pocket for a rental. I paid $2000 to Reedman for these repairs. I got the car back, and immediately (same day) experienced the exact same problems, and then my car would not start again. When I did get it started I kept getting warnings that the engine might overheat. I got it back to Reedman and they then said it was a bad alternator and some wires were bad as well. They had my car for 2 months. I picked it up 9/30/26 and within less than 6 hours the check engine light and start stop unavailable light came on. The car started feeling jumpy again upon starting, and the thumping noise returned. This car was purchased brand new in 2018 and only has about 51,000 miles on it. I do not understand why this is all happening to a car that has such low mileage. My 2014 Nissan has never had a single problem.

Filed Oct 27, 2026 · Transmission · MI

The engine powertrain system failed, specifically a catastrophic failure of the cylinder head gaskets alongside a stretched engine timing chain. The replaced components were discarded by the repair facility following the completion of the service and are not available for inspection. The failure caused a sudden, severe engine malfunction accompanied by a rough idle and immediate loss of smooth powertrain operation. Sudden engine failures of this nature create a severe hazard when operating on backroads or public highways, as they can cause unexpected stalling, a complete loss of motive power, or sudden deceleration in active traffic, significantly increasing the risk of a collision. The diagnosis of the blown head gasket and stretched timing chain was formally confirmed and documented by an independent service center (Rusty's Auto Service, Repair Order #118288). The vehicle has not been inspected by the manufacturer, police, or insurance representatives. It was inspected and repaired strictly by the independent service center. The vehicle experienced a sudden, momentary rough idle and rapid coolant loss without any prior overheating indications or warning lights. These symptoms appeared immediately prior to bringing the vehicle in for a professional diagnostic inspection.

Filed Sep 22, 2026 · Engine · IL

Head gasket blown! Vehicle is under 100k miles, never overheated, service properly maintained. When researching symptoms, I discovered I am one of hundreds if not thousands of 2017-2018 model Pacifica owners who have suffered this issue. Heads are known to be faulty and Chrysler will not address the root of it. It's very possible this could lead to a locked engine while driving and cause harm to driver or others.

Filed Sep 11, 2026 · Engine · GA

We had to replace both head gaskets last July with only 70,000 miles on the vehicle. The repair cost was $4,600.00. This August, we started experiencing coolant leaks again. We discovered the cylinder heads are warped now. This was checked last year and it was not the main issue then. It is extremly disappointing that now at 80,000 miles we are looking at another $5000.00+ repair. There needs to be a recall on the engine cylinders and head gasket.

Filed Aug 23, 2026 · Engine · NC

This report is for a 2018 Chrysler Pacifica with 90,100 miles. The check engine light came on in July 2026. It was a cylinder 5 misfire. The spark plugs and ignition coil were replaced. The check engine light came on again about 2 weeks later (cylinder 5 misfire again), was dismissed and reset by the shop, and came on again about 2 weeks later. This time, the shop diagnosed cylinder 5 misfire due to "cylinder 5 is leaking coolant into the cylinders." They quoted $12,000 for engine replacement. Went for 2nd opinion at a Chrysler dealership. They confirmed cylinder 5 misfire due to coolant leaking into cylinder 5. Cylinder 5 had low compression. Tech recommended replacing cylinder head for $6200. My research shows that this issue is common for the Pacificas, so I reached out to both Chrysler and the dealer for goodwill assistance with the repair. It was declined due to the van being older than 2019. I cannot continue to drive it with this issue, due to the safety risk of engine failure while operating.

