2013 Chrysler Town and Country: fuel pump failure

Filed Mar 11, 2025 · Electrical · 136,000 miles · MI

The contact owns a 2013 Chrysler Town & Country. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. The contact stated that after several attempts, the vehicle started; however, the vehicle lost motive power. The vehicle was started, and the contact turned the vehicle off. The contact became aware that the fuel pump had continued running. The contact, who was a licensed independent mechanic, diagnosed the vehicle with TIPM failure. The vehicle was not repaired. The contact referenced the federal safety agency Campaign Number: 19V813000 (Electrical system); however, the VIN was not included in the recall. The dealer was made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 136,000.

Filed Jul 7, 2024 · Electrical, Engine · VT

Today, we experienced, for the FOURTH time, a complete stall while driving. Accelerator would not work at all. Van died while driving approx 25 mph. We just had the entire fuel pump & fuel pump relay completely replaced. We have replaced both of these twice now, in less than 3 years. Same problem keeps happening. Mechanic agrees, that the core problem lies within a failure of the TIPM system. It's an electrical problem causing the fuel pump to fail while driving. This is extremely dangerous. It happened to us previously, while we were on the interstate driving approx 65 mph, and it almost caused us to crash the vehicle. Another problem to also note, is this same problem has caused the A/C unit to stop working. Blows out hot air, but will not produce cold air. A/C was completely replaced. Still not working. Mechanic says yet again, it's a failure of electrical sources due to the TIPM module. This should be an immediate recall from Chrysler, for 2013 Town N Country Minivan. Over 200 logged complaints of the exact same problem. They manufactured a broken TIPM module in these make & model vehicles. Now, my husband is stranded 200 miles from home, on the side of the road, and it's 98 degrees out. This is 4th time, weve experienced a total power failure. So it doesn't matter if you replace the fuel pump, it will still DIE. We are having this POS towed to our local mechanic, AGAIN. Its available for inspection. Problems have been confirmed by an independent servicer. Check engine remains on. Someone is going to die, if Chrysler doesn't issue an recall for this ongoing problem. The interior power is still on,and engine will turn over, will not start.

Filed Mar 12, 2024 · Fuel system · OH

On multiple occasions, and without warning, the car died while driving creating extremely dangerous and stressful situations. Additionally, the defective fuel pump relay caused the fuel pump to run even when the car was not running. This then caused damage to the fuel pump and required replacing both the relay and pump itself. As the Fuel Pump relay is a single unit soldered together, it could not be independently tested during normal checks. A recall was issues and executed for the same issue on Jeep and Durango models. I also see that this was brought up previously for this T&C model but was determined not to warrant a recall. A known, dangerous, costly, and preventable issue that was corrected elsewhere but not in this model. How is that possible? I've noted approximately the first time I recall the car shutting itself off while driving (this was not the only or last time it happened - nor is it the date of service when we had to pay to have the car repaired).

Filed Jan 22, 2024 · Engine, Fuel system · AL

Started the vehicle and traveled maybe about 50 feet. Noticed loss of power steering. This was due to the engine stalling out. The vehicle would not start and there was a strong odor of fuel fumes in the vehicle cabin. Exited the vehicle and observed a large puddle of oil running downhill from the vehicle. The puddle also smelled of gasoline. I had the vehicle towed to a repair shop. The issue was determined to be a cracked oil filter housing assembly and the clip on the fuel return line had failed causing fuel to be sprayed onto the engine. The repair cost will be just over $800. It is fortunate that the engine was still cold and that the loss of oil caused the engine to shut off. If the engine had been hot enough to ignite the fuel, this could have had tragic results with a potential loss of my family's life. The oil filter housing assembly is a known issue with the Pentastar V6 3.6L engine. Chrysler so far has failed to take responsibility for this issue. I recently had to have repairs due to a faulty fuel pump relay. There appears to be related Chrysler TIPM recalls on almost every other model but the 2013 Town and Country. This issue appears to cause the vehicle to not start or allow the fuel pump to remain running after the vehicle is shut down. My Town and Country would not start and it produced strong fuel fumes. As noted, there are multiple safety issues noted with this model of vehicle that remain unresolved. It is a 2013 model but the issues are ones that have existed since the production of the vehicle and Chrysler has yet to assume responsibility. I will add a copy of the repair invoice shortly.

Filed May 15, 2023 · Electrical · IA

Everyone is having problems with fuel pump relay. Mine is constantly running and draining battery. I have been pulling the fuse everytime I get out of vehicle. There are multiple vehicle jeeps and others that have this same relay and some have been recalled. There has been recalls on plastic part on back lift gates that might come off and hit people. This is fuel.

Filed Dec 21, 2022 · Electrical, Fuel system · TX

Fuel pump continues to run after shut down, draining battery. Related to my other report (11498461).

Filed Dec 4, 2022 · Electrical, Fuel system · MN · 1 injury

What started as an intermittent crank / no start issue quickly progressed to complete failure of fuel pump relay that is part of TIPM. During the first crank no start issue on the day in question I was able to use remote start and the vehicle started normally. (Probably do to slightly higher system voltage as some accessories are turned off during remote start vs pushbutton start). Later the same day is when the complete failure occurred. This could be a major inconvenience for many, but in the harsh Minnesota winters it's more than just inconvenient when you have a wife and young kids in a vehicle away from home that will not start when air temps are in the single digits and wind chill is far below zero. Fortunately / sadly, this is such a common problem that I was able to diagnose it rather quickly with Google, but not before getting a frostbitten finger. I was able to bypass this fuel pump relay by forcing a paper clip into fuse holder M37 and getting keyed power from an alternative source, fuse M25. I don't, however, recommend this fix. What I do recommend is that Chrysler Corporation expand the recall of affected vehicles with this TIPM to include ALL vehicles that this was installed in. In hindsight, a totally unexplained, drained battery overnight while hundreds of miles from home was probably my first sign of this failing relay as it most likely stuck on forcing fuel pump to stay running with ignition off. This occurred 26 days prior to my crank / no start issue. After jump starting and fully charging, battery was tested and passed. Battery resting voltage tested day after crank / no start issue is 12.8V. If I remove relay jumper, crank no start persists.

Filed Jun 27, 2022 · Electrical, Fuel system · 120,000 miles · NC

The contact owns a 2013 Chrysler Town and Country. The contact stated while driving approximately 15 MPH uphill, the vehicle independently stopped. The vehicle was shifted into reverse(R) and the vehicle inadvertently drove forward. There were no warning lights illuminated. The vehicle was diagnosed by an independent mechanic with the check engine warning light illuminated. The mechanic replaced the fuel pump, spark plugs, and alternator. The mechanic stated there might also be a failure with the TIPM. The vehicle was also towed to another independent mechanic who diagnosed the vehicle and determined there was a failure with the fuel line connector and an abnormal clicking noise. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The approximate failure mileage was 120,000.

Filed Jan 25, 2022 · Electrical, Fuel system · PA

The issue is the fuel pump relay which is internal to the total intigrated power modual or tipm. The van wouldn’t start.

Filed Nov 7, 2021 · Electrical · OH

Integrated fuel pump relay went out and horn started sounding and wouldn't turn off. Fuel pump relay won't work and horn relay won't turn off.

Filed Sep 12, 2021 · Electrical, Fuel system · VA

Over a year ago, we began to have a problem in which the vehicle would, on occasion, not start. The “check engine” light would come on, along with another icon that looked like a lightning bolt between two inverted parentheses. Sometimes it started up on the first try, other times it would take a few attempts, and sometimes it would not start at all. Then a new wrinkle emerged: the van conked out on us a few times while on the road -- once while merging onto a highway. We now had a serious (and potentially dangerous) problem on our hands. We had the fuel pump replaced, but the problem persisted. I took the van to our local Chrysler dealership to have them figure it out. They replaced the throttle body and cleaned the fuel injectors and fuel system. I drove the car home without incident, but the following morning, I tried to start it, and the same old situation emerged — the engine cranked but never turned over. I then had it towed back to the dealer for another round of diagnostics. I mentioned that I had seen on the Internet about a possible faulty Totally Integrated Power Module (TIPM), an issue in various Chrysler/Dodge/Jeep/Ram products. Later they called saying the battery was the problem (even though they earlier reported that the battery was okay), and had nothing to do with the TIPM. For about a week, the van is started up without a hitch, but then same old hesitating-before-starting situation reared its ugly head, albeit briefly. It is only a matter of time before it stalls out again in traffic. These vehicles should be recalled and the TIPM needs to be replaced.

Filed Mar 8, 2021 · Engine, Fuel system · 156,000 miles · AL

Fuel pump keeps running after key is removed. Van won't start no fuel. Iratic engine keeps trying to start with key released. Not a constant 3 or 4 times a week. Stationary.