2018 Chrysler Pacifica: engine failure

Filed Oct 27, 2026 · Transmission · MI

The engine powertrain system failed, specifically a catastrophic failure of the cylinder head gaskets alongside a stretched engine timing chain. The replaced components were discarded by the repair facility following the completion of the service and are not available for inspection. The failure caused a sudden, severe engine malfunction accompanied by a rough idle and immediate loss of smooth powertrain operation. Sudden engine failures of this nature create a severe hazard when operating on backroads or public highways, as they can cause unexpected stalling, a complete loss of motive power, or sudden deceleration in active traffic, significantly increasing the risk of a collision. The diagnosis of the blown head gasket and stretched timing chain was formally confirmed and documented by an independent service center (Rusty's Auto Service, Repair Order #118288). The vehicle has not been inspected by the manufacturer, police, or insurance representatives. It was inspected and repaired strictly by the independent service center. The vehicle experienced a sudden, momentary rough idle and rapid coolant loss without any prior overheating indications or warning lights. These symptoms appeared immediately prior to bringing the vehicle in for a professional diagnostic inspection.

Filed Oct 13, 2026 · Engine · 38,000 miles · PA

The contact owns a 2018 Chrysler Pacifica. The contact stated that while driving at 30 MPH, the engine seized. The vehicle was able to restart. The dealer was made aware of the failure. The contact was informed that the repair was not covered under an unknown recall associated with the failure because the VIN was not included. The failure mileage was approximately 38,000.

Filed Aug 23, 2026 · Engine · NC

This report is for a 2018 Chrysler Pacifica with 90,100 miles. The check engine light came on in July 2026. It was a cylinder 5 misfire. The spark plugs and ignition coil were replaced. The check engine light came on again about 2 weeks later (cylinder 5 misfire again), was dismissed and reset by the shop, and came on again about 2 weeks later. This time, the shop diagnosed cylinder 5 misfire due to "cylinder 5 is leaking coolant into the cylinders." They quoted $12,000 for engine replacement. Went for 2nd opinion at a Chrysler dealership. They confirmed cylinder 5 misfire due to coolant leaking into cylinder 5. Cylinder 5 had low compression. Tech recommended replacing cylinder head for $6200. My research shows that this issue is common for the Pacificas, so I reached out to both Chrysler and the dealer for goodwill assistance with the repair. It was declined due to the van being older than 2019. I cannot continue to drive it with this issue, due to the safety risk of engine failure while operating.

Filed Aug 13, 2026 · Engine · MN

Failed head gasket that put vehicle in compromised working condition on the roadway - check engine light flash, poor and inconsistent engine running. First indications were 5-10 seconds of rough idle after startup when sitting overnight, then p0303 check engine code for cylinder three misfire as well as loss of coolant. Independent shop confirmed issue and replaced head gasket. Problem appears to have re-occurred after 2 years and 20000 miles with similar indications. Same shop advised likely engine block or cylinder head defect or damage and would not do any tear down or repair short of engine replacement.

Filed Aug 7, 2026 · Engine, Steering · SC

Engine fail with less than106000 miles. Replace brand new engine November 2025. Steering rack has intermittent power issues. It started having steering issue around July 2026. It makes the steering hard to turn during highway speeds.

Filed Jul 22, 2026 · Engine · NJ

I bought my 2018 Chrysler Pacifica Touring van in February 2018 brand new from Burlington Chrysler, Burlington, NJ. In May 2026 the check engine light came on and I brought the van to my mechanic. The code he pulled was for #5 cylinder. I had the repair done. A month later in June of 2026 the che ck engine light came back on and this time the code was for the catalytic converter. On July 21, 2026 I brought the van back to my mechanic for an oil change and replacement of catalytic converter. When they put the van up, it was discovered that coolant had leaked all through the exhaust system and my mechanic suspected there was a crack in the head gasket. He searched through the Pacifica Forum online and found many, many complaints about this same issue. My mechanic completed the oil change and filled the car with coolant because it had none and advised me to bring the car to the dealership which I did. On July 22, 2026 Chrysler called and advised I need an entirely new motor. I now have to pay out-of-pocket $14,098 + tax for a new motor and catalytic converter. Chrysler advised there is nothing else they could do for me because the car is out of warranty. However, the car is only 8 years old with 76,000 miles and has had all the regular maintenance and oil changes required. It should not need to have the motor replaced at this point unless there's a major defect with these engines. I feel this is a MAJOR safety issue as this head gasket crack occurred without any warning other than the codes for #5 cylinder and catalytic converter failures. Without coolant, the car would have overheated at some point and caused engine failure and power loss. As I drive mainly on highways, this defect had the potential to cause a very bad accident. Due to the overwhelming number of complaints about this issue, I feel this warrants an investigation by your organization.

Filed Jul 1, 2026 · Engine · IL

I own a 2018 Chrysler Pacifica equipped with the 3.6L Pentastar V6 engine. At approximately 81,600 miles, the vehicle developed a check engine light and a Cylinder 5 misfire (P0305). The vehicle began exhibiting hard starts, rough engine operation during cold starts, white smoke from the exhaust, and coolant loss with no obvious external leak. An independent repair facility initially diagnosed the vehicle and found evidence suggesting coolant intrusion into Cylinder 5. The vehicle was then inspected by a Chrysler dealership. The dealership confirmed that coolant was present inside Cylinder 5 using a borescope inspection. The dealership recommended replacement of the cylinder head gasket. The safety concern is that the failure developed with little warning other than a check engine light and intermittent rough operation. The engine misfires on startup and can run rough, which could result in reduced power, hesitation, stalling, or loss of acceleration while operating the vehicle. The vehicle also consumes coolant internally, which may lead to engine overheating or further engine damage if not detected quickly. During my research, I found numerous reports from other owners describing similar coolant intrusion, head gasket failures, and Cylinder 5 misfires in Chrysler vehicles equipped with the 3.6L Pentastar engine. Despite the apparent frequency of these complaints, I am not aware of any recall addressing this issue. In my case, the repair estimate is approximately $5,000 for head gasket replacement. I am submitting this report because coolant intrusion into a combustion cylinder can create a significant safety concern due to engine misfires, loss of performance, and the potential for engine failure while driving. I believe this issue warrants investigation to determine whether a defect exists affecting other vehicles with this engine.

Filed Jun 27, 2026 · Engine · IL

I own a 2018 Chrysler Pacifica with approximately 79,000 miles. The check engine light illuminated, so I had the vehicle scanned at an auto parts store. The diagnostic code indicated a cylinder 3 misfire. After leaving the store, the vehicle quickly began displaying overheating warnings. The overheating occurred suddenly, and the vehicle had been driven very little after the check engine light first came on. Because of the overheating, I had the vehicle towed to a repair shop. The shop initially repaired the vehicle and tested for misfires but reported that they found no remaining issues. However, immediately after leaving the shop, the check engine light returned with the same cylinder 3 misfire code. The vehicle was returned to the repair shop for further diagnosis. After additional inspection, the shop determined that the engine had a blown head gasket. This resulted in major engine damage and the possibility of a complete engine replacement despite the vehicle having only 79,000 miles. I am submitting this complaint because the engine failure occurred unexpectedly and without warning other than the check engine light. The rapid progression from a misfire to severe overheating created a potential safety hazard due to the risk of sudden engine failure or loss of power while driving. I believe this premature engine failure may indicate a defect affecting other 2018 Chrysler Pacifica vehicles.

Filed Jun 20, 2026 · Engine, Transmission · OR

2018 Chrysler Pacifica with the 3.6L V6 engine had a check engine light turn. At same time a vibration started, which was most noticable when the car was in idle. Also, a foggy exhaust started at the same time. No temperature or other warnings were occuring. After driving it to the repair facility the car was not able to be turned on. The findings are that there is a headgasket leak and radiator failure that resulted in coolant entering into the cylinder. That resulted in either hydrolock or engine overheating, causing engine failure. Again no temperature warning or other indication of a major issue was provided. The likely repair is a full engine and radiator replacement. It appears that many other Chrysler Pacifica vehicles have reported similar issues with the 3.6L Pentastar engine. No recall is currently available for the 2018 Chrysler Pacifica for this issue, however, it looks like the older versions (~2011-2013) have had a recall for similar issues. I have reached out to Chrysler Corporate and requested support on this repair.

Filed Jun 15, 2026 · Engine · IN

Car has 110k on it with regular documented maintenance. The head gasket is blown and requires new engine.

Filed Apr 20, 2026 · Engine · MI

Head gasket and engine failure at 61,000 miles.

Filed Feb 13, 2026 · Engine · IL

At 120,000 miles the head gasket has started leaking into the cylinders. We are unsure if it is reparable or if I will require a new engine. This is a know problem with Pacificas and is an issue they should be fixing since the problem is on the engine part they installed.