Filed Jul 22, 2026 · Engine · NJ

I bought my 2018 Chrysler Pacifica Touring van in February 2018 brand new from Burlington Chrysler, Burlington, NJ. In May 2026 the check engine light came on and I brought the van to my mechanic. The code he pulled was for #5 cylinder. I had the repair done. A month later in June of 2026 the che ck engine light came back on and this time the code was for the catalytic converter. On July 21, 2026 I brought the van back to my mechanic for an oil change and replacement of catalytic converter. When they put the van up, it was discovered that coolant had leaked all through the exhaust system and my mechanic suspected there was a crack in the head gasket. He searched through the Pacifica Forum online and found many, many complaints about this same issue. My mechanic completed the oil change and filled the car with coolant because it had none and advised me to bring the car to the dealership which I did. On July 22, 2026 Chrysler called and advised I need an entirely new motor. I now have to pay out-of-pocket $14,098 + tax for a new motor and catalytic converter. Chrysler advised there is nothing else they could do for me because the car is out of warranty. However, the car is only 8 years old with 76,000 miles and has had all the regular maintenance and oil changes required. It should not need to have the motor replaced at this point unless there's a major defect with these engines. I feel this is a MAJOR safety issue as this head gasket crack occurred without any warning other than the codes for #5 cylinder and catalytic converter failures. Without coolant, the car would have overheated at some point and caused engine failure and power loss. As I drive mainly on highways, this defect had the potential to cause a very bad accident. Due to the overwhelming number of complaints about this issue, I feel this warrants an investigation by your organization.

Filed Jul 1, 2026 · Engine · IL

I own a 2018 Chrysler Pacifica equipped with the 3.6L Pentastar V6 engine. At approximately 81,600 miles, the vehicle developed a check engine light and a Cylinder 5 misfire (P0305). The vehicle began exhibiting hard starts, rough engine operation during cold starts, white smoke from the exhaust, and coolant loss with no obvious external leak. An independent repair facility initially diagnosed the vehicle and found evidence suggesting coolant intrusion into Cylinder 5. The vehicle was then inspected by a Chrysler dealership. The dealership confirmed that coolant was present inside Cylinder 5 using a borescope inspection. The dealership recommended replacement of the cylinder head gasket. The safety concern is that the failure developed with little warning other than a check engine light and intermittent rough operation. The engine misfires on startup and can run rough, which could result in reduced power, hesitation, stalling, or loss of acceleration while operating the vehicle. The vehicle also consumes coolant internally, which may lead to engine overheating or further engine damage if not detected quickly. During my research, I found numerous reports from other owners describing similar coolant intrusion, head gasket failures, and Cylinder 5 misfires in Chrysler vehicles equipped with the 3.6L Pentastar engine. Despite the apparent frequency of these complaints, I am not aware of any recall addressing this issue. In my case, the repair estimate is approximately $5,000 for head gasket replacement. I am submitting this report because coolant intrusion into a combustion cylinder can create a significant safety concern due to engine misfires, loss of performance, and the potential for engine failure while driving. I believe this issue warrants investigation to determine whether a defect exists affecting other vehicles with this engine.

Filed Jun 27, 2026 · Engine · IL

I own a 2018 Chrysler Pacifica with approximately 79,000 miles. The check engine light illuminated, so I had the vehicle scanned at an auto parts store. The diagnostic code indicated a cylinder 3 misfire. After leaving the store, the vehicle quickly began displaying overheating warnings. The overheating occurred suddenly, and the vehicle had been driven very little after the check engine light first came on. Because of the overheating, I had the vehicle towed to a repair shop. The shop initially repaired the vehicle and tested for misfires but reported that they found no remaining issues. However, immediately after leaving the shop, the check engine light returned with the same cylinder 3 misfire code. The vehicle was returned to the repair shop for further diagnosis. After additional inspection, the shop determined that the engine had a blown head gasket. This resulted in major engine damage and the possibility of a complete engine replacement despite the vehicle having only 79,000 miles. I am submitting this complaint because the engine failure occurred unexpectedly and without warning other than the check engine light. The rapid progression from a misfire to severe overheating created a potential safety hazard due to the risk of sudden engine failure or loss of power while driving. I believe this premature engine failure may indicate a defect affecting other 2018 Chrysler Pacifica vehicles.

Filed Jun 20, 2026 · Engine, Transmission · OR

2018 Chrysler Pacifica with the 3.6L V6 engine had a check engine light turn. At same time a vibration started, which was most noticable when the car was in idle. Also, a foggy exhaust started at the same time. No temperature or other warnings were occuring. After driving it to the repair facility the car was not able to be turned on. The findings are that there is a headgasket leak and radiator failure that resulted in coolant entering into the cylinder. That resulted in either hydrolock or engine overheating, causing engine failure. Again no temperature warning or other indication of a major issue was provided. The likely repair is a full engine and radiator replacement. It appears that many other Chrysler Pacifica vehicles have reported similar issues with the 3.6L Pentastar engine. No recall is currently available for the 2018 Chrysler Pacifica for this issue, however, it looks like the older versions (~2011-2013) have had a recall for similar issues. I have reached out to Chrysler Corporate and requested support on this repair.

Filed May 27, 2026 · Electrical, Engine · NJ

What component or system failed or malfunctioned, and is it available for inspection upon request? The alternator snap off while driving on the highway. The snap was clean all bolts are still in the engine block. While driving all kinds of dashboard lights and overheating indicators turned on. How was your safety or the safety of others put at risk? This happens with warning or actions prior to the alternator falling out of the while driving. This put me at-risk of crash and endangering anyone on board, leaving me and family stranded on yhe highway. Has the problem been reproduced or confirmed by a dealer or independent service center? Similar post online with same issues found. Dealer want 80% of the car value to repair and wont help. They recommend changing a cylinder head. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Chryslerbdealer ship inspected. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No signs or symptoms. After the alternator drop off, many issues arise. None prior.

Filed Mar 16, 2026 · Engine · MD

VIN: [XXX] 2018 Chrysler Pacifica Touring L Plus 3.6L Mileage at first failure: 52,930 On November 7, 2024 my 2018 Pacifica began losing coolant (I had to refill it multiple times) and exhibited morning engine shuddering/stuttering. I took it to Century Chrysler Jeep Ram in Mt. Airy, MD (Repair Order #XXX). They performed a 5-hour cooling-system pressure test and borescoped all 6 cylinders. Their notes state: “no coolant was found… no leaks… held pressure for entire 5 hours… could not find any leaks.” They replaced the spark plugs and performed a tune-up (total charged $1,606 after discount). Their own paperwork admits it “could be internal engine issue’s” and “will have to wait till gets worse.” They even wrote an estimate for a cylinder leak-down test but never performed it. The vehicle ran normally for only two days. The shuddering returned and rapidly progressed to complete no-start/stalling (engine would not crank). On December 17, 2024 I took it to Limitless Auto Solutions in Monrovia, MD (another Chrysler-authorized shop, Repair Order #XXX). They removed the intake manifold, all 6 spark plugs and coils to inspect for coolant intrusion. Exact diagnosis: “Rear Cylinder Head Warped – Coolant Intrusion In Cylinders 1 & 3” (Bank 1, rear head closest to firewall). They replaced the complete Bank 1 cylinder head, full gasket set, spark plugs, thermostat, coolant, oil, and related components. Total cost: $6,823.54 (paid in full; 36-month/36k-mile warranty issued). The first dealership’s failure to diagnose the known coolant-intrusion / warped-head defect (despite a 5-hour test + borescope) directly caused the engine to catastrophically worsen, creating a clear safety hazard of sudden stalling or hydrolock while driving. This matches hundreds of identical complaints on 2017–2025 Pacifica 3.6L vehicles. I request a full investigation and recall. Both repair invoices are available upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 26, 2026 · Engine · WA

2018 Pacifica with 3.6L engine. Blown head gasket at 69k miles with coolant leaking into cylinder 5. The engine is very hesitant upon acceleration and can be dangerous when pulling out into traffic. This is an all too common issue and needs to be addressed by Chrysler. Engines should not be failing this at 69k. I change oil every 4k miles which is way ahead of the recommended schedule by Chrysler. Coolant was done by the dealer after radiator replacement for a radiator leak at 52k miles